158
Berlingo-2-VP_en_Chap07_Verification_ed01-2016
Levels
Cooling system
Only use the fluid recommended by the manufacturer.
Otherwise,
you risk seriously damaging
your
engine.
When
the engine is warm, the
temperature
of the coolant is controlled
by
the engine fan.
As
this fan can
operate
with the ignition key removed
and
because the cooling system is
pressurised, wait for at least one hour
after the engine has stopped before
carrying
out any work.
Slacken
the cap by 1/4 of a turn to
release the pressure to prevent any
risk
of scalding. When the pressure
has
dropped, remove the cap and top
up
the level with coolant.
If
fluid has to be added frequently,
this
indicates a fault which must be
checked
by a CITROËN dealer as
soon
as possible.
Power steering fluid level
The vehicle must be parked on level ground with the engine cold. Unscrew
the cap integrated with the gauge and
check
the level which must be between
the
MIN and MAX marks. In
order to regenerate the filter, you are advised to drive at a speed higher
than
40 mph (60 km/h) for at least five minutes
as soon as possible, when
traffic
conditions permit (until the
message
disappears and the service
warning
lamp goes off).
d
uring regeneration of the particle
emission
filter, the noise of a relay
operating
may be heard under the
dashboard.
If
the message is still displayed and
if
the service warning lamp remains
on, contact a CITR
o Ë n dealer or a
qualified
workshop.
Topping up
The
level
must
be
between
the
MIN
and
MAX
marks
on
the
expansion
bottle.
If
more
than
1
litre
of
fluid
is
required to top up the level, have the
system
checked
by
a
CITROËN
dealer
or
a
qualified
workshop.
Screenwash and headlamp
wash level
For best quality cleaning and for your
safety, we would advise that you use
products of the CITROËN range.
For
optimum cleaning and to avoid
freezing,
this fluid must not be topped
up
or replaced with plain water.
Capacity
of the screenwash reservoir:
approximately
3 litres.
If
your vehicle is fitted with headlamp
washers, the capacity of the reservoir
is
6 litres.
Diesel additive level
(Diesel with particle
filter)
Topping up
This additive must be topped up by
a
CITROËN dealer or a qualified
workshop
without delay.
Waste products
avoid prolonged contact of used oil
with the skin.
Brake
fluid is harmful to health and
very
corrosive.
Do
not dispose of used oil, brake fluid
or coolant into drains or into the ground
but into the containers dedicated to this
use at a CITR
o Ë n dealer (France) or
an
authorised waste disposal site.
The
minimum
level
of
this
additive
is indicated by lighting of the service
warning
lamp,
accompanied
by
an
audible
signal
and
a
message
in
the
screen.
When this occurs with the engine
running it is due to the start of
saturation
of
the
particle
filter
(exceptionally prolonged urban type
driving
conditions:
low
speed,
long
traffic
jams,
...).
197
Berlingo-2-VP_en_Chap09_Caract-technique_ed01-2016
Petrol Engines / Weights
5-seatEngine Gearbox Engine oil
capacity with filter
replacement (litres) Unbraked trailer (kg)
Recommended nose
weight (kg)
1.6 110 hp 5-speed
manual3.25 750 55
1.6 VTi 100 hp 5-speed
manual4.25 600 70
1.6 VTi 120 hp 5-speed
manual4.25 690 70
1.6 VTi 120 hp Euro 6 5-speed
manual4.25 600 70
1.2 PureTech S&S 110 hp Euro 6 5-speed
manual3.45 600 70
7-seat Engine Gearbox Engine oil
capacity with filter
replacement (litres) Unbraked trailer (kg)
Recommended nose
weight (kg)
1.6 110 hp 5-speed
manual3.25 750 70
TECHNICAL DATA
9
Weights
198
Berlingo-2-VP_en_Chap09_Caract-technique_ed01-2016
Diesel Engines / Weights
5-seatEngine Gearbox Engine oil
capacity with filter
replacement (litres) Unbraked
trailer (kg) Recommended nose
weight (kg)
1.6 HDi 75 hp 5-speed
manual-600 70
1.6 HDi 75 hp FAP 5-speed
manual-715 70
1.6 BlueHDi 75 hp Euro
65-speed
manual-720 70
1.6 HDi 90 hp 5-speed
manual3.75 735 70
1.6 HDi 92 hp FAP 5-speed
manual3.75 715 70
1.6 e-HDi 92 hp FAP 5-speed
manual3.75 690
70
6-speed electronic 75070
1.6 BlueHDi 100 hp Euro 6 5-speed
manual3.75 600 70
1.6 BlueHDi 100 hp S&S 5-speed
manual3.75 600
70
6-speed electronic 60070
1.6 HDi 115 hp FAP 5-speed
manual3.75 735 70
1.6 BlueHDi 120 hp Euro 6 6-speed
manual3.75 600 70
FAP:
particle filter.
e-HDi:
model equipped with Stop & Start.
Weights
199
Berlingo-2-VP_en_Chap09_Caract-technique_ed01-2016
7-seatEngine Gearbox Engine oil
capacity with filter
replacement (litres) Unbraked
trailer (kg) Recommended nose
weight (kg)
1.6 HDi 92 hp FAP 5-speed
manual3.75 750 70
1.6 BlueHDi 100 hp Euro 6 5-speed
manual3.75 600 70
1.6 BlueHDi 100 hp Euro 6 S&S 5-speed
manual3.75 600 70
1.6 HDi 115 hp FAP 5-speed
manual3.75 750 70
1.6 BlueHDi 120 hp Euro 6 6-speed
manual3.75 600 70
FAP:
particle filter.
e-HDi:
model equipped with Stop & Start.
TECHNICAL DATA
9
Weights
