2016 Citroen C4 oil filter

9
C4-2_en_Chap00b_vue-ensemble_ed02-2015
Technical data - Maintenance
Running out of Diesel fuel 238
Checking   levels  
2
26 -229
-
oil
-
 
b
rake   fluid
-


coolant
-
 
p
ower   steering   fluid
-
 
s
creenwash   /   headlamp   wash   fluid
-
 
a
dditive   (Diesel   with   particle   filter)
AdBlue
  additive  
2
32-235
Changing
 bu

lbs
 2
51-259
-
front
-
rear Petrol
  engines  
2
71-272
Diesel   engines  
2
73 -277
Dimensions
 2
78
Identification
 ma
rkings
 2
79
Bonnet
 2
23
Petrol underbonnet

2
24
Diesel underbonnet
2

25Checking
 c

omponents
 23
0-231
-


battery
-
 
a
ir   filter   /   passenger  
c

ompartment   filter
-

o
il filter
-
 
p
article   filter   (Diesel)
-
 
b
rake   pads   /   discs
Battery 2
65 -268
Energy   economy   mode  2 19
Changing
 / 
R

eplacing   a   fuse  
2
60 -261
Engine
  compartment   fuses  
2
64
.
Over view

11
C4-2_en_Chap00c_eco-conduite_ed02-2015
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   recommended   in   the   manufacturer's   service   schedule.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   is   faulty   your   vehicle  
b

ecomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified   workshop  
w

ithout   delay   to   have   the   emissions   of   nitrous   oxides   brought   back   to  
t

he   legal   level.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(

3 000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
.
Eco-driving

224
C4-2_en_Chap07_infos-pratiques_ed02-2015
Petrol engines
1. Power steering r eservoir.
2. S creenwash   and   headlamp   wash   reservoir.
3.
 C

oolant   header   tank.
4.
 B

rake   fluid   reservoir.
5.
 B

attery   /   Fuses.
6.
 F

usebox.
7.
 A

ir   filter.
8.
 E

ngine   oil   dipstick.
9.
 E

ngine   oil   filler   cap.
Practical information

225
C4-2_en_Chap07_infos-pratiques_ed02-2015
* According to engine.
Diesel engines
1. Power steering r eservoir.
2. S creenwash   and   headlamp   wash  
reservoir.
3.
 C

oolant   header   tank.
4.
 B

rake   fluid   reservoir.
5.
 B

attery   /   Fuses.
6.
 F

usebox.
7.
 A

ir   filter.
8.
 E

ngine   oil   dipstick.
9.
 E

ngine   oil   filler   cap.
10.
 P

riming
 pu
mp*.
The Diesel fuel system operates under high pressure:
- Never   carry   out   any   work   on   this   system y
ourself.
- HDi   engines   make   use   of   advanced t
echnology.
All
  maintenance   and   repairs   require   specially   trained
 s

taff,   which   only   a   CITROËN   dealer   can   provide.
7
Practical information

229
C4-2_en_Chap07_infos-pratiques_ed02-2015
Used products
The additive reservoir low level is indicated by:
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
-
 
f
ixed   illumination   of   the   particle  
f

ilter   warning   lamp,   accompanied  
b

y   an   audible   signal   and   a  
m

essage   that   the   particle   filter  
a

dditive   level   is   too   low.
Additive level (Diesel with
particle filter)
Avoid prolonged contact of used oil or f
luids   with   the   skin.
Most
  of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do not discard used oil or fluids into
sewers
  or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
7
Practical information

230
C4-2_en_Chap07_infos-pratiques_ed02-2015
Checks
Particle filter (Diesel)
- fixed  illumination   of   the   particle  f
ilter   warning   lamp,   accompanied  
b

y   an   audible   signal   and   a  
m

essage   that   there   is   a   risk   of  
b

lockage   of   the   particle   filter.
The presence of this label, in particular with
the
 
Stop
 
&
 
Start
 
system,
 
indicates
 
the
 
use
 
of
 
a s

pecific 12 V lead-acid battery with special
technology
 
and
 
specification.
 
The
 
involvement
 
o

f
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop
 
i

s
 
essential
 
when
 
replacing
 
or
 
disconnecting
 
t

he
 
battery. As
 
soon
 
as   the   traffic   conditions   permit,  
r

egenerate   the   filter   by   driving   at   a   speed   of   at  
l

east
 
40
 
mph   (60   km/h)   until   the   warning   lamp  
g

oes
 
off.
If
 
the
 
warning   lamp   stays   on,   refer   to   the  
"

Additive
 
level"   section.
Unless
 
other wise
 
indicated,
 
check
 
these
 
components
 
in
 
accordance
 
with
 
the
 
manufacturer's
 
service
 
schedule
 
and   according   to   your   engine.
Other wise,
 
have
 
them
 
checked
 
by
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop.
Air filter and passenger compartment filter
Refer to the manufacturer's s
ervice schedule for details of the
replacement
  intervals   for   these  
c

omponents.
Oil filter
Replace the oil filter each time the e ngine   oil   is   changed.
Refer
  to   the   manufacturer's  
s

ervice schedule for details of
the
  replacement   interval   for   this  
c

omponent.
12 V battery
The battery does not require any maintenance.
H owever,   check   that   the   terminals   are   clean a

nd   correctly   tightened,   particularly   in   summer
 a

nd   winter.
When carrying out work on the battery, refer to the "12 V battery" section for details of the
precautions
  to   be   taken   before   disconnecting  
t

he   battery   and   following   its   reconnection.Depending
  on   the   environment   (e.g.   dusty  a
tmosphere)   and   the   use   of   the   vehicle  
(e.g.
  city   driving),   replace them twice as often
if necessary .
A
  clogged   passenger   compartment   filter   may  
h

ave   an   adverse   effect   on   the   per formance  
o

f   the   air   conditioning   system   and   generate  
u

ndesirable
 o
dours.The start of saturation of the particle filter is
indicated
  by:
On a new vehicle, the first operations of
regeneration   of   the   particle   filter   may   be  
a

ccompanied   by   the   smell   of   "burning",  
w

hich   is   per fectly   normal.
Following
  prolonged   operation   of   the  
v

ehicle at very low speed or at idle,
you
  may,   in   exceptional   circumstances,  
n

otice   the   emission   of   water   vapour   at  
t

he   exhaust   on   acceleration.   This   does  
n

ot affect the behaviour of the vehicle
or
  the   environment.
Practical information

271
C4-2_en_Chap09_caracteristiques_ed02-2015
Petrol engines and gearboxes
Petrol enginePureTech 110 V Ti 120 PureTech 130 S&S
Gearbox Manual
(5 - speed) Manual

(5 - speed) Manual
(6- speed) E AT 6
automatic (6- speed)
Model c ode:
NC... HNZ6
HNZ6/1
HNZ6/2 5FS0
HNYM/S
HNYM/1S HNY T/S
HNY T/1S
HNY T/2S
Cubic
  capacity   (cc) 1 19 91
  5981 19 9
Bore
  x   stroke   (mm) 75
  x   90.577
  x   85.875
  x   90.5
Max
  power*:   EU   standard   (kW) 8188 96
Max
  power   engine   speed   (rpm) 5 5006
  0005 500
Max
  torque:   EU   standard   (Nm) 205160 230
Max
  torque   engine   speed   (rpm) 1 5004 250 1
  750
Fuel UnleadedUnleaded Unleaded
Catalytic converter Ye sYe s Ye s
Oil capacity in litres
(with filter replacement) 3.5
4.25 3.5
.../S:
 

model   fitted   with   Stop   &   Start.
.../1:  model
  fitted   with   low   rolling   resistance   tyres.
.../2:  model
  fitted   with   very   low   rolling   resistance   tyres.
*
  The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
9
Technical data

273
C4-2_en_Chap09_caracteristiques_ed02-2015
Diesel engines and gearboxes
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
D iesel engine
HDi 90HDi 90 FAP BlueHDi 100 e-HDi 115
Gearbox Manual
(5 - speed) Manual
(5 - speed) Manual
(5 - speed) Manual
(6- speed)
Model code:
NC... 9HJC

9HJC/1 9HP0BHY6
BHY6/1
BHY6/2S 9HD8/S

9HD8/1S
9HD8/2S
Cubic   capacity   (cc)
1   560
1   560
1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
6868 7384
Max   power   engine   speed   (rpm)
4 0004 000 3   750
3   600
Max   torque:   EU   standard   (Nm)
230230254 270
Max   torque   engine   speed   (rpm)
1   750
1   750
1   750
1   750
Fuel DieselDieselDieselDiesel
Catalytic converter Ye sYe sYe sYe s
Particle   filter   (FAP)
NoYe s Ye sYe s
Oil capacity in litres
(with filter replacement) 3.75
3.753.753.75
.../S:
 
model   fitted   with   Stop   &   Start.
.../1:
 

model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
 

model   fitted   with   very   low   rolling   resistance   tyres.
9
Technical data