2018 CHEVROLET CITY EXPRESS check engine

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Vehicle Care 199
Fuses and Circuit
Breakers
{Danger
Fuses and circuit breakers are
marked with their ampere rating.
Do not exceed the
specified amperage rating when
replacing fuses and circuit
breakers. Use of an oversized
fuse or circuit breaker can result
in a vehicle fire. You and others
could be seriously injured or
killed.
The wiring circuits in the vehicle are
protected from short circuits by a
combination of fuses and circuit
breakers. This greatly reduces the
chance of fires caused by electrical
problems.
Look at the silver-colored band
inside the fuse. If the band is broken
or melted, replace the fuse. Be sure
you replace a bad fuse with a new
one of the identical size and rating. Spare fuses are provided and can
be found in the passenger
compartment fuse box.
Engine Compartment
Fuse Block
The fuse block is in the engine
compartment of the vehicle.
Remove the cover by pushing the
tab and lifting the cover up.
Fusible Links
If the electrical equipment does not
operate and fuses are in good
condition, check the fusible links.
If any of these fusible links are
melted, replace with only Genuine
GM parts.
Caution
Spilling liquid on any electrical
component on the vehicle may
damage it. Always keep the
covers on any electrical
component.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Vehicle Care 229
Caution
If any accessories are left on or
plugged in during the jump
starting procedure, they could be
damaged. The repairs would not
be covered by the vehicle
warranty. Whenever possible, turn
off or unplug all accessories on
either vehicle when jump starting.
3. Turn off the ignition on both vehicles. Unplug unnecessary
accessories from the cigarette
lighter or the accessory power
outlet. Turn off the radio and all
lamps that are not needed.
This will avoid sparks and help
save both batteries. And it
could save the radio!
4. Open the hoods and locate the positive (+) and negative (−)
terminal locations of the other
vehicle.
{Warning
Using a match near a battery can
cause battery gas to explode.
People have been hurt doing this,
and some have been blinded.
Use a flashlight if you need more
light.
Battery fluid contains acid that
can burn you. Do not get it on
you. If you accidentally get it in
your eyes or on your skin, flush
the place with water and get
medical help immediately.
{Warning
Fans or other moving engine
parts can injure you badly. Keep
your hands away from moving
parts once the engine is running. 5. Check that the jumper cables
do not have loose or missing
insulation. If they do, you could
get a shock. The vehicles
could be damaged too.
Before you connect the cables,
here are some basic things you
should know. Positive (+) will
go to positive (+) or to a remote
positive (+) terminal if
equipped. Negative (−) will go
to an unpainted metal part or to
a remote negative (−) terminal
if equipped.
Do not connect positive (+) to
negative (−) or you will get a
short that would damage the
battery and possibly other parts
too. Do not connect the
negative (−) cable to the
negative (−) terminal on the
dead battery because this can
cause sparks.
6. Connect the red positive (+) cable to the positive (+)
terminal (1) of the dead battery.
Use a remote positive (+)
terminal if equipped. Do not let
the other end touch metal.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
242 Service and Maintenance
Service and
Maintenance
General Information
General Information . . . . . . . . . . 242
Maintenance Schedule
Maintenance Schedule . . . . . . . 246
Special Application Services
Special ApplicationServices . . . . . . . . . . . . . . . . . . . . 254
Additional Maintenance
and Care
Additional Maintenanceand Care . . . . . . . . . . . . . . . . . . . . 254
Recommended Fluids,
Lubricants, and Parts
Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 257
Maintenance Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . 258
Maintenance Records
Maintenance Records . . . . . . . . 259
General Information
Maintenance Requirements
Some regular maintenance is
essential to maintain the vehicle’s
mechanical condition, as well as its
emissions and engine performance.
It is the owner ’s responsibility to
make sure that the scheduled
maintenance, as well as general
maintenance, is performed.
As the vehicle owner, you are the
only one who can ensure that your
vehicle receives proper
maintenance. You are a vital link in
the maintenance chain.
General Maintenance
General maintenance includes
those items that should be checked
during normal day-to-day operation.
They are essential for proper
vehicle operation. It is your
responsibility to perform these
procedures regularly as prescribed. Performing general maintenance
checks requires minimal mechanical
skill and only a few general
automotive tools.
These checks or inspections can be
done by yourself, a qualified
technician, or, if you prefer, your
dealer.
Scheduled Maintenance
The maintenance items listed in this
section are required to be serviced
at regular intervals. However, under
severe driving conditions, additional
or more frequent maintenance will
be required.
Where to go for Service
If maintenance service is required or
your vehicle appears to malfunction,
have the systems checked and
serviced. It is recommended that
you visit your dealer for this service.
Chevrolet technicians are
well-trained specialists and are kept
up to date with the latest service
information through technical
bulletins, service tips, and training
programs.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 243
You can be confident that your
dealer’s service department can
perform the service needed to meet
the maintenance requirements on
your vehicle.
General Maintenance
During the normal day-to-day
operation of the vehicle, general
maintenance should be performed
regularly as prescribed in this
section. If you detect any unusual
sounds, vibrations, or smells, be
sure to check for the cause or have
your dealer do it promptly. In
addition, it is recommended that you
visit your dealer if you think that
repairs are required.
When performing any checks or
maintenance work, see Doing Your
Own Service Work 0178.
Explanation of General
Maintenance Items
Additional information on the
following items with * is found under
“Vehicle Checks” in the Vehicle
Care section of this manual. Outside the Vehicle
The maintenance items listed here
should be performed from time to
time, unless otherwise specified.
Doors and engine hood* :
Check
that the doors and engine hood
operate properly. Also ensure that
all latches lock securely. Lubricate
hinges, latches, latch pins, rollers,
and links if necessary.
Make sure that the secondary latch
keeps the hood from opening when
the primary latch is released.
When driving in areas using road
salt or other corrosive materials,
check lubrication frequently.
Lamps* : Clean the headllamps on
a regular basis. Make sure that the
headlamps, stoplamps, taillamps,
turn signal lamps, and other lights
are all operating properly and
installed securely. Also check
headlamp aim. Road wheel nuts (lug nuts) :
When checking the tires, make sure
no wheel nuts are missing, and
check for any loose wheel nuts.
Tighten if necessary.
Tire rotation* :
Tires should be
rotated every 8 000 km (5,000 mi).
Tires* : Check the pressure with a
gauge often and always prior to long
distance trips. If necessary, adjust
the pressure in all tires, including
the spare, to the pressure specified.
Check carefully for damage, cuts,
or excessive wear.
Tire Pressure Monitoring System
(TPMS) transmitter components :
Replace the TPMS transmitter
grommet seal, valve core, and cap
when the tires are replaced due to
wear or age.
Wheel alignment and balance : If
the vehicle pulls to either side while
driving on a straight and level road,
or if you detect uneven or abnormal
tire wear, there may be a need for
wheel alignment. If the steering

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 245
Windshield wiper and washer* :
Check that the wipers and washer
operate properly and that the wipers
do not streak.
Under the Hood and Vehicle
The maintenance items listed here
should be checked periodically (for
example, each time you check the
engine oil or refuel).
Battery* :Check the fluid level in
each cell. The fluid should be at the
bottom of the filler opening. Vehicles
operated in high temperatures or
under severe conditions require
frequent checks of the battery fluid
level.
Care should be taken to avoid
situations that can lead to potential
battery discharge and potential
no-start conditions such as:
. Installation or extended use of
electronic accessories that
consume battery power when
the engine is not running (phone
chargers, GPS, DVD
players, etc.). .
Vehicle is not driven regularly
and/or only driven short
distances.
In these cases, the battery may
need to be charged to maintain
battery health.
Brake fluid level* : Make sure that
the brake fluid level is between the
MAX and MIN lines on the reservoir.
Engine coolant level* : Check the
coolant level when the engine
is cold.
Engine drive belts : Make sure the
drive belts are not frayed, worn,
cracked, or oily.
Engine oil level* : Check the level
after parking the vehicle on a level
spot and turning off the engine. Wait
more than 15 minutes for the oil to
drain back into the oil pan.
Exhaust system : Make sure there
are no loose supports, cracks,
or holes. If the sound of the exhaust
seems unusual or there is a smell of
exhaust fumes, immediately have
the exhaust system inspected. It is
recommended that you see your dealer for this service. For additional
information, see
Engine Exhaust
0 149.
Fluid leaks : Check under the
vehicle for fuel, oil, water, or other
fluid leaks after the vehicle has
been parked for a while. Water
dripping from the air conditioner
after use is normal. If you notice any
leaks or if fuel fumes are evident,
check for the cause and have it
corrected immediately.
Radiator and hoses : Check the
front of the radiator and clean off
any dirt, insects, leaves, etc., that
may have accumulated. Make sure
the hoses have no cracks,
deformation, rot, or loose
connections.
Underbody : The underbody is
frequently exposed to corrosive
substances such as those used on
icy roads or to control dust. It is very
important to remove these
substances, otherwise rust may
form on the floor pan, frame, fuel
lines, and around the exhaust
system. At the end of winter, the
underbody should be thoroughly

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
246 Service and Maintenance
flushed with plain water, being
careful to clean those areas where
mud and dirt may accumulate. For
additional information,Exterior Care
0 233.
Windshield washer fluid* : Check
that there is adequate fluid in the
reservoir.Maintenance
Schedule
Explanation of Scheduled
Maintenance Items
The following descriptions are
provided to give you a better
understanding of the scheduled
maintenance items that should be
regularly checked or replaced. The
maintenance schedule indicates at
which mileage/time intervals each
item requires service.
In addition to scheduled
maintenance, your vehicle requires
that some items be checked during
normal day-to-day operation. For
additional information, refer to
“General Maintenance” in this
section.
Items marked with * are
recommended for reliable vehicle
operation. You are not required to
perform maintenance on these
items in order to maintain the
warranties that come with your
vehicle. Other maintenance items
and intervals are required. When applicable, additional
information can be found under
“Vehicle Checks”
in the Vehicle
Care section of this manual.
Chevrolet does not advocate the
use of non-OEM approved
aftermarket flushing systems and
strongly advises against performing
these services on a Chevrolet
product. Many of the aftermarket
flushing systems use non-OEM
approved chemicals or solvents, the
use of which has not been validated
by Chevrolet.
For recommended fuel, lubricants,
fluids, grease, and refrigerant, refer
to Recommended Fluids and
Lubricants 0257.
Emission Control System
Maintenance
Drive belts* : Check engine drive
belts for wear, fraying, or cracking
and for proper tension. Replace any
damaged drive belts.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 247
Engine air filter :Replace at
specified intervals. When driving for
prolonged periods in dusty
conditions, check/replace the filter
more frequently.
Engine coolant* : Replace coolant
at the specified interval. When
adding or replacing coolant, be sure
to use only prediluted ACDelco CE
Long Life Antifreeze Coolant (blue)
or equivalent. See Recommended
Fluids and Lubricants 0257.
Mixing any other type of coolant or
using non-distilled water may
reduce the recommended service
interval of the coolant.
Engine oil and oil filter : Replace
engine oil and oil filter at the
specified intervals. For
recommended oil grade and
viscosity, see Recommended Fluids
and Lubricants 0257.
Engine valve clearance* : Inspect
only if valve noise increases. Adjust
valve clearance if necessary. Evaporative emissions control
vapor lines :
Check vapor lines for
leaks or looseness. Tighten
connections or replace parts as
necessary.
Fuel lines* : Check the fuel hoses,
piping, and connections for leaks,
looseness, or deterioration. Tighten
connections or replace parts as
necessary.
Spark plugs : Replace at specified
intervals. Install new plugs of the
same type as originally equipped.
Chassis and Body Maintenance
Brake lines and cables : Visually
inspect for proper installation.
Check for chafing, cracks,
deterioration, and signs of leaking.
Replace any deteriorated or
damaged parts immediately.
Brake pads, rotors, drums, and
linings : Check for wear,
deterioration, and fluid leaks.
Replace any deteriorated or
damaged parts immediately. Exhaust system :
Visually inspect
the exhaust pipes, muffler, and
hangers for leaks, cracks,
deterioration, and damage. Tighten
connections or replace parts as
necessary.
Steering gear and linkage, axle
and suspension parts, drive shaft
boots : Check for damage,
looseness, and leakage of oil or
grease. Under severe driving
conditions, inspect more frequently.
Tire rotation : Tires should be
rotated every 8 000 km (5,000 mi).
When rotating tires, check for
damage and uneven wear. Replace
if necessary.
Transmission fluid/oil : Visually
inspect for signs of leakage at
specified intervals.
If towing a trailer, using a camper or
car-top carrier, or driving on rough
or muddy roads, replace the CVT
fluid every 96 000 km (60,000 mi) or
request the dealer to inspect the
fluid.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 255
Brakes
Brakes stop the vehicle and are
crucial to safe driving.
.Signs of brake wear may include
chirping, grinding, or squealing
noises, or difficulty stopping.
. Trained dealer technicians have
access to tools and equipment
to inspect the brakes and
recommend quality parts
engineered for the vehicle.
Fluids
Proper fluid levels and approved
fluids protect the vehicle’s systems
and components. See
Recommended Fluids and
Lubricants 0257 for GM approved
fluids.
. Engine oil and windshield
washer fluid levels should be
checked at every fuel fill.
. Instrument cluster lights may
come on to indicate that fluids
may be low and need to be
filled. Hoses
Hoses transport fluids and should
be regularly inspected to ensure
that there are no cracks or leaks.
With a multi-point inspection, your
dealer can inspect the hoses and
advise if replacement is needed.
Lamps
Properly working headlamps,
taillamps, and brake lamps are
important to see and be seen on
the road.
.
Signs that the headlamps need
attention include dimming, failure
to light, cracking, or damage.
The brake lamps need to be
checked periodically to ensure
that they light when braking.
. With a multi-point inspection,
your dealer can check the lamps
and note any concerns. Shocks and Struts
Shocks and struts help aid in control
for a smoother ride.
.
Signs of wear may include
steering wheel vibration, bounce/
sway while braking, longer
stopping distance, or uneven
tire wear.
. As part of the multi-point
inspection, trained dealer
technicians can visually inspect
the shocks and struts for signs
of leaking, blown seals,
or damage, and can advise
when service is needed.
Tires
Tires need to be properly inflated,
rotated, and balanced. Maintaining
the tires can save money and fuel,
and can reduce the risk of tire
failure.
. Signs that the tires need to be
replaced include three or more
visible treadwear indicators; cord
or fabric showing through the