2016 Abarth 500 window

REPLACING THE REAR
WINDOW WIPER BLADE
Proceed as follows:
❒raise the cover A fig. 131 and remove
the arm from the car, undoing the nut
B fig. 131 that fastens it to the pivot
pin;
❒correctly position the new arm and
tighten the nut fully;
❒lower the cover.
JETS
Windscreen washer
If the jet of fluid is inadequate, firstly
check that there is fluid in the reservoir
(see "Checking levels" in this chapter).
Then check that the jet holes are not
clogged; use a needle to unblock them
if necessary.The windscreen jets are directed by
adjusting the angle.
The jets should be directed at about
1/3 of the height from the top edge of
the windscreen fig. 132.
IMPORTANT In versions with a sun
roof, make sure that the sun roof is
closed before operating the front jets.Rear window washer
The rear window washer jets are fixed.
The jet holder is on the rear window
fig. 133.
WARNING
144) Driving with worn windscreen/
rear window wiper blades is a
serious hazard, because visibility
is reduced in bad weather.
131AB0A0113
132AB0A0114
133AB0A0115
166
SERVICING AND MAINTENANCE

Dry the less visible parts with special
care, such as the door frames, bonnet
and the headlight frames, where water
may stagnate more easily. The car
should not be taken to a closed area
immediately, but left outside so that
residual water can evaporate.
Do not wash the car after it has been
left in the sun or with the bonnet hot:
this may alter the shine of the
paintwork.
Exterior plastic parts must be cleaned
in the same way as the rest of the car.
Where possible, do not park under
trees; the resinous substance that
many species release give the paint a
dull appearance and increase the
possibility of triggering rusting
processes.
IMPORTANT Bird droppings must be
washed off immediately and thoroughly
as the acid they contain is particularly
aggressive.
5)
34)
Windows
To clean glasses, use specific cleaning
products.
Use clean cloths to avoid scratching
the glass or damaging the
transparency.
IMPORTANT Wipe the rear window
inside gently with a cloth following the
direction of the filaments to avoid
damaging the heating device.
Headlights
Use a soft cloth soaked in water and
detergent for washing cars.
IMPORTANT Never use aromatic
substances (e.g. petrol) or ketones (e.g.
acetone) for cleaning the plastic lenses
of the headlights.
IMPORTANT When cleaning with a
pressure washer, keep the water jet at
least 20 cm away from the headlights.Engine compartment
Wash the engine compartment
thoroughly at the end of every winter.
Be careful not to direct the jet of water
onto electronic control units.
Adequately protect the upper air
intakes to prevent damage to the
windscreen wiper motor. Have this
operation performed at a specialised
workshop.
IMPORTANT The washing should take
place with the engine cold and the
ignition key in the STOP position. After
the washing operation, make sure
that the various protections (e.g. rubber
caps and guards) have not been
removed or damaged.
IMPORTANT
5) Detergents cause water pollution.
The vehicle should be washed in
areas equipped for collecting
and purifying the liquid used in
the washing process.
168
SERVICING AND MAINTENANCE

SUPPLIES
Version 1.4 TB PETROL ABARTH
Prescribed fuels and original
lubricants
Fuel tank (litres) 35
Unleaded petrol not less than 95 RON
(EN 228 specification)
Fuel tank reserve (litres) 5
Engine cooling system (litres) 5.15Mixture of 50% distilled water and 50%
PARAFLU
UP(*)
Engine sump (litres) 2.75
SELENIA ABARTH 10W50
Engine sump and filter (litres) 2.90
Gearbox/differential casing (litres) 1.65TUTELA CAR TECHNYX
Hydraulic brake circuit (kg) 0.55TUTELA TOP 4
Windscreen and rear window washer
fluid reservoir (litres)2.5Mixture of water andTUTELA
PROFESSIONAL SC35
(*) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLUUPand demineralised water.
187

UseFluid and lubricant features for a correct use of
the carGenuine fluids
and lubricantsApplications
Protective agent for
radiatorsRed protective with antifreeze action for cooling
systems, based on inhibited monoethylene glycol with
organic formula based on O.A.T.
that passes CUNA NC 956-16, ASTM D 3306
specificationsPARAFLU
UP(*)
Contractual
Technical Reference
No. F101.M01Cooling circuit
usage percentage:
50% distilled water
50% PARAFLU
UP
(**)
Windscreen/rear
window washer fluidMixture of alcohol, water and surfactants CUNA NC
956-IITUTELA
PROFESSIONAL
SC35Contractual
Technical Reference
No. F201.D02To be used diluted
or undiluted in
screen washer/
wiper systems
(*) IMPORTANT Do not top up or mix with other fluids which have different specifications from those described.
(**) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLUUPand demineralised water.
190
TECHNICAL SPECIFICATIONS

WHATTODOIF
Fault Possible solution
... A TYRE IS PUNCTURED. Use the Fix&Go tyre repair kit. See page 131
... A TYRE DEFLATES. Restore the correct pressure. See page 183
... THE BATTERY IS FLAT. -See page 149 or contact an
Abarth Dealership.
... THE INTERNAL ROOF LIGHT DOES NOT
SWITCH ON.Replace the bulb.See page 142 or contact an
Abarth Dealership.
... THE LUGGAGE COMPARTMENT ROOF
LIGHT DOES NOT SWITCH ON.Replace the bulb.See page 143 or contact an
Abarth Dealership.
... AN EXTERNAL BULB (main beam, dipped
beam headlights...) DOES NOT COME ON.-Contact an Abarth
Dealership.
Replace the bulb.See page 142 or contact an
Abarth Dealership.
... THE REMOTE CONTROL DOES NOT
WORK.Replace the batteries inside the remote
control.See page 13 or contact an
Abarth Dealership.
... AN ELECTRIC WINDOW DOES NOT
WORK.Check the relevant protection fuse.See GENERAL
INFORMATION
page 144 or
contact an Abarth
Dealership.
Have the relevant window raising / lowering
motor checked.Contact an Abarth
Dealership.
... AN INSTRUMENT PANEL WARNING
LIGHT SWITCHES ON.- See page 83.
195

RIGHT HAND DRIVE
DASHBOARD
1. Side vent 2. Left stalk: external lights controls 3. Turbo pressure gauge 4. Instrument panel and warning lights 5. Right stalk: controls wiper,
washer, trip computer 6. Passenger air bag 7. Oddment compartment/hidden document tray 8. Power windows control 9. Driver air bag.
11
7
7777
9
6
11775
88
2773
1AB0A0229
1
RIGHT HAND DRIVE VERSIONS
197

INDEX
A
BS .............................................. 53
ABS (system) ................................. 53
Air cleaner ...................................... 162
Analogue pressure gauge............... 79
Automatic climate control
system ......................................... 26
Battery .......................................... 162
– advice for extending lifetime ...... 162
– inspecting the charge ................ 162
– replacement .............................. 162
Battery (recharging) ........................ 149
Bodywork (cleaning and
maintenance) ............................... 167
Bodywork (warranty) ...................... 167
Bonnet ........................................... 48
Brake fluid ...................................... 160
Brakes ........................................... 177
Bulbs
– bulbs (replacement) ................... 135
– general instructions ................... 135
– types of bulbs ........................... 136
Car inactivity ................................. 128
Carrying children safely .................. 105
Checking levels .............................. 159
Cigar lighter.................................... 36
Cleaning and maintenance
– car interior ................................. 169
– leather parts .............................. 169– plastic parts .............................. 169
– seats ......................................... 169
Climate control
– Passenger compartment air
diffusers .................................... 21
Climatic comfort ............................. 21
Clutch ............................................ 176
CO2 emissions............................... 192
CODE Card .................................... 11
Control panel and on-board
instruments .................................. 78
Controls ......................................... 34
Correct reading of the rim .............. 181
Correct tyre reading ....................... 180
Cup/bottle holders ......................... 38
Daytime running lights (DRL) ......... 30
Digital engine coolant
temperature gauge....................... 79
Digital fuel level gauge .................... 79
Dimensions .................................... 184
Dipped headlights (bulb
replacement) ................................ 140
Dipped headlights/side lights ......... 30
Direction indicators (bulb
replacement) ................................ 139
Direction indicators ........................ 31
Display ........................................... 68
Doors ............................................. 42
– Door central
locking/unlocking ...................... 42
– door locking/unlocking .............. 42– opening/closing with the key ..... 42
Driver side knee bag ...................... 115
Driver's side front airbag ................ 114
Dualdrive electric power steering .... 59
EBD (Electronic Brake force
Distribution) .................................. 53
eco Index ....................................... 69
Electric windows ............................ 44
Engine codes - bodywork
versions ....................................... 173
Engine compartment (washing) ...... 168
Engine coolant ............................... 160
Engine............................................ 174
– marking ..................................... 172
Engine oil (consumption) ................ 160
Engine oil (level check) ................... 160
EOBD system ................................ 59
ESC (Electronic Stability Control)
system ......................................... 52
External lights................................. 30
Fiat CODE system......................... 10
Fitting "Universal" child restraint
system ......................................... 107
Fixed glass roof .............................. 40
Fix&Go Automatic (kit) .................... 131
Flashing ......................................... 30
Fluids and lubricants ...................... 188
Fog lights (bulb replacement) ......... 140
Fog lights/rear fog light................... 35
Follow Me Home (device) ............... 31

Front airbags .................................. 114
Front light clusters (bulb
replacement) ................................ 139
Front roof light ................................ 33
Fuel consumption .......................... 191
Fuel cut-off system......................... 35
Fuel supply..................................... 175
Fuel tank plug ................................ 65
Fuse boxes (location) ..................... 144
Fuses (replacement) ....................... 144
Gear Shift Indicator (system) ......... 69
Glove compartment ....................... 37
Handbrake.................................... 123
Hazard warning lights..................... 35
HBA system ................................... 54
Headlight alignment corrector ........ 51
Headlights (adjusting headlights
abroad) ........................................ 52
Headlights...................................... 51
Headlights (washing) ...................... 168
Head restraints............................... 17
– Rear head restraints .................. 17
Heated rear window (activation) ..... 25
Heating and ventilation ................... 22
Hill Holder system .......................... 54
Identification data
– bodywork paint plate ................. 172
– chassis marking ........................ 172
– engine marking.......................... 172– identification data plate.............. 172
Ignition switch ................................ 14
Installing electrical/electronic
devices ........................................ 61
Interior fittings ................................ 36
Interior roof light (bulb
replacement) ................................ 142
Interiors (cleaning) .......................... 169
Isofix child restraint system
setup ........................................... 110
iTPMS ............................................ 56
Lifting the car ................................ 149
Lubricants (specifications) .............. 188
Luggage compartment................... 45
– closing ...................................... 45
– extending the luggage
compartment ............................ 46
Luggage compartment light
(bulb replacement) ....................... 143
Luggage compartment light ........... 34
Main beam headlights (bulb
replacement) ................................ 140
Main beam headlights .................... 30
Maintenance and care.................... 154
– heavy-duty use of the car .......... 158
– periodic checks ......................... 158
– scheduled servicing ................... 154
– Scheduled Servicing Plan .......... 155
Manual climate control system ....... 24
– controls ..................................... 24
– maintenance ............................. 25Menu items .................................... 71
MSR system .................................. 54
Number plate lights (bulb
replacement) ................................ 142
Paintwork (maintenance) ............... 167
Parking .......................................... 123
Parking sensors ............................. 62
Passenger side front airbag ............ 115
Performance .................................. 185
Plugs (type) .................................... 174
Pollen filter ..................................... 162
Power socket ................................. 38
Preparation to install a portable
navigation system ........................ 39
Pretensioners ................................. 103
– Load limiters.............................. 103
Protecting the environment ............ 65
Radiofrequency remote control:
ministerial approvals..................... 194
Radio ............................................. 60
Radio transmitters and mobile
phones......................................... 61
Rear light clusters (bulb
replacement) ................................ 141
Rear seats (backrest release).......... 16
Rear view mirrors ........................... 19
Rear window washer (jets).............. 166
Rear window wiper/washer ............ 32
Reconfigurable multifunction
display ......................................... 68
INDEX