2018 FIAT 500 battery

IN AN EMERGENCY
144
IF THE BATTERY IS
FLAT36)
IMPORTANT The battery recharging
procedure is provided for information
purposes only. You are advised to
contact a Fiat Dealership to have this
operation carried out.
IMPORTANT After turning the ignition
key to STOP and having closed the
driver’s side door, wait at least one
minute before disconnecting the battery
and then reconnecting the electrical
supply to the battery.
Charging should be slow at a low
ampere rating for approximately 24
hours. Charging for a longer time may
damage the battery.
Versions without Start&Stop
(for versions/markets, where provided)
To recharge, proceed as follows:
❒ disconnect the terminal from the
negative battery pole;
❒ connect the charger cables to the
battery terminals, making sure that
polarities are correct;
❒ turn on the charger;
❒ when you have finished, turn the
charger off before disconnecting the
battery;
❒ reconnect the terminal to the
negative battery pole.
Versions with Start&Stop
(for versions/markets, where provided)
To recharge, proceed as follows:
❒ disconnect the connector A fig. 132
(pressing the button B) from the
sensor C monitoring the battery
charge status, on the negative pole
D of the battery;
132DVDF0S0127c
❒ connect the positive cable of the
battery charger to the positive
battery pole E fig. 133 and the
negative cable to the terminal of
sensor D;
❒ turn on the charger. At the end of
the charging process, switch the
battery charger off;
❒ after having disconnected the
battery charger, reconnect
connector A to the sensor C as
shown in fig. 132.
133DVDF0S0128c

SERVICING AND CARE
154
REGULAR
INSPECTIONS
39) 22) 4)
Every 1,000 km or before long
journeys, check and, if necessary, top
up the following:
❒ engine coolant fluid level;
❒ brake fluid level;
❒ windscreen washer fluid level;
❒ tyre inflation pressure and condition;
❒ operation of lighting system
(headlights, direction indicators,
hazard warning lights, etc.);
❒ operation of the windscreen
wiper/washer system, position and
wear of the windscreen and rear
window wiper blades.
Every 3,000 km check and top up if
required: engine oil level.
You are advised to use PETRONAS
LUBRICANTS products, which have
been designed and produced
specifically for Fiat cars (see table
“Capacities” in the “Technical
specifications” section).
DEMANDING USE
OF THE CAR
If the vehicle is mainly used in one of
the following particularly harsh
conditions:
❒ trailer or caravan towing;
❒ dusty roads;
❒ short repeated distances (less than
7-8 km) and with external
temperatures below zero;
❒ engine often idling or driving long
distances at low speeds or long
periods of inactivity;
perform the following inspections more
frequently than shown on the
Scheduled Servicing Plan:
❒ check front disk brake pad
conditions and wear;
❒ Check cleanliness of bonnet and
luggage compartment locks,
cleanliness and lubrication of
linkage;❒ sight inspect the conditions of:
engine, gearbox, transmission,
pipes and hoses (exhaust -
fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.);
❒ check battery charge and battery
fluid level (electrolyte);
❒ visually check the various drive belt
conditions;
❒ check and, if necessary, change
engine oil and replace oil filter;
❒ check pollen filter and replace it, if
required;
❒ check air cleaner and replace it, if
required.

155
ENGINE
COMPARTMENT
39) 22) 4)
0.9 TWINAIR
60 HP*, 65 HP
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
* For versions/markets, where provided
0.9 TWINAIR
80 HP*, 85 HP - 105 HP
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
* For versions/markets, where provided
136DVDF0S074c
137DVDF0S075c

SERVICING AND CARE
156
1.2 8V 69 HP
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
1.4 16V 100 HP*
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
* For versions/markets, where provided
138DVDF0S076c
139DVDF0S077c

157
1.3 MULTIJET 95 HP
EURO 5
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
140DVDF0S079c
1.3 MULTIJET 78/95 HP
EURO 6
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
141DVDF0S462c

159
Proceed as follows: detach the
connector A fig. 142 (by pressing
button B) from sensor C for monitoring
the status of the battery installed on
the negative battery pole D. This
sensor should never be disconnected
from the battery pole except if the
battery is replaced.
IMPORTANT After turning the ignition
key to STOP and having closed the
driver’s side door, wait at least one
minute before disconnecting the
battery and then reconnecting the
electrical supply to the battery.
142DVDF0S0157c
BATTERY
39) 24) 3)
The car is fitted with a
low-maintenance battery: no
electrolyte top-ups with distilled water
are needed in standard conditions
of use.
INSPECTING THE
CHARGE AND THE
ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner Handbook
only by specialised personnel.
Topping must be carried out by
specialised personnel at a Fiat
Dealership.
REPLACING THE
BATTERY
If required, replace the battery with a
genuine spare part with the same
specifications.
If a battery with different specifications
is fitted, the service intervals given in
the “Scheduled Servicing Plan” will no
longer be valid.
Follow the battery manufacturer’s
instructions for maintenance.
CAR INACTIVITY
(CARS EQUIPPED WITH
START&STOP SYSTEM)
In the event of vehicle inactivity
(or if the battery is replaced), special
attention must be paid to the
disconnection of the battery power
supply.

191
21) VEHICLE REFUELLING
•Do not bring naked flames or lit cigarettes near to the fuel tank
opening: fire risk. Keep your face away from the fuel filler to
prevent breathing in harmful vapours.
•During normal service the catalyst reaches high temperatures;
therefore do not park the car over inflammable materials (grass,
dry leaves, pine needles, etc.): fire hazard.
•Do not use a mobile phone near the refuelling pump: risk of fire.
22) SEAT BELTS - PRETENSIONERS
•Do not press the seat belt release button while the vehicle is
moving.
•Remember that in the event of an accident, the rear seat
passengers not wearing seat belts are exposed to a very serious
risk and also represent a serious danger for the front seat
occupants.
•The pretensioner may be used only once. Contact a Fiat
Dealership to have it replaced after it has been deployed.
•For maximum safety, keep the backrest upright, lean back into
it and make sure the seat belt fits closely across your chest and
pelvis. Always fasten the seat belts on both the front and the rear
seats.
•Travelling without wearing seat belts will increase the risk of
serious injury and even death in the event of an accident.
•Removing or tampering with seat belt and pretensioner
components is strictly prohibited. Any intervention on these
components must be performed by qualified and authorised
technicians. Always go to a Fiat Dealership.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)
19) START&STOP SYSTEM
•When replacing the battery, always go to a Fiat Dealership.
Replace the battery with one of the same type (HEAVY DUTY)
and with the same specifications.
•Before opening the bonnet, make sure that the vehicle is
switched off and the key is in the STOP position.
Please follow the instructions on the decal near the front
crossmember. It is advisable to extract the key when there are
other people in the car.
The car should always be left after the key has been removed
or turned to the STOP position. When refuelling, make sure
that the car is switched off with the key in the STOP position.
•For cars with Dualogic gearbox, if the engine is
automatically stopped on a slope, the engine should be
restarted by moving the gear lever
to + or – without –releasing the brake pedal.
For vehicles with Dualogic transmission, where the Hill Holder
function is present, in case of stop downhill the motor does
not cut off automatically, so as to make the Hill Holder
function - which is active only when the engine is running -
available.
•If climate comfort is to be favoured, the Start&Stop system
can be disabled, for a continuous operation of the climate
control system.
20) ACCESSORIES PURCHASED BY THE OWNER
Take care when fitting additional spoilers, alloy wheels or non-
standard wheel hubs: they could reduce the ventilation of the
brakes and affect efficiency under sharp, repeated braking or
on long descents. Make sure that nothing obstructs the pedal
stroke (mats, etc.).

195
•Remember that the servo-brake and power steering are not
operational until the engine has been started, therefore much
effort than usual is required on the brake pedal and steering
wheel.
•For vehicles featuring a Dualogic gearbox, if the engine is not
started with a gear engaged, a warning is sounded to notify
the driver of the potential danger due to the gear being
automatically put into neutral.
•This starting procedure must be performed by expert
personnel because incorrect actions could cause electrical
discharge of considerable intensity. Furthermore, battery fluid
is poisonous and corrosive: avoid contact with skin and eyes.
Keep naked flames and lighted cigarettes away from the
battery and do not cause sparks.
•Remove any metal objects (e.g. rings, watches, bracelets),
that might cause an accidental electrical contact and cause
serious injury.
•Do not attempt to charge a frozen battery: it must be thawed
first, otherwise it may explode.
If freezing has occurred, the battery should be checked by
skilled personnel to make sure that the internal elements are
not damaged and that the body is not cracked, with the risk of
leaking poisonous and corrosive acid.
27) HANDBRAKE
• The car should be braked after a few clicks of the lever, if it is
not, contact a Fiat Dealership to have it adjusted.
• Never leave children in the unattended car. Always remove
the ignition key when leaving the car and take it out with you. • In the case of parking manoeuvres on roads on a gradient, the
front wheels must be steered towards the pavement
(when parking downhill), or in the opposite direction if the vehicle
is parked uphill. Block the wheels with a wedge or a stone if the
car is parked on a steep slope.
28) USING THE MANUAL GEARBOX
Press the clutch pedal fully to change gears correctly. It is
therefore essential that there is nothing under the pedals: make
sure the mats are lying flat and do not get in the way of the pedals.
29) TOWING TRAILERS
•The ABS with which the car is equipped will not control the
braking system of the trailer. Particular caution is required on
slippery roads.
•Do not, under any circumstances, modify the vehicle braking
system to control the trailer breaking system.
The towing braking system must be completely independent of the
vehicle’s hydraulic system.
30) SNOW TYRES
The maximum speed for snow tyres marked
“Q” is 160 km/h, while it is 190 km/h for “T” tyres and 210 km/h for
“H” tyres.
The highway code speed limits must however always be complied
with.
31) WARNING LIGHTS AND MESSAGES
•If the warning light
xturns on when travelling (on certain
versions together with the message on the display) stop the car
immediately and contact a Fiat Dealership.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)