2016 Peugeot 508 Hybrid air filter

12
508_en_Chap00c_eco-conduite_ed01-2016
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the
bottom of the boot, as close as possible to the rear seats.
Limit the loads carried in the vehicle and reduce wind resistance (roof
bars, roof rack, bicycle carrier, trailer...). u
s
e a roof box in preference.
Remove roof bars and roof racks after use.
At the end of winter, remove snow tyres and refit your summer tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in
the door aperture, driver's side.
Carry out this check in particular:
-

b
efore a long journey,
-

a
t each change of season,
-

a
fter a long period out of use.
Don't forget the spare wheel and the tyres on any trailer or caravan.
Have your vehicle serviced regularly (engine oil, oil filter, air filter,
passenger compartment filter...) and observe the schedule of
operations recommended in the manufacturer's service schedule.
With a BlueHDi Diesel engine, if the SCR system is faulty your vehicle
becomes polluting; go to a P
e

uge
Ot
dealer or a qualified workshop
without delay to have the emissions of nitrous oxides brought back to
the legal level.
When refuelling, do not continue after the third cut-off of the nozzle to
avoid any over flow.
At the wheel of your new vehicle, it is only after the first 1 800 miles
(3
000 kilometres) that you will see the fuel consumption settle down to
a consistent average.
eco-driving

83
508_en_Chap03_ergonomie-et-confort_ed01-2016
Heating and Ventilation
Air intake
the air circulating in the passenger compartment
is filtered and originates either from the outside via
the grille located at the base of the windscreen or
from the inside in air recirculation mode.
Controls
the incoming air follows various routes
depending on the controls selected by
the driver, the front passenger and rear
passengers, according to the level of
equipment.
th
e temperature control enables you to obtain
the level of comfort required by mixing the air of
the various circuits.
th

e air distribution control enables you to
select the air vents used in the passenger
compartment by the combined use of the
associated buttons.
th

e air flow control enables you to increase or
reduce the speed of the ventilation fan.
th

ese controls are grouped together on control
panel A on the centre console. 1.
W

indscreen demisting/defrosting vents.
2.
F

ront side window demisting/defrosting
vents.
3.
S

ide adjustable air vents.
4.
C

entral adjustable air vents.5.
A

ir outlets to the front footwells.
6.
A

djustable air vents for the rear
passengers.
7.
A

ir outlets to the rear footwells.
Air distribution
3
ease of use and comfort

85
508_en_Chap03_ergonomie-et-confort_ed01-2016
Recommendations for ventilation and air conditioning
the air conditioning system does not contain chlorine and does not present any danger to the ozone layer. In order for these systems to be fully effective, follow the operation and maintenance guidelines below:
F
I
f the interior temperature remains very high after the vehicle has been parked in the sun for a considerable time, first ventilate the
passenger compartment for a few minutes.
P
lace the air flow control at a sufficient level to provide an adequate renewal of air in the passenger compartment.
F t
o o
btain an even air distribution, take care not to obstruct the exterior air intake grilles located at the base of the windscreen, the nozzles,
the vents and the air outlets, as well as the air extractor located in the boot.
F
I
n normal conditions, use the intake of exterior air as prolonged use of the air recirculation may cause misting of the windows and side
windows.
F
D
o not cover the sunshine sensor, located on the dashboard; this is used for regulation of the automatic air conditioning system.
F
O
perate the air conditioning system for 5 to 10 minutes, once or twice a month to keep it in good working order.
F e
n
sure that the passenger compartment filter is in good condition and have the filter elements replaced regularly (refer to the "Checks"
section).
W
e recommend the use of a combined passenger compartment filter. t
h
anks to its second special active filter, it contributes to the
purification of the air breathed by the occupants and the cleanliness of the passenger compartment (reduction of allergic symptoms, bad
odours and greasy deposits).
F t
h
e air conditioning uses power from the engine while operating. t
h
is results in an increase in the vehicle's fuel consumption.
W

hen towing at or near maximum capacity or on steep slopes in high ambient temperatures, switching off the air conditioning saves engine
power and so improves towing capacity.
C
ondensation created by the air conditioning results in a discharge of water under the vehicle when stationary, which is per fectly normal.
F t
o e
nsure correct operation of the air conditioning system, you are also advised to have it checked regularly.
F
I
f the system does not produce cold air, do not use it and contact a P
e
uge
Ot
dealer or a qualified workshop.
3
ease of use and comfort

221
508_en_Chap07_info-pratiques_ed01-2016
Checks
12 V battery
the battery does not require any
maintenance.
However, check regularly that the
terminals are correctly tightened (versions
without quick release terminals) and that
the connections are clean.Refer to the manufacturer's
service schedule for details of the
replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the manufacturer's
service schedule for details of
the replacement interval for this
component.
Oil filter
Versions equipped with Stop & Start are
fitted with a 12 V lead-acid battery of specific
technology and specification.
Its replacement should be carried out only by a
P
e
uge
Ot
dealer or a qualified workshop.
Particle filter (Diesel)
the start of saturation of the particle
filter is indicated by the temporary
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed
of at least 40 mph (60 km/h) until the
warning lamp goes off.
If the warning lamp stays on, this
indicates a low additive level.
For more information on checking levels,
refer to the corresponding section.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.
un

less otherwise indicated, check these components in accordance with the manufacturer's service schedule and according to your engine.
Other wise, have them checked by a P
e

uge
Ot

dealer or a qualified workshop.
When carrying out any operation on the 12 V
battery, refer to the corresponding section for
details of the precautions to be taken before
starting work. Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g.

city driving), replace them twice as often
if necessary .
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours. illumination of this warning lamp accompanied
by a message in the multifunction screen.
7
Practical information

354
508_en_Chap11_index-alpha_ed01-2016
gauge, fuel.............................................. 13, 20 0ge
arbox,
automatic
........ 1

1, 16, 176, 180, 183, 222, 253
ge

arbox, manual

......11, 16, 174, 180, 183, 222
gea

r lever, automatic gearbox
..................... 17

6
ge

ar lever, manual gearbox

.........................174
ge

ar shift indicator

....................................... 175
gl

ove box ...................................................... 101
gr

ound clearance

......................................... 272
gu

ide-me-home

.................................... 121, 124Identification, vehicle
....................................
2
73
Immobiliser, electronic

................
52, 61, 69, 167
Indicator, coolant temperature
........................ 3
0
Indicator, engine oil level ................................
31
Indicator lamps ................................................
14
Indicators, direction ......................................120
Inflating tyres


..........................................11, 2 7 3
Inflating tyres and accessories (using the kit)
..............................

................234
Input, auxiliary
.............................. 1

08, 292, 346
Instrument panel
...............................

..............13
Instruments and controls

..................................7
I

ntelligent t
ra
ction Control
............................13

4
ISOFIX


...................................................152-15 6
Hazard warning lamps


..........................
132, 2 27
Headlamp adjustment

...................................
126
Headlamps, automatic illumination

......
118 , 12 1
Headlamps, dipped beam

.............
117, 242, 244
Headlamps, halogen

.............................
242, 244
Headlamps, main beam
................ 1
17, 242, 244
Headlamp wash

............................................
128
Head restraints, front ................................
75, 78
Head restraints, rear .....................................
109
Head-up display

............................
18 4, 188, 19 0
Heating

.........................................
83, 86, 88, 91
Heating, programmable (Webasto)
................ 97
H
ill start assist
...............................................
18
3
Horn ............................................................... 132
Filling the fuel tank

............................... 20

0, 202
Filter, air
...............

......................................... 221
Filter, oil


......................................................... 221
Filter, particle


........................................ 220, 221
G
I
E
H
F
Driving positions (storing) ...............................77
Dynamic stability control (DSC) ........ 1
8, 22, 133Filter, passenger compartment
.....................221
Fitting a wheel ............................... ................240
Fitting roof bars


.............................................212
Fittings, boot
......................................... 11

2 , 113
Fittings, front


...................................................99
Fittings, rear
...............................

...................111
Flap, fuel filler

...............................
.................200
Flashing indicators


................................120, 125
Foglamps, front


.............................119, 123, 242
Foglamps, rear


..............................119, 245, 246
Folding the rear seats


...................................109
Folding/unfolding the door mirrors


.................80
Frequency (radio)


..........................................288
Fuel ................................................................ 202
Fuel consumption
............................................ 11
F

usebox, dashboard

.....................................250
Fusebox, engine compartment


.....................252
Fuses


.............................................................249
e

BA

............................................................... 13 3
ec

o-driving (advice)

........................................ 11
el

ectronic brake force distribution
(
eB

FD)

........................................................ 13 3
em

ergency call
..................................... 1

3 2 , 2 74
em

ergency switching off
............................... 16

6
em

ergency warning lamps
................... 13

2, 2 27
em

issions control system, SCR .............25, 223
en

ergy economy mode

.................................261
en

gine compartment

.............................215 -217
en

gine,
Diesel


............16, 202, 216, 217, 228, 266, 268
en

gine, petrol

....................... 202, 215, 264, 265
en

vironment
......................... 1

1, 54, 63, 96, 179,
186, 220, 226, 253
Alphabetical index

356
508_en_Chap11_index-alpha_ed01-2016
Player, Apple® ......................................294, 345
Player, MP3 CD ............................ 292, 343, 344
Port,
u
S

B

..................................... 1

08, 292, 345
Pressures, tyres


............................................ 273
Pre-tensioning seat belts


.............................. 13 8
Priming the fuel system
................................ 228
Protecting children


................................ 13 8, 140, 143 -15 8
Puncture


........................................................ 229Reservoir, headlamp wash /
screenwash ................................................. 220
Resetting the service indicator


.......................34
Reversing camera


.........................................19 9
Reversing lamp
..................................... 24

5, 246
Risk areas (update)
.......................................307
Roof bars
....................................................... 2

12
Roof, opening


........................................104, 10 6
Running out of fuel (Diesel)

..........................2

28
Safety, children


................................13 8, 140, 143 -15 8
Saturation of the particle filter (Diesel)

.........2

21
Screen, cold climate
.....................................204
Screen, touch
...............................

.................271
Screen, instrument panel


..........................28, 39
Screen menu map


...............282, 284, 286, 296,
298, 302, 310, 320, 322
Screen, multifunction (with audio system)
............................340, 348
Screenwash, front/rear


.................................128
SCR (Selective Catalytic Reduction)


............223
Seat belts
............................................... 13

6 -13 8
Seats, front
...............................

.................75 -77
Seats, heated


..................................................78
Seats, rear


.....................................................109
Serial number, vehicle
.................................. 2

73
Service indicator


.............................................33
Service warning lamp


.....................................20
Servicing
...............................

..........................11
Settings, system


......................................28, 310
Sidelamps


.....................117, 125, 242, 245, 246
ta

ble of weights
...................................26

5, 268
tab

les of engines

..................................264, 267
ta

bles of fuses ..............................................249
ta

nk, AdBlue
® additive .................................2 23t
a n k , f u e l
....................................................... 200
te

chnical data

............................................... 264
te

lephone


..................................................... 320
te

mperature, coolant

...................................... 30
th

ird brake lamp

........................................... 248
S
T
Side repeater .............................. ..................244
Ski flap .............................. ............................111
Snow chains
.................................................. 20

3
Socket, 12 V accessory

................1

0 1, 1 0 8 , 111
Sockets, audio


.....................108, 292, 345, 346
Speed limiter


......................................... 188, 192
Spotlamps, side


.................................... 125, 24 4
Stability control (DSC)


............................18, 13 3
Starting the engine


...............................161, 165
Starting using another battery
...................... 25

4
Station, radio
........................................ 2

88, 340
Steering mounted controls, audio


.......280, 339
Steering wheel, adjustment


............................79
Stop & Start


.................... 17, 42, 89, 92, 96, 180,
200, 214, 221, 253, 256
Storage


.............................. 9 9 , 1 0 1, 1 0 7, 111 -113
Storage wells


................................................ 113
Storing driving positions


.................................77
Stowing rings


........................................ 112 , 113
Sun visor


....................................................... 101
Switching off the engine
....................... 16

1, 165
Synchronising the remote control


.............54, 63
Radio


.................................................... 288, 340
Radio, digital (Digital Audio Broadcasting - DAB)


................................... 290
Range, AdBlue


.......................................... 35, 36
RDS


....................................................... 2 8 9 , 3 41
Rear screen, demisting


................................... 96
Recharging the battery
................................. 25

5
Reduction of electrical load


.......................... 261
Regeneration of the particle filter

.......................................... 221
Reinitialising the remote control
............... 5

4, 63
Reminder, lighting on


.................................... 11 9
Remote control
.................................... 4

9, 55, 69
Removing a wheel

........................................ 238
Removing the battery .................................... 257
Removing the mat


......................................... 10 0
Replacing bulbs


............................................ 242
Replacing fuses
..............................

.............. 249
Replacing the air filter


................................... 221
Replacing the oil filter
................................... 2

21
Replacing the passenger compartment filter


...................................... 221
R
Alphabetical index

40
In the event of a breakdown
508HY-comp _en_Chap08_en-cas-de-pannes_ed01-2016
 Remove the deflector 1 .  Uncouple the hose 2 .  Remove the assembly of air flow meter and air filter 3 .  If present, move aside the coolant hose 4 .  Remove the battery cover 5 .
 Slacken 6 then disconnect the negative ( - ) - ) -terminal of the battery.  Unclip the wiring harnesses 7 . 7 . 7 Unclip and move aside the wiring harness 8 .  Remove the bolt from the maxi-fuse box 9 .  Remove the nut 10 from the positive ( + ) + ) +cable.  Move aside the wiring harness 11 .

48
Frequently asked questions
508HY-comp_en_Chap13_questions_ed01-2016
Frequently asked questions
100% electric mode (zero emissions)
QuestionAnswer
Why is it not always possible for me to select ZEV (Zero Emissions Vehicle) mode even though the battery seems well charged?
This situation is temporary. Certain conditions will occasionally prevent the change to ZEV mode, even if the battery has sufficient charge, such as, for example, very cold conditions, altitude, demisting, high demand for
heating or air conditioning, regeneration of the particle filter (FAP).
Why do I sometimes see an alert message " Electric mode not available: FAP regeneration in progress" ?
This is a message which indicates that regeneration of the particle filter (FAP) is in progress. This is a completely normal process that takes place every 240 or 300 miles (400 or 500 km) (or more frequently in prolonged urban use), as on a conventional HDi Diesel vehicle. In the case of a conventional HDi Diesel vehicle, this process is not generally noticed by the driver. On the other hand, in the case of HYbrid4 this phenomenon may be noticeable (in urban use) as temporarily the HDi engine will not stop and this message will be displayed at intervals while regeneration is in progress.
Why is it not possible for me to put the vehicle into ZEV mode, even though I had just been running electrically in AUTO mo de?
The management of ZEV is different from AUTO mode. Changing to ZEV mode is only possible with a battery charge of at least 4 bars, in order to assure sufficient range. In AUTO mode, the system alone manages the conditions for changing temporarily to electric mode, for shorter periods and with a lower state of charge of the battery.
Why is the range in ZEV mode lower when going uphill? The vehicle needs more energy when going uphill than when running on the level. So it is better to stay in AUTO mode, which will favour operation of the HDi Diesel engine.
Why is it that the system makes me come out of ZEV mode; it does not return to ZEV mode automatically when the conditions allow?
It is not intended to give preference to ZEV running at any cost, as it is not always the most economical mode. So the system returns automatically to AUTO mode.