2016 Abarth 500 warning lights

NUMBER PLATE LIGHTS
To replace the bulbs proceed as
follows:
❒apply pressure to the point shown by
the arrow fig. 115 and remove the
lens;
❒change the bulb, releasing it from the
side contacts;
❒fit the new bulb and make sure that it
is correctly clamped between the
contacts;
❒then refit the lens.
WARNING
116) Due to the high power supply
voltage, gas discharge bulbs
(Xenon) should only be replaced
by specialised personnel: danger
of death! Contact an Abarth
Dealership.
REPLACING AN
INTERIOR BULB
For the type of bulb and power rating,
see paragraph "Replacing a bulb".
INTERIOR ROOF LIGHT
To replace the bulb, proceed as follows:
❒using the screwdriver provided,
extract the roof light A fig. 116
working in the point shown by the
arrow;
115AB0A0099
116AB0A0100
142
IN AN EMERGENCY

ENGINE COMPARTMENT FUSE BOX
DEVICE PROTECTED FUSE AMPERE
Climate control fan F08 30
AvailableF09 15
Acoustic warnings F10 15
Engine management system (secondary loads) F11 10
Main beam headlights F14 15
Electric roof motor F15 20
Powertrain Control Module F17 10
AvailableF18 7,5
Air conditioning compressor F19 7,5
Heated rear window, mirror defrosters F20 30
Fuel pumpF21 15
Ignition coilF22 15
Powertrain Control Module F22 20
Braking system (control unit, valves) F23 20
+15 Braking system, electrical steering, yaw sensor F24 7,5
Fog lightsF30 15
AvailableF84 10
Front power socket (with or without cigar lighter) F85 15
147

SCHEDULED SERVICING PLAN
The checks listed in the Scheduled Servicing Plan, after reaching 120,000 km/8 years, must be cyclically repeated starting from
the first interval, thus following the same intervals as before.
Thousands of miles 9 18 27 36 45 54 63 72 81 90
Thousands of kilometres 15 30 45 60 75 90 105 120 135 150
Years12345678910
Check tyre condition/wear and adjust pressure, if
necessary; check “Fix&Go Automatic” kit recharge expiry
date (for versions/markets, where provided)●●●●●●●●●●
Check operation of lighting system (headlights, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.)●●●●●●●●●●
Check and, if necessary, top up fluid levels (engine
coolant, hydraulic clutch/brakes, screen washer, battery,
etc.)●●●●●●●●●●
Check exhaust emissions/smokiness●●●●●●●●●●
Use the diagnosis socket to check supply/engine
management systems operation, emissions and, for
versions/markets, where provided, engine oil degradation●●●●●●●●●●
Visually inspect condition of: exterior bodywork,
underbody protection, pipes and hoses (exhaust, fuel
system, brakes), rubber elements (gaiters, sleeves,
bushes, etc.)●●●●●
Check windscreen/rear window wiper blade position/wear●●●●●
155

PERIODIC CHECKS
Every 1,000 km or before long
journeys, check and, if necessary, top
up the following:
❒engine coolant level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre inflation pressure and condition;
❒operation of lighting system
(headlights, direction indicators,
hazard warning lights, etc.);
❒operation of screen washer/wiper
system and positioning/wear of
windscreen/rear window wiper
blades.
Every 3,000 km check and, if
necessary, top up: engine oil level.
You are advised to use PETRONAS
LUBRICANTS products, which have
been designed and produced
specifically for Abarth cars (see table
"Capacities" in the "Technical
specifications" chapter).
HEAVY-DUTY USE OF
THE CAR
If the car is used mainly under one of
the following conditions:
❒towing a trailer or caravan;
❒dusty roads;
❒short, repeated journeys (less than
7-8 km) at sub-zero outside
temperatures;
❒engine often idling or driving long
distances at low speeds or long
periods of inactivity;
the following checks must be carried
out more often than indicated in the
Scheduled Servicing Plan:
❒check front disc brake pad condition
and wear;
❒check cleanliness of bonnet and
luggage compartment locks,
cleanliness and lubrication of linkage;
❒visually inspect condition of: engine,
gearbox, transmission, pipes and
hoses (exhaust - fuel system -
brakes) and rubber elements (boots -
sleeves - bushes - etc.);
❒check battery charge and battery
fluid level (electrolyte);
❒visually inspect condition of the
accessory drive belts;❒check and, if necessary, change
engine oil and replace oil filter;
❒check and, if necessary, replace
pollen filter;
❒check and, if necessary, replace air
cleaner.
158
SERVICING AND MAINTENANCE

AIR CLEANER/
POLLEN FILTER
For filter replacement, contact an
Abarth Dealership.
BATTERY
The car is fitted with a low-maintenance
battery: no electrolyte top-ups with
distilled water are needed in standard
conditions of use.
INSPECTING THE
CHARGE AND THE
ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner Handbook only
by specialised personnel. Any top-up
operations must be carried out by
skilled personnel and by an Abarth
Dealership.
REPLACING THE
BATTERY
136) 137) 138) 139)
33)
4)
If required, replace the battery with an
original spare part with the same
specifications.
If a battery with different specifications
is fitted, the service intervals given in
the "Scheduled Servicing Plan" will no
longer be valid.
Follow the battery manufacturer's
instructions for maintenance.USEFUL ADVICE FOR
EXTENDING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and
make it last longer, observe the
following instructions:
❒when you park the car, ensure that
the doors, tailgate and bonnet are
closed properly, to prevent any lights
from remaining on inside the
passenger compartment;
❒switch off all roof lights inside the car:
the car is however equipped with a
system which switches all interior
lights off automatically;
❒do not keep accessories (e.g. radio,
hazard warning lights, etc.) switched
on for a long time when the engine
is not running;
❒before performing any operation on
the electrical system, disconnect
the negative battery pole;
❒completely tighten the battery
terminals.
IMPORTANT If the charge level remains
under 50% for a long time, the battery
is damaged by sulphation, reducing
its capacity and efficiency at start-up.
162
SERVICING AND MAINTENANCE

WHATTODOIF
Fault Possible solution
... A TYRE IS PUNCTURED. Use the Fix&Go tyre repair kit. See page 131
... A TYRE DEFLATES. Restore the correct pressure. See page 183
... THE BATTERY IS FLAT. -See page 149 or contact an
Abarth Dealership.
... THE INTERNAL ROOF LIGHT DOES NOT
SWITCH ON.Replace the bulb.See page 142 or contact an
Abarth Dealership.
... THE LUGGAGE COMPARTMENT ROOF
LIGHT DOES NOT SWITCH ON.Replace the bulb.See page 143 or contact an
Abarth Dealership.
... AN EXTERNAL BULB (main beam, dipped
beam headlights...) DOES NOT COME ON.-Contact an Abarth
Dealership.
Replace the bulb.See page 142 or contact an
Abarth Dealership.
... THE REMOTE CONTROL DOES NOT
WORK.Replace the batteries inside the remote
control.See page 13 or contact an
Abarth Dealership.
... AN ELECTRIC WINDOW DOES NOT
WORK.Check the relevant protection fuse.See GENERAL
INFORMATION
page 144 or
contact an Abarth
Dealership.
Have the relevant window raising / lowering
motor checked.Contact an Abarth
Dealership.
... AN INSTRUMENT PANEL WARNING
LIGHT SWITCHES ON.- See page 83.
195

RIGHT HAND DRIVE
DASHBOARD
1. Side vent 2. Left stalk: external lights controls 3. Turbo pressure gauge 4. Instrument panel and warning lights 5. Right stalk: controls wiper,
washer, trip computer 6. Passenger air bag 7. Oddment compartment/hidden document tray 8. Power windows control 9. Driver air bag.
11
7
7777
9
6
11775
88
2773
1AB0A0229
1
RIGHT HAND DRIVE VERSIONS
197

Front airbags .................................. 114
Front light clusters (bulb
replacement) ................................ 139
Front roof light ................................ 33
Fuel consumption .......................... 191
Fuel cut-off system......................... 35
Fuel supply..................................... 175
Fuel tank plug ................................ 65
Fuse boxes (location) ..................... 144
Fuses (replacement) ....................... 144
Gear Shift Indicator (system) ......... 69
Glove compartment ....................... 37
Handbrake.................................... 123
Hazard warning lights..................... 35
HBA system ................................... 54
Headlight alignment corrector ........ 51
Headlights (adjusting headlights
abroad) ........................................ 52
Headlights...................................... 51
Headlights (washing) ...................... 168
Head restraints............................... 17
– Rear head restraints .................. 17
Heated rear window (activation) ..... 25
Heating and ventilation ................... 22
Hill Holder system .......................... 54
Identification data
– bodywork paint plate ................. 172
– chassis marking ........................ 172
– engine marking.......................... 172– identification data plate.............. 172
Ignition switch ................................ 14
Installing electrical/electronic
devices ........................................ 61
Interior fittings ................................ 36
Interior roof light (bulb
replacement) ................................ 142
Interiors (cleaning) .......................... 169
Isofix child restraint system
setup ........................................... 110
iTPMS ............................................ 56
Lifting the car ................................ 149
Lubricants (specifications) .............. 188
Luggage compartment................... 45
– closing ...................................... 45
– extending the luggage
compartment ............................ 46
Luggage compartment light
(bulb replacement) ....................... 143
Luggage compartment light ........... 34
Main beam headlights (bulb
replacement) ................................ 140
Main beam headlights .................... 30
Maintenance and care.................... 154
– heavy-duty use of the car .......... 158
– periodic checks ......................... 158
– scheduled servicing ................... 154
– Scheduled Servicing Plan .......... 155
Manual climate control system ....... 24
– controls ..................................... 24
– maintenance ............................. 25Menu items .................................... 71
MSR system .................................. 54
Number plate lights (bulb
replacement) ................................ 142
Paintwork (maintenance) ............... 167
Parking .......................................... 123
Parking sensors ............................. 62
Passenger side front airbag ............ 115
Performance .................................. 185
Plugs (type) .................................... 174
Pollen filter ..................................... 162
Power socket ................................. 38
Preparation to install a portable
navigation system ........................ 39
Pretensioners ................................. 103
– Load limiters.............................. 103
Protecting the environment ............ 65
Radiofrequency remote control:
ministerial approvals..................... 194
Radio ............................................. 60
Radio transmitters and mobile
phones......................................... 61
Rear light clusters (bulb
replacement) ................................ 141
Rear seats (backrest release).......... 16
Rear view mirrors ........................... 19
Rear window washer (jets).............. 166
Rear window wiper/washer ............ 32
Reconfigurable multifunction
display ......................................... 68
INDEX