2015 TOYOTA HILUX check engine

3846-3. Do-it-yourself maintenance
HILUX_OM_OM0K219E_(EE)■
Adding engine oil
If the oil level is below or near
the low level mark, add engine
oil of the same type as that
already in the engine.
Make sure to check the oil type and prepare the items needed
before adding oil.
*: The model code is indicated on the manufacturer’s label or plate.
(→ P. 494)
Remove the sand and dust from around the oil filler cap.
Remove the oil filler cap by turning it counterclockwise.
Add engine oil slowly, checking the dipstick.
Install the oil filler cap by turning it clockwise.
Engine oil selection→P. 500
Oil quantity
(Low → Full)
Gasoline engine 1.5 L (1.6 qt., 1.3 Imp.qt.)
Diesel engine
XFor Russia, Ukraine and
KUN25L-PRMDH models
*
1.6 L (1.7 qt., 1.4 Imp.qt.)
XExcept for Russia, Ukraine and
KUN25L-PRMDH models
*
1.4 L (1.5 qt., 1.2 Imp.qt.)
Items Clean funnel
1
2
3
4
HILUX_OM_OM0K219E_(EE).book Page 384 Wednesday, May 14, 2014 3:06 PM

3866-3. Do-it-yourself maintenance
HILUX_OM_OM0K219E_(EE)
CAUTION
■Used engine oil
● Used engine oil contains potentially harmful contaminants which may
cause skin disorders such as inflammation and skin cancer, so care
should be taken to avoid prolonged and repeated contact. To remove used
engine oil from your skin, wash thoroughly with soap and water.
● Dispose of used oil and filters only in a safe and acceptable manner. Do
not dispose of used oil and filters in household trash, in sewers or onto the
ground. Call any authorized Toyota deal er or repairer, or another duly
qualified and equipped professional, service station or auto parts store for
information concerning recycling or disposal.
● Do not leave used engine oil within the reach of children.
NOTICE
■To prevent serious engine damage
Check the oil level on a regular basis.
■
When replacing the engine oil
● Be careful not to spill engine oil on the vehicle components.
● Avoid overfilling, or the engine could be damaged.
● Check the oil level on the dipstick every time you refill the vehicle.
● Be sure the engine oil filler cap is properly tightened.
HILUX_OM_OM0K219E_(EE).book Page 386 Wednesday, May 14, 2014 3:06 PM

3876-3. Do-it-yourself maintenance
6
Maintenance and care
HILUX_OM_OM0K219E_(EE)
The coolant level is satisfactory if it is between the upper and lower
lines on the reservoir when the engine is cold.Reservoir cap
Upper line
Lower line
If the level is on or below the lower line, add coolant up to the upper line.
(→ P. 482)
■Coolant selection
Only use “Toyota Super Long Life Coolant” or a similar high quality ethylene
glycol based non-silicate, non-amine, non- nitrite, and non-borate coolant with
long-life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deion-
ized water. (Minimum temperature: -35 °C [-31 °F])
For more details about engine coolant, contact any authorized Toyota dealer
or repairer, or another duly qualified and equipped professional.
■ If the coolant level drops within a short time of replenishing
Visually check the radiator, hoses, engine coolant reservoir caps, drain cock
and water pump. If you cannot find a leak, have any authorized Toyota dealer
or repairer, or another duly qualified and equipped professional test the cap
and check for leaks in the cooling system.
Engine coolant
1
2
3
XGasoline engineXDiesel engine
HILUX_OM_OM0K219E_(EE).book Page 387 Wednesday, May 14, 2014 3:06 PM

3896-3. Do-it-yourself maintenance
6
Maintenance and care
HILUX_OM_OM0K219E_(EE)
Check the radiator, condenser and intercooler and clear away any for-
eign objects. If any of the above parts is extremely dirty or you are not
sure of their condition, have your vehicle inspected by any authorized
Toyota dealer or repairer, or another duly qualified and equipped pro-
fessional.
Radiator, condenser and intercooler (if equipped)
CAUTION
■When the engine is hot
Do not touch the radiator, condenser or intercooler as they may be hot and
cause serious injuries, such as burns.
HILUX_OM_OM0K219E_(EE).book Page 389 Wednesday, May 14, 2014 3:06 PM

409
6
6-3. Do-it-yourself maintenance
Maintenance and care
HILUX_OM_OM0K219E_(EE)
Checking and replacing fuses
Turn the engine switch off.
After a system failure, see “Fuse layout and amperage ratings”
(→ P. 414) for details about which fuse to check.
Open the fuse box cover.
XEngine compartment
Push the tab in and lift the lid off.
If any of the electrical components do not operate, a fuse may
have blown. If this happens, check and replace the fuses as nec-
essary.
1
2
3
HILUX_OM_OM0K219E_(EE).book Page 409 Wednesday, May 14, 2014 3:06 PM

4537-2. Steps to take in an emergency
7
When trouble arises
HILUX_OM_OM0K219E_(EE)
*1: The model code is indicated on the manufacturer’s label or plate. (→ P. 494)
*2: Driver’s seat belt buzzer:
The driver’s seat belt buzzer sounds to alert the driver that his or her seat
belt is not fastened. The buzzer sounds intermittently for 30 seconds after
the vehicle reaches a speed of 15 km/h (9 mph). Then, if the seat belt is
still unfastened, the buzzer will sound in a different tone for 90 more sec-
onds.
*3: Except for KUN25L-PRMDH model*1
Low engine oil level warn-
ing light (diesel engine)
*3
Indicates that engine oil
level is low
Check the level of engine oil
and add more oil if neces-
sary.
(remains on)
Engine oil change
reminder light (diesel
engine)
*3
XExcept for Russia and
Ukraine
Indicates that the engine
oil should be changed
Comes on approximately
30000 km (18000 miles)
after the engine oil has
been changed (and the oil
maintenance data has
been reset)
XFor Russia and Ukraine
You have forgotten to reset
the oil change system
Change the engine oil in
accordance with the main-
tenance schedule.
Have the engine oil and oil
filter checked and/or
changed by any authorized
Toyota dealer or repairer, or
another duly qualified and
equipped professional. After
changing the engine oil, the
oil change system should be
reset. ( →P. 385)
Warning lightWarning light/DetailsCorrection procedure
HILUX_OM_OM0K219E_(EE).book Page 453 Wednesday, May 14, 2014 3:06 PM

4597-2. Steps to take in an emergency
7
When trouble arises
HILUX_OM_OM0K219E_(EE)
CAUTION
■Using the tire jack
Improper use of the tire jack may cause the vehicle to suddenly fall off the
jack, leading to death or serious injury.
● Do not use the tire jack for any purpose other than replacing tires or install-
ing and removing tire chains.
● Only use the tire jack that comes with this vehicle for replacing a flat tire.
Do not use it on other vehicles, and do not use other tire jacks for replac-
ing tires on this vehicle.
● Always check that the tire jack is securely set to the correct jack up point.
● Do not put any part of your body under the vehicle while it is supported by
the jack.
● Do not start or run the engine while your vehicle is supported by the jack.
● Do not raise the vehicle while someone is inside.
● When raising the vehicle, do not put an object on or under the jack.
● Do not raise the vehicle to a height greater than that required to replace
the tire.
● Use a jack stand if it is necessary to get under the vehicle.
Take particular care when lowering the vehicle to ensure that no one work-
ing on or near the vehicle may be injured.
■
Using the jack handle
Tighten all the jack handle bolts securely using a Phillips-head screwdriver
or your hand, to prevent the extens ion parts from coming apart unexpect-
edly.
● Do not continue jacking up once the yel-
low caution line has appeared.Ye l l o w
caution line
HILUX_OM_OM0K219E_(EE).book Page 459 Wednesday, May 14, 2014 3:06 PM

4847-2. Steps to take in an emergency
HILUX_OM_OM0K219E_(EE)
Start the engine to check that the radiator cooling fan operates and
to check for coolant leaks from the radiator or hoses.
If the fan is not operating:
Stop the engine immediately and contact any authorized Toyota
dealer or repairer, or another duly qualified and equipped profes-
sional.
If the fan is operating:
Have the vehicle inspected at the nearest authorized Toyota dealer
or repairer, or another duly qualified and equipped professional.
CAUTION
■When inspecting under the hood of your vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
● If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot.
● Keep hands and clothing (especially a tie, a scarf or a muffler) away from
the fans and belts. Failure to do so may cause the hands or clothing to be
caught, resulting in serious injury.
● Do not loosen the radiator cap or the coolant reservoir cap while the
engine and radiator are hot. High tem perature steam or coolant could
spray out.
NOTICE
■ When adding engine coolant
Add coolant slowly after the engine has cooled down sufficiently. Adding
cool coolant to a hot engine too quickly can cause damage to the engine.
■
To prevent damage to the cooling system
Observe the following precautions:
● Avoid contaminating the coolant with foreign matter (such as sand or dust
etc.).
● Do not use any coolant additive.
6
7
HILUX_OM_OM0K219E_(EE).book Page 484 Wednesday, May 14, 2014 3:06 PM