2018 CHEVROLET LOW CAB FORWARD heater

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
268 Vehicle Care
No. Description Rating16 MIRROR HEATER 15A
17 IGNITION 2 10A
18 IGNITION 1 10A
19 – –
20 ECM 10A
21 METER 10A
22 ECU (BATT) 10A
23 MIRROR 10A
24 AUDIO, ACC 15A
25 HORN 15A
26 TURN, HAZARD 15A
27 TAIL LAMPS 10A
28 ILLUMI- NATIONS 10A
29 CORNERING LAMPS 10A
30 AIR CONDITIONER 10A
31 – –
32 – – No. Description Rating
33 – –
34 – –
D-1 CIGAR 20A
D-2 ACCESS- ORIES SOCKET 15A
D-3 POWER SOURCE 20A
D-4 – –

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
270 Vehicle Care
No. Description16 TAIL LAMP
17 CIGAR LIGHTER
18 CORNERING LAMP
19 POWER ACC
20 BLOWER MOTOR Fuse and Relay Location
–Cab Exterior
Fuse and Relay Location
Fuse locations (2): No. Description Rating
1 MARKER LIGHT 20A
2 TAIL MAIN 20A
3 FUEL HEATER 15A
4 SCR 20A
5 PM SENSOR 15A No. Description Rating
6 RR DOME LIGHT 15A
7 CONDENSER FAN 20A
8 A/C 10A

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Vehicle Care 271
Relay locations (1):No. Description
1 STARTER
2 PM SENSOR
3 NOX & DEF SENSOR
4 A/C COMPRESSOR
5 CONDENSER FAN
6 RR DOME LIGHT
7 SCR HEATER VALVE
8 MARKER LIGHT
9 –
10 –
11 FUEL HEATER When Slow-blow Fuses Blow Out
Slow-blow fuses protect the
electrical circuits, and they are
installed so that they can be quickly
replaced if there is a malfunction.
If an overload exists in the circuit
from the battery, the slow-blow fuse
will blow out before the wiring
harness is damaged to protect the
electrical circuitry. InspectionWhen the headlights and other
devices in the electrical system do
not work, but there is no problem
with the fuses, check the
slow-blow fuse.
The slow-blow fuse is blown if it
looks like the illustration.
Immediately contact the nearest
dealer.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Service and Maintenance 313
rocker shaft bracket nuts before
checking and adjusting valve
clearance.
Check and adjust valve clearance
every 80 000 km (50,000 miles) or
12 months whichever occurs first.
3. Engine Oil and Oil Filter :
Change at interval noted below
depending upon driving conditions.
•Normal Service —Change every
16 000 km (10,000 miles) or
12 months whichever occurs first.
• Severe Service —Change every
8 000 km (5,000 miles) or 3 months
if you often drive under one or more
of these conditions: (a) driving in
dusty areas, (b) frequent idling or
idling for long periods, (c) driving
6 km (4 miles) or less in freezing
weather, or other short trips in cold
weather, where the engine does not
thoroughly warm up.
Change oil and filter as soon as you
can after driving in a dust storm.
When recommended oil is used, it
conforms to this maintenance
schedule. (Recommended oil: CK-4
(API designations)) 4. Fuel Filter :
Replace the fuel
filter every 24 000 km (15,000 miles)
or more frequently if clogged or
replace when the fuel filter indicator
light comes on (if equipped).
5. Pre-Fuel Filter/Water
separator : Replace the fuel filter
every 24 000 km (15,000 miles) or
more frequently if clogged or
replace when the fuel filter indicator
light comes on (if equipped).
6. Air Cleaner Filter : The level of
dirt in the air cleaner element can
be checked against the indicator.
Replace the air cleaner filter when
the Driver Information Center (DIC)
shows "CHECK AIR FILTER".
7. Damage to Air Intake Ducts and
Hoses : Check for damage of air
intake ducts and hoses and that
those are correctly installed every
24 000 km (15,000 miles) or
12 months. Replace or adjust those
if necessary. 8. Drive Belts :
Check belt driving
the fan, alternator or A/C
compressor every 16 000 km
(10,000 miles). Look for cracks,
fraying, wear, and proper tension.
9. Engine Bolt Torques : Loosened
bolts result in lower engine output.
Check and adjust manifold
mounting, and injectors to correct
torque every 80 000 km
(50,000 miles).
10. Rotate Tires : To equalize wear,
rotate tires and adjust tire pressures
every 10 400 km (6,500 miles). See
Tire Rotation 0284.
11. Engine Cooling System : At
12 months or 16 000 km
(10,000 miles) intervals, wash
radiator cap and filler neck with
clean water, pressure test system
and radiator cap for proper pressure
holding capacity, tighten hose
clamps and inspect condition of all
cooling and heater hoses. Replace
hoses if cracked, swollen or
otherwise deteriorated. Have the
hoses replaced by your authorized
dealer.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Index 353
Diesel Exhaust Fluid (DEF)Warning Light . . . . . . . . . . . . . . . . . . 80
Diesel Particulate Filter . . . . . . . . . 161
Distracted Driving . . . . . . . . . . . . . . . 122
Dome Lamps . . . . . . . . . . . . . . . . . . . . 96
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Locks . . . . . . . . . . . . . . . . . . . . 33
Drive Belt Routing, Engine . . . . . . 341
Driver Behavior . . . . . . . . . . . . . . . . . 122
Driver Information Cen- ter (DIC) . . . . . . . . . . . . . . . . . . . . . . . 82
Driving Emergencies . . . . . . . . . . . . 137, 146
For Better Fuel Economy . . . . . . . 23
Hill and Mountain Roads . . . . . . 132
If the Vehicle is Stuck . . . . . . . . . 136
Wet Roads . . . . . . . . . . . . . . . . . . . 132
Winter . . . . . . . . . . . . . . . . . . . . . . . . 133
E
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 215
Electrical System Overload . . . . . . . . . . . . . . . . . . . . . 264
Emergencies . . . . . . . . . . . . . . 137, 146
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 231 Engine (cont'd)
Alarm and Automatic
Shutdown . . . . . . . . . . . . . . . . . . . 155
Check Light (Malfunction In-
dicator) . . . . . . . . . . . . . . . . . . . . . . . . 74
Checks Before Operating . . . . . 156
Compartment Overview . . . . . . . 222
Coolant . . . . . . . . . . . . . . . . . . . . . . . 231
Coolant Temperature Gauge . . . . 72
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 222
Drive Belt Routing . . . . . . . . . . . . 341
Exhaust . . . . . . . . . . . . . . . . . . . . . . 159
Heater . . . . . . . . . . . . . . . . . . . . . . . . 154
High Idle System . . . . . . . . . . . . . 155
Oil Pressure Light . . . . . . . . . . . . . . 79
Overheating . . . . . . . . . . . . . . . . . . 237
Reduced Power Light . . . . . . . . . . . 81
Running While Parked . . . . . . . . 160
Shutdown Warning Light . . . . . . . . 80
Engine Oil Level Indicator Light . . . . . . . . . . . . 80
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 206
Exhaust Brake . . . . . . . . . . . . . . . . . . 201
Exhaust Brake Light . . . . . . . . . . . . . 78
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 170
Extender, Seat Belt . . . . . . . . . . . . . . 49 Exterior Lamp Controls . . . . . . . . . . 92
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Filter, Engine Air Cleaner . . . . . . . . . . . 231
Fixed Mast Antenna . . . . . . . . . . . . 102
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . 93
Flashers, Hazard Warning . . . . . . . 94
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 287
Fluid Automatic Transmission . . . . . . 229
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 246
Diesel Exhaust . . . . . . . . . . . . . . . . . 24
Power Steering . . . . . . . . . . . . . . . 240
Washer . . . . . . . . . . . . . . . . . . . . . . . 241
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 348
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 38
Fuel Biodiesel . . . . . . . . . . . . . . . . . . . . . 207
Cold Weather Operation . . . . . . 209
Diesel Engines . . . . . . . . . . . . . . . 206
Economy Driving . . . . . . . . . . . . . . . 23
Filling the Tank . . . . . . . . . . . . . . . 213
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 72

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
354 Index
Fuel (cont'd)Running out of Fuel . . . . . . . . . . . 212
Water in Fuel . . . . . . . . . . . . . . . . . 209
Fuel for Diesel Engines . . . . . . . . . 206
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 73
Engine Coolant Temperature . . . 72
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Odometer . . . . . . . . . . . . . . . . . . . . . . . 71
Speedometer . . . . . . . . . . . . . . . . . . . 71
Tachometer . . . . . . . . . . . . . . . . . . . . . 72
Trip Odometer . . . . . . . . . . . . . . . . . . 71
Warning Lights and Indi-cators . . . . . . . . . . . . . . . . . . . . . . . . . 69
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 218
Getting In and Out of the Ve-
hicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 55
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 344
H
Hazard Warning Flashers . . . . . . . . 94
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 254
Bulb Replacement . . . . . . . 254, 257 Headlamps (cont'd)
Daytime Running Lamps
(DRL) Indicator Light . . . . . . . . . . 82
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On Light . . . . . . . . . . . . 81
High/Low Beam Changer . . . . . . . 93
Heated Mirrors . . . . . . . . . . . . . . . . . . . 34
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 154
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 115
High Idle System . . . . . . . . . . . . . . . 155
High-Beam On Light . . . . . . . . . . . . . 81
Hill and Mountain Roads . . . . . . . . 132
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 58
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 155
Idle Shutdown Light . . . . . . . . . . . . . 81
Ignition Positions . . . . . . . . . . . . . . . 148
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . . 51
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Cluster . . . . . . . . . . . . . . . 70
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 55 Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North
America . . . . . . . . . . . . . . . . . . . . . . . 287
K
Keyless EntryRemote (RKE) System . . . . . . . . . 26
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
L
Lamps Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Cornering . . . . . . . . . . . . . . . . . . . . . . . 95
Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Exterior Controls . . . . . . . . . . . . . . . . 92
Interior . . . . . . . . . . . . . . . . . . . . . . . . 264
License Plate . . . . . . . . . . . . . . . . . 263
Malfunction Indicator (Check
Engine) . . . . . . . . . . . . . . . . . . . . . . . 74
Roofmarker . . . . . . . . . . . . . . . . . . . 261
Sidemarker . . . . . . . . . . . . . . . . . . . 261
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 48
Lighter, Cigarette . . . . . . . . . . . . . . . . 67
Lighting Illumination Control . . . . . . . . . . . . . 95
Lights
Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . . . 77