2016.5 VAUXHALL VIVARO stop start

Driving and operating141The flow and filterability of diesel fuels
are temperature-dependent. When
temperatures are low, refuel with
diesel fuel with guaranteed winter
properties.
Diesel fuel filter 3 152, diesel fuel
system bleeding 3 152.
Refuelling9 Danger
Before refuelling, switch off engine
and any external heaters with
combustion chambers.
Vehicles with stop-start system:
The engine must be switched off
and the ignition key removed, to avoid risk of engine being
restarted automatically by the
system.
Switch off any mobile phones.
Follow the operating and safety
instructions of the filling station
when refuelling.
9 Danger
Fuel is flammable and explosive.
No smoking. No naked flames or
sparks.
If you can smell fuel in your
vehicle, have the cause of this
remedied immediately by a
workshop.
Caution
In case of misfuelling, do not
switch on ignition.
Notice
To ensure the fuel level is displayed
correctly, the ignition must be
switched off before refuelling. Avoid
minor fuel top-ups (e.g. less than
5 litres) to ensure accurate readings.
The fuel filler flap is located on the left-
hand side of the vehicle.
The fuel filler flap can only be opened
if the vehicle is unlocked and the left-
hand door is opened.
Pull flap to open.
To open the fuel filler cap, turn
anticlockwise.
The fuel filler cap can be retained in
the bracket on the fuel filler flap.
For refuelling, fully insert the pump
nozzle and switch it on.
After automatic cut-off, it can be
topped up by operating the pump
nozzle a maximum of two more times.
Caution
Wipe off any overflowing fuel
immediately.

146Vehicle careVehicle checks
Performing work9 Warning
Only perform engine compartment
checks when the ignition is off.
The cooling fan may start
operating even if the ignition is off.
9 Danger
The ignition system generates
extremely high voltages. Do not
touch.
The caps for topping up the engine oil, the coolant, the washer fluid and the
oil dipstick handle are yellow for ease
of identification.
Bonnet
Opening
Pull the release lever and return it to
its original position.
Move the safety catch (located
slightly right of centre) sideways to
the left vehicle side and open the
bonnet.
The bonnet is held open
automatically by a lifter.
If the bonnet is opened during an
Autostop, the engine will be restarted automatically for safety reasons.
Stop-start system 3 119.
Closing
Lower the bonnet and allow it to fall
into the latch from a low height
(approx. 30 cm). Check that the
bonnet is engaged.

Vehicle care151battery. Short-distance driving and
frequent engine starts can discharge
the battery. Avoid the use of
unnecessary electrical consumers.
Batteries do not belong in household
waste. They must be disposed of at
an appropriate recycling collection
point.
Laying up the vehicle for more than
4 weeks can lead to battery
discharge.
Ensure the ignition is switched off
before connecting or disconnecting
the vehicle battery.
Replacing the vehicle battery In vehicles with an AGM (Absorptive
Glass Mat) battery, make sure to
have the battery replaced with
another AGM battery.
An AGM battery can be identified by
the label on the battery. We
recommend the use of an original
Vauxhall battery.
Notice
Using an AGM vehicle battery
different from the original Vauxhall
vehicle battery may result in a lower
performance of the stop-start
system.
We recommend that you have the
vehicle battery replaced by a
workshop.
Stop-start system 3 119.
Charging the vehicle battery9 Warning
On vehicles with stop-start
system, ensure that the charging potential does not exceed
14.6 volts when using a battery
charger. Otherwise the vehicle
battery might be damaged.
9 Danger
Ensure adequate ventilation when
charging the battery. There is a
risk of explosion if gases
generated during charging are
allowed to accumulate!
Jump starting 3 174.

Vehicle care153● Switch on the ignition (key toposition 2) for 5 seconds at a
time.
● Switch off ignition (key to position
1 ) for 3 seconds.
● Repeat this process multiple times.
● Start the engine (key to position 3) then switch off (key to position
0 ).
Ignition switch positions 3 116.
With power button● Insert the electronic key in the card reader.
● Press START/STOP without
pressing any of the pedals.
● Wait a few minutes before starting engine.
Power button 3 116.
If the engine fails to start, seek the
assistance of a workshop.
Starting the engine 3 118.
Wiper blade replacement Wiper blades on the windscreenLift the wiper arm, press button to
disengage the wiper blade and
remove.
Attach new wiper blade slightly
angled to the wiper arm and push until
it engages.
Lower wiper arm carefully.
Wiper blade on the rear window
Lift wiper arm, press retaining lugs
together to disengage the wiper blade
and remove.
Lower wiper arm carefully.

202IndexAAbsorptive Glass Mat battery .....150
Accessories and vehicle modifications .......................... 145
Adaptive forward lighting .............98
Adblue .......................................... 93
AdBlue .......................... 88, 123, 182
AdBlue tank ................................ 197
Adjustable air vents ...................112
AGM battery ............................... 150
Airbag and belt tensioners ...........85
Airbag deactivation ................57, 85
Airbag label............................. 53, 57
Airbag system .............................. 53
Air conditioning regular operation ................................ 113
Air conditioning system .............. 104
Air intake .................................... 113
Air recirculation ...................104, 176
Air vents...................................... 112
Alert .............................................. 92
Antifreeze ................................... 148
Antilock brake system ................ 129
Antilock brake system (ABS) .......87
Anti-theft alarm system ................35
Anti-theft bolts............................. 171
Anti-theft locking system .............. 33
Anti-theft security lock ..................23
Appearance care ........................177
Armrest ........................................ 46Ashtrays ....................................... 79
Automatic anti-dazzle ..................39
Automatic fuel cut-off ..................119
Automatic light control .................97
Automatic locking ........................28
Autostop ....................... 89, 118, 119
Auxiliary heater ........................... 108
B Battery ........................................ 150
Battery discharge protection ......102
Battery, jump starting.................. 174
Belts.............................................. 49 Bench seat.................................... 68
BlueInjection ............................... 123
Bonnet ....................................... 146
Bottle holders................................ 68
Brake and clutch fluid .................182
Brake assist ............................... 130
Brake fluid .................................. 150 Brakes ............................... 128, 150
Brake system ............................... 86
Breakdown.................................. 176
Bulb replacement ....................... 154
C
Capacities .................................. 197
Car Pass ...................................... 20
Catalytic converter .....................123
Central locking system ................23
Centre high-mounted brake light 156

206Seat belt ........................................ 8
Seat belt reminder .......................85
Seat belts ..................................... 49
Seat folding .................................. 45
Seat heating ................................. 46
Seat position ................................ 43
Seats ............................................ 68
Selective catalytic reduction .......123
Service ............................... 113, 181
Service display ............................ 81
Service information ....................181
Service vehicle soon .................... 86
Side airbag system ......................56
Sidelights ...................................... 96
Side turn signal lights ................156
Sliding door .................................. 29
Spare wheel ............................... 173
Spare wheel security tool ...........163
Speed limiter......................... 79, 136
Speedometer ............................... 79
Starting and operating ................116
Starting off ................................... 17
Starting the engine ...............17, 118
Steering ...................................... 115
Steering column controls ..............75
Steering wheel adjustment ......9, 75
Steering wheel controls ...............75
Stop engine .................................. 86
Stop-start system.................. 17, 119
Storage ......................................... 66Storage box.................................. 68
Storage compartment ...................67
Storage compartments .................66
Sun visors .................................... 41
Symbols ......................................... 4
T
Tablet holder................................. 66 Tachograph ............................ 90, 95
Tachometer ................................. 80
Tailgate ......................................... 32
Tailgate emergency release .........32
Tail lights ................................... 155
Technical data ............................ 187
Temporary spare wheel ..............173
Three-point seat belt .................... 50
Toll road stickers .......................... 39
Tools .......................................... 163
Top-tether fastening eyes ............65
Torx key ...................................... 163
Tow bar....................................... 142
Towing ................................ 142, 176
Towing another vehicle .............177
Towing a trailer ........................... 143
Towing eye ......................... 163, 176
Towing the vehicle .....................176
Traction Control system ............. 130
Trailer coupling ........................... 142
Trailer stability assist .................143
Trailer towing ............................. 143Transmission ............................... 16
Tread depth ............................... 167
Trip computer .............................. 93
Trip odometer .............................. 80
Turbo engine warm-up ...............118
Turn and lane-change signals .....99
Turn signal ................................... 84
Tyre chains ................................ 168
Tyre changing ............................. 171
Tyre designations ......................164
Tyre pressure ............................ 164
Tyre pressure monitoring system ............................... 88, 166
Tyre pressures ........................... 198
Tyre repair kit ............................. 169
Tyres .......................................... 164
Tyres and wheel size, changing. 168
U Ultrasonic parking assist............. 136
Underseat storage .......................68
Upholstery .................................. 179
Upshift .......................................... 87
Using this manual ..........................3
V Vehicle battery ...................150, 174
Vehicle checks............................ 146
Vehicle data ................................ 186
Vehicle data recording and privacy ..................................... 201