2016.5 VAUXHALL MOVANO_B brake

188Vehicle care
19. Continue driving immediately sothat the sealant is evenlydistributed throughout the tyre.
After driving approx. 6 miles, but
no more than 10 minutes, stop
and check tyre pressure using the
compressor. Screw compressor
air hose directly onto tyre valve
and compressor when doing this.
20. If the tyre pressure is more than 3.1 bar , set it to the correct value.
Repeat the procedure until there
is no more loss of pressure.
If the tyre pressure has fallen
below 3.1 bar, the vehicle must
not be driven. Seek the
assistance of a workshop.
21. Stow tyre repair kit under the front
seat.
Notice
The driving characteristics of the repaired tyre are severely affected,
therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
The built-in safety valve opens at a
pressure of 7 bar (102 psi).
Note the expiry date of the kit. After
this date its sealing capability is no
longer guaranteed. Pay attention to
storage information on sealant
bottle.
Replace the used sealant bottle. Dispose of the bottle as prescribed
by applicable laws.
The compressor and sealant can be
used from approx. -30 °C.Wheel changing
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel
3 185.
Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-slippery surface. The
front wheels must be in the
straight-ahead position.
● Apply the parking brake and engage first gear or reverse gear
(manual transmission) or N
(manual transmission
automated).
● Switch off the air suspension system 3 125.
● Remove the spare wheel 3 190.
● Never change more than one wheel at a time.
● Use the jack only to change wheels in case of puncture, not
for seasonal winter or summer
tyre change.
● The jack is maintenance-free.

194Vehicle care● Use a booster battery with thesame voltage (12 volts). Its
capacity (Ah) must not be much less than that of the discharged
vehicle battery.
● Use jump leads with insulated terminals and a cross section of
at least 25 mm 2
.
● Do not disconnect the discharged
battery from the vehicle.
● Switch off all unnecessary electrical consumers.
● Switch off the air suspension system 3 125.
● Do not lean over the vehicle battery during jump starting.
● Do not allow the terminals of one
lead to touch those of the other
lead.
● The vehicles must not come into contact with each other during
the jump starting process.
● Apply the parking brake and engage neutral (manual
transmission) or N (manual
transmission automated).Jump start terminal
In the event of a discharged vehicle
battery, the jump start terminal
enables the vehicle to be started
without the need to access the battery inside the vehicle.
The jump start terminal is located in
the engine compartment and
identified by a " <" sign on the red
insulating cover. Lift the red insulating
cover to access the terminal
connector.
Ensure the red insulating cover is
latched back into position when not in
use.
Jump starting procedure
Depending on model, the jump start
terminal may be located at the left-
hand or right-hand side of the engine
compartment.

196Vehicle careCaution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Switch off the air suspension system 3 125.
Transmission in neutral.
Caution
Vehicles with manual
transmission automated: If neutral cannot be selected, the vehiclemust only be towed with the drive
wheels raised off the ground.
The vehicle should always be
towed with the ignition switched
off.
Manual transmission automated
3 134.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the
air recirculation system 3 106 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and refit the cover.
Towing another vehicle
Attach a tow rope - or better still a tow
rod - to the rear towing eye, never to
the rear axle and suspension units.
The rear towing eye must only be
used for towing and not recovering a
vehicle.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.

202Service and maintenanceEngine oil viscosity grades
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade
depending on the minimum ambient
temperature 3 205.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only silicate-free long life coolant (LLC) antifreeze approved for the
vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C.
This concentration should be
maintained all year round. The use of additional coolant additives that
intend to give additional corrosionprotection or seal against minor leaks
can cause function problems. Liability
for consequences resulting from the
use of additional coolant additives will be rejected.
Brake fluid
Over time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should
therefore be replaced at the specified interval.
AdBlue Only use AdBlue to reduce the
nitrogen oxides in the exhaust
emission 3 128.

230IndexAAbsorptive Glass Mat battery .....163
Accessories and vehicle modifications .......................... 158
Adaptive forward lighting ...100, 169
AdBlue .......................... 89, 128, 201
Adblue gauge ............................... 80
AdBlue tank ................................ 224
Adjustable air vents ...................115
AGM battery ............................... 163
Airbag and belt tensioners ...........86
Airbag deactivation ................55, 86
Airbag label................................... 51 Airbag system .............................. 51
Air conditioning regular operation ................................ 117
Air conditioning system .............. 106
Air intake .................................... 116
Air suspension ........................... 125
Air suspension system................ 195
Air vents...................................... 115
Antifreeze ................................... 161
Antilock brake system ................ 137
Antilock brake system (ABS) .......88
Anti-theft alarm system ................31
Anti-theft bolts............................. 188
Anti-theft locking system .............. 31
Anti-theft security lock ..................21
Appearance care ........................197
Armrest ........................................ 45Ashtrays ....................................... 79
Automatic light control .................97
Automatic locking ...................21, 25
Autostop ............................. 121, 122
Auxiliary heater ........................... 111
B
Battery discharge protection ......104
Battery, jump starting.................. 193
Belts.............................................. 48 BlueInjection ............................... 128
Bonnet ....................................... 159
Brake assist ............................... 139
Brake fluid .......................... 163, 201
Brakes ............................... 137, 163
Brake system ............................... 88
Breakdown.................................. 195
Bulb replacement ....................... 167
C Capacities .................................. 224
Cargo management system ........69
Car Pass ...................................... 19
Catalytic converter .....................127
Central locking system ................21
Centre high-mounted brake light 172
Changing tyre and wheel size ...184
Charging system .......................... 87
Child locks ................................... 25
Child restraint installation locations ................................... 58

232Front storage................................ 67
Front turn signal lights ...............170
Fuel consumption - CO 2-
Emissions ............................... 153
Fuel economy rating (ecoScoring) 94
Fuel for diesel engines ..............151
Fuel gauge ................................... 80
Fuel tank ..................................... 224
Fuse box ............................. 176, 177
Fuses ......................................... 174
G Gauges ......................................... 79
General information ...................153
Glass panel .................................. 38
Glovebox ..................................... 67
Glovebox cooler ......................... 116
Ground clearance .......................125
H Hand brake - see Parking brake. 138
Hazard warning flashers ............100
Headlight flash ............................. 99
Headlight range adjustment ........99
Headlights ...................... 97, 98, 167
Headlights when driving abroad ..99
Head restraint adjustment .............8
Head restraints ............................ 39
Heated exterior mirrors .................15
Heated mirrors ............................. 34
Heated rear window ...............15, 37Heating ........................................ 45
Heating and ventilation system . 105
High beam ............................. 91, 98
High beam assist ....................91, 98
Hill start assist ........................... 139
Horn ....................................... 14, 75
Hub cap hook ............................. 179
I
Identification plate .....................204
Idle speed control .......................121
Ignition switch positions .............120
Immobiliser .................................. 32
Indicators ...................................... 79
Info display ................................... 92
Information displays...................... 92
Initial drive information.................... 6
Instrument cluster ........................79
Instrument panel fuse box .........176
Instrument panel illumination .....174
Instrument panel overview ........... 10
Instrument panel storage .............66
Interior care ............................... 198
Interior lighting ............................ 101
Interior lights ...................... 101, 173
Interior mirrors .............................. 35
Interruption of power supply ......137
Introduction .................................... 3
ISOFIX child restraint systems ....65J
Jack ............................................ 179
Journey record.............................. 94
Jump starting ............................. 193
K Keys ............................................. 19
Keys, locks ................................... 19
L
Lane departure warning .......88, 150
Lashing eyes ............................... 69
Light covers, misted.................... 101
Lighting ......................................... 97
Lighting features .........................103
Light switch .................................. 97
Load compartment........................ 21 Load compartment fuse box ......177
Load compartment lighting .........102
Loading information .....................72
Low fuel ....................................... 90
M Malfunction indicator light ............87
Manual adjustment ......................33
Manual anti-dazzle ......................35
Manual door locks ........................21
Manual mode ............................. 135
Manual transmission............. 16, 133
Manual transmission automated ......................... 16, 134

233Manual windows ..........................35
Messages ..................................... 92
Mirror adjustment ........................... 8
Mirrors .................................... 33, 35
Misted light covers .....................101
N New vehicle running-in ..............120
Number plate light .....................173
O Object detection systems ...........146
Odometer ..................................... 80 Oil ............................................... 160
Oil, engine .......................... 201, 205
Oil level ......................................... 81
Oil pressure .................................. 90
Outside temperature ....................77
Overcab storage ..........................68
Overhead console .......................67
Overrun cut-off ........................... 122
P
Parking ................................ 17, 124
Parking assist ............................ 146
Parking brake ............................ 138
Parking ticket holder .....................37
Particulate filter ........................... 127
Performing work ........................159
Pollen filter ................................. 116
Power door locks ..........................24Power outlets ............................... 78
Power side step ............................ 26
Power sliding door ........................26
Power steering fluid ....................162
Power take-off ............................ 155
Power windows ............................ 35
Preheating ........................... 89, 121
Puncture ............................. 185, 188
R Radio Frequency Identification (RFID) ..................................... 228
Radio remote control ...................20
Rain sensor .................................. 76
Reading lights ............................ 102
Rear air conditioning system .....110
Rear bench seat storage ..............68
Rear courtesy light...................... 101
Rear doors ................................... 29
Rear fog light ............................... 91
Rear fog lights ...................... 97, 101
Rear heating system .................. 109
Rear reading light .......................102
Rear seats .................................... 46
Rear storage ................................. 68
Rear view camera ...................... 147
Rear windows .............................. 36
Recommended fluids and lubricants ........................ 201, 205
Refuelling ................................... 152Remote control ............................. 20
Retractable parking brake ..........138
Reversing lights .........................101
Ride control systems ..................140
Ride height ................................. 125
Roof .............................................. 38
Roof load ...................................... 72
Roof rack ..................................... 72
S Safety belts ................................... 48
Safety net .................................... 71
Seat adjustment ....................... 7, 41
Seat belt ........................................ 8
Seat belt reminder .......................86
Seat belts ..................................... 48
Seat heating ................................. 45
Seat position ................................ 40
Selective catalytic reduction .......128
Selector lever ............................. 134
Service ............................... 117, 200
Service display ......................82, 87
Service information ....................200
Service vehicle soon .................... 87
Side airbag system ......................54
Sidelights ...................................... 97
Side turn signal lights ................171
Side windows................................ 36
Sliding door .................................. 26
Spare wheel ............................... 190