2017 KIA OPTIMA PLUG-IN HYBRID Battery

(Continued)
If any electrolyte gets intoyour eyes, flush your eyeswith clean water for atleast 15 minutes and getimmediate medical atten‐tion.If electrolyte gets on yourskin, thoroughly wash thecontacted area. If you feelpain or burning sensation,get medical attention im‐mediately.
Wear eye protection whencharging or working near abattery. Always provideventilation when workingin an enclosed space.
An inappropriately dis‐posed battery can beharmful to the environ‐ment and human health.Dispose the battery ac‐cording to your local law(s)or regulation.
(Continued)
(Continued)
The battery contains lead.Do not dispose of it afteruse. We recommend thatyou contact an authorizedKia dealer.
•When lifting a plastic-cased bat‐tery, excessive pressure on thecase may cause battery acid toleak, resulting in personal injury.Lift with a battery carrier or withyour hands on opposite corners.
•Never attempt to recharge thebattery when the battery cablesare connected.
•The electrical ignition systemworks with high voltage. Nevertouch these components with theengine running or the ignitionswitched on.
Failure to follow the above warningscan result in serious bodily injury ordeath.
CAUTION
•When you don’t use the vehicle fora long time in the low temperaturearea, separate the battery andkeep it indoors.
•Always charge the battery fully toprevent battery case damage inlow temperature area.
•If you connect unauthorized elec‐tronic devices to the battery, thebattery may be discharged. Neveruse unauthorized devices.
Battery capacity label
&YBNQMF
06.-
Maintenance
9-40

❈The actual battery label in the vehi‐
cle may differ from the illustration.
1. AGM90L-DIN : The Kia model name
of battery
2. 90Ah(20HR) : The nominal capacity (in Ampere hours)
3. 170RC : The nominal reserve ca‐ pacity (in min.)
4. 12V : The nominal voltage
5. 850CCA (SAE) : The cold-test cur‐ rent in amperes by SAE
6. 680A : The cold-test current in am‐ peres by EN
Battery recharging
Your vehicle has a maintenance-free,
calcium-based battery. • If the battery becomes discharged in a short time (because, for example,the headlights or interior lights were
left on while the vehicle was not in
use), recharge it by slow charging
(trickle) for 10 hours.
• If the battery gradually discharges because of high electric load while
the vehicle is being used, recharge it
at 20-30A for two hours.
WARNING
nRecharging battery
When recharging the battery, ob‐serve the following precautions:•The battery must be removedfrom the vehicle and placed in anarea with good ventilation.
•Do not allow cigarettes, sparks, orflame near the battery.
•Watch the battery during charg‐ing, and stop or reduce the charg‐ing rate if the battery cells begingassing (boiling) violently or if thetemperature of the electrolyte ofany cell exceeds 49°C (120°F).
•Wear eye protection when check‐ing the battery during charging.
•Disconnect the battery charger inthe following order.1.Turn off the battery chargermain switch.
2.Unhook the negative clampfrom the negative battery ter‐minal.
3.Unhook the positive clamp fromthe positive battery terminal.
WARNING
•Before performing maintenance orrecharging the battery, turn off allaccessories and stop the engine.
•The negative battery cable mustbe removed first and installed lastwhen the battery is disconnected.
•Operation related to the battery isrecommended to an authorized Kiadealer.
CAUTION
•Keep the battery away from wa‐ter or any liquid.
•For your safety, we recommendthat you use parts for replace‐ment from an authorized Kia deal‐er.
Reset items
Items should be reset after the battery
has been discharged or the battery has been disconnected. • Auto up/down window (if equipped)
• Sunroof (if equipped)
• Trip computer

9-41
9
Maintenance

FUSES
#MBEF
UZQF
$BSUSJEHF
UZQF
.VMUJGVTF
#'5
0+'
❈Left side: Normal Right side: Blown
A vehicle’s electrical system is protec‐
ted from electrical overload damage by fuses.
This vehicle has 2 (or 3) fuse panels,
one located in the driver’s side panel
bolster, the others in the engine com‐ partment near the battery.
If any of your vehicle’s lights, accesso‐
ries, or controls do not work, check the
appropriate circuit fuse. If a fuse has blown, the element inside the fuse will
melt.
If the electrical system does not work,
first check the driver’s side fuse panel.
Before replacing a blown fuse, discon‐ nect the negative battery cable.
Always replace a blown fuse with one
of the same rating.
If the replacement fuse blows, this indi‐
cates an electrical problem. Avoid using the system involved and immediately
consult an authorized Kia dealer.
Three kinds of fuses are used: blade
type for lower amperage rating, car‐ tridge type, and multi fuse for higher
amperage ratings.
WARNING
nFuse replacement
•Never replace a fuse with anythingbut another fuse of the same rat‐ing.
•A higher capacity fuse could causedamage and possibly a fire.
•Never install a wire or aluminumfoil instead of the proper fuseeven as a temporary repair. It maycause extensive wiring damageand a possible fire.
•Do not arbitrarily modify or add-on electric wiring of the vehicle.
CAUTION
Do not use a screwdriver or any oth‐er metal object to remove fuses be‐cause it may cause a short circuitand damage the system.
Maintenance
9-52

4. Push in a new fuse of the samerating, and make sure it fits tightly
in the clips. If it fits loosely, we rec‐
ommend that you consult an au‐
thorized Kia dealer.
CAUTION
After checking the fuse panel in theengine compartment, securely installthe fuse panel. If not, cover throughthe audible clicking sound. Electricalfailures may occur from water con‐tact.
Multi fuse
If the multi fuse is blown, it must be re‐
moved as follows: 1. Disconnect the negative battery cable.
2. Remove the nuts shown in the pic‐ ture above.
3. Replace the fuse with a new one of the same rating.
4. Reinstall in the reverse order of re‐ moval.
NOTICE
If the multi fuse is blown, we recom‐
mend that you consult an author‐
ized Kia dealer.
Main fuse
If the main fuse is blown, it must be re‐
moved as follows: 1. Turn off the engine.
2. Disconnect the negative battery cable.
3. Remove the nuts shown in the pic‐ ture above.

9-55
9
Maintenance

4. Replace the fuse with a new one ofthe same rating.
5. Reinstall in the reverse order of re‐ moval.
NOTICE
The electronic system may not
function correctly even when the
engine room and internal fuse box's
individual fuses are not disconnec‐
ted. In such case the cause of the
problem may be disconnection of
the main fuse (BFT type), which is
located inside the positive battery
terminal (+) cap. Since the main fuse
is designed more intricately than
other parts, please visit the nearest
Kia dealer and service center.
CAUTION
Visually inspect the battery cap forsecure closing. If the battery cap isnot securely latched, the electricalsystem may be damaged to due in‐flux of moisture into the system.
Fuse/relay panel description
%SJWFSLÓT
TJEF
GVTF
QBOFM
0+'
&OHJOF
DPNQBSUNFOU
GVTF
QBOFM
#BUUFSZ
UFSNJOBM
DPWFS
Inside the fuse/relay panel covers, you
can find the fuse/relay label describing fuse/relay name and capacity.
NOTICE
Not all fuse panel descriptions in this
manual may be applicable to your
vehicle. It is accurate at the time of
printing. When you inspect the fuse
panel in your vehicle, refer to the
fuse panel label.
Maintenance
9-56

Fuse NameSymbolFuse rat‐ingCircuit Protected
IG1
25A PCB Block (Fuse - OPCU2/ELECTRICAL WATER PUMP/TCU2/ACTIVE HYDRAULIC
BOOTER 3/HEV ECU2/ECU3)
MODULE 9
10A Smart Key Control Module
WASHER
15A Multifunction Switch (Wiper Low & Washer Switch)
MODULE 8
10A Driver/Passenger Door Module
CLUSTER
10A Instrument Cluster
MULTI MEDIA
15A Audio, A/V & Navigation Head Unit, Keyboard
HTD STRG
15A BCM (Steering Wheel Heated)
MODULE 1
10A Console Switch, Active Air Flap Unit, Gateway, Driver/Passenger Door Module
DR LOCK
20A Door Lock Relay, Door Unlock Relay, ICM Relay Box (Dead Lock Relay)
MEMORY 2
10A Siren Control Module, Ultrasonic Intrusion Protection Sensor
SMART KEY
15A Smart Key Control Module
A/BAG IND
10A Instrument Cluster (Air Bag IND. Power)
TRUNK
10A Trunk Lid Relay, Fuel Filler & Trunk Open Switch, ICM Relay Box (Fuel Filler Open Relay)
SUNROOF 2
20A Sunroof Control Unit (Roller)
BATTERY MANAGE‐ MENT
BATTERY
MANAGEMENT20A BMS Control Module
MEMORY 1
10A Instrument Cluster, A/C Control Module, Data Link Connector, BCM, Wireless
Charger, Driver IMS Module, Rain Sensor, ICM Relay Box (Outside Mirror Fold‐
ing/Unfolding Mirror Relay), Security Indicator, Auto Light & Photo Sensor,
Driver/Passenger Door Module


9-59
9
Maintenance

Battery terminal cover

Maintenance
9-64

Engine room compartment fuse panel
Fuse NameSymbolFuse ratingCircuit Protected
MULTI FUSE MDPS 1
80A MDPS Unit (Column)
COOLING FAN
60A RLY. 2 (Cooling Fan Relay)
B+5
50A PCB Block (Engine Control Relay, Fuse -FUEL
PUMP/ECU2/TCU1/HORN/WIPER1/BATTERY C/FAN)
B+3
50A Smart Junction Block (IPS 2 (IPS 5), IPS 3 (IPS 6), IPS 7, IPS 8)
REAR HEATED
50A RLY. 11 (Rear Heated Relay)
ACTIVE HYDRAULIC BOOSTER 2
2ACTIVE
HYDRAULIC BOOSTER40A Integrated Brake Actuation Unit
BLOWER
40A RLY. 4 (Blower Relay)
POWER OUTLET1
40A RLY. 7 (Power Outlet Relay)
IG2
30A PCB Block (IG2 Relay)
B+1
60A Smart Junction Block (Fuse - TRUNK, SUNROOF2, S/HEATER
REAR, SUNROOF1, P/WDW RH, P/SEAT PASS, P/WDW LH, P/SEAT
DRV)
EEWP
EEWP60A Engine Electric Water Pump
B+2
60A Smart Junction Block (IPS 1, IPS 4, Fuse - FOG LAMP REAR, S/
HEATER FRONT, AMP)
ACTIVE HYDRAULIC BOOSTER 1
ACTIVE
HYDRAULIC
BOOSTER140A Integrated Brake Actuation Unit
IG1
40A PCB Block (IG1/ACC Relay)

9-65
9
Maintenance