2015 SUZUKI NEXA brake
[x] Cancel search: brakePage 127 of 288
Downloaded from www.Manualslib.com manuals search engine
2 3 ( 5 $ 7 , 1 * < 2 8 5 9 ( + , & / (
0 6 (
% U D N H $ V V L V W 6 \ V W H P L I H T X L S S H G When you slam the brakes on, the brake
assist system judges as an emergency
stop and provides more powerful braking
for a driver who cannot hold down the
brake pedal firmly.
NOTE:
If you quickly and forcefully depress the
brakes, you may hear a clicking sound in
the brake pedal. This is normal and indi-
cates that the brake assist system is acti-
vated properly. $ Q W L / R F N % U D N H 6 \ V W H P $ % 6
L I H T X L S S H G ABS will help in avoiding locking of the
wheel by electronically controlling braking
pressure. It will also help you maintain
steering control when braking on slippery
surfaces or when braking hard”
The ABS works automatically, so you do
not need any special braking technique.
Just push the brake pedal down without
pumping. The ABS will operate whenever
it senses that the wheels are locking up.
You may feel the brake pedal moves a little
while the ABS is operating.
NOTE:
The ABS will not work if vehicle speed is
under about 10 km/h (6 mph).
63J081
(1) ABS warning light
(2) Brake system warning light
: $ 5 1 , 1 *
Page 132 of 288
Downloaded from www.Manualslib.com manuals search engine ' 5 , 9 , 1 * 7 , 3 6
0 6 (
pressure shown on the label on the driver’s
side door or the driver’s door lock pillar. + L J K Z D \ ' U L Y L Q JWhen driving at highway speeds, pay
attention to the following:
• Stopping distance progressively
increases with vehicle speed. Apply the
brakes far enough ahead of the stopping
point to allow for the extra stopping dis-
tance.
• On rainy days, hydroplaning can occur.
Hydroplaning is the loss of direct contact
between the road surface and the vehi-
cle’s tires due to a water film forming
between them. Steering or braking the
vehicle while hydroplaning can be very
difficult, and loss of control can occur.
Keep speed down when the road sur-
face is wet.
• At high speeds, the vehicle may be
affected by side winds. Therefore,
reduce speed and be prepared for unex-
pected buffeting, which can occur at the
exits of tunnels, when passing by a cut
of a hill, or when being overtaken by
large vehicles, etc.
' U L Y L Q J R Q + L O O V
64MS171
• When climbing steep hills, the vehicle
may begin to slow down and show a lack
of power. If this happens, you should
shift to a lower gear so that the engine
will again be operating in its normal
power range. Shift rapidly to prevent the
vehicle from losing momentum.
• When driving down a hill, the engine
should be used for braking by shifting to
next lower gear.
: $ 5 1 , 1 *
7 U \ Q R W W R K R O G W K H E U D N H S H G D O G R Z Q
W R R O R Q J R U W R R R I W H Q Z K L O H J R L Q J
G R Z Q D V W H H S R U O R Q J K L O O 7 K L V F R X O G
F D X V H W K H E U D N H V W R R Y H U K H D W U H V X O W
L Q J L Q U H G X F H G E U D N L Q J H I I L F L H Q F \
) D L O X U H W R W D N H W K L V S U H F D X W L R Q F R X O G
U H V X O W L Q O R V V R I Y H K L F O H F R Q W U R O
NOTICE
: K H Q G H V F H Q G L Q J D G R Z Q K L O O
1 ( 9 ( 5 W X U Q W K H L J Q L W L R Q N H \ W R W K H
Page 135 of 288
Downloaded from www.Manualslib.com manuals search engine
' 5 , 9 , 1 * 7 , 3 6
0 6 (
' R ¶ V D Q G ' R Q W ¶ V I R U 6 D I H
' U L Y L Q JExercise care in handling your vehicle. Be
conscious of not only your own safety but
also the safety of others on the road, and
thus enjoy the best and most comfortable
driving experience.
This section contains basic rules for safe
driving. Read it carefully for good under-
standing of the content so that you can
enjoy safe and pleasant driving in your
vehicle.
6 W D U W L Q J
1) Adjust the driver’s seat for the proper
driving posture.
2) Adjust the rear view mirror so as to
obtain the best possible rear view.
3) Before moving off, look forward and
back to confirm safety.4) Don’t start quickly, since it is dangerous
and wastes fuel.
* H Q H U D O G U L Y L Q J
1) Be sure to stop before the stop light and
stop sign. When moving into the inter-
section without any traffic lights or
signs, drive slowly to confirm safety.
72F-08-002
2) Always follow other vehicles at a safe
distance in order to prevent a rear-end
collision, in case the vehicle ahead
make a sudden stop.
3) Turn ON the turn signal at least 30
meters before making a turn or chang-
ing the lane so as not to be hit from
behind.
4) Before entering a corner, decelerate to
a safe speed. Don’t apply brakes during
cornering, or a cornering skid may
occur.5) When overtaking other vehicles, watch
out for the oncoming vehicle and care-
fully confirm the safety.
6) Don’t attempt zigzag driving which will
hinder your control over the vehicle and
cause an accident.
72F-08-011
% U D N L Q J
1) Use the parking brake when parking
your vehicle and shift the gear shift
lever into the first gear or reverse gear
position for the sake of safety.
Page 136 of 288
Downloaded from www.Manualslib.com manuals search engine ' 5 , 9 , 1 * 7 , 3 6
0 6 (
2) Don’t use hand-braking unless una-
voidable. It causes the vehicle to skid
and a rearend collision occur. It is espe-
cially dangerous when the tyres are
worn, for they allow a larger skid.
72F-08-012
Use foot brake in three stages
1.Warn the vehicle behind you
2.Gradually apply the brake.
3.Bring the vehicle to a halt.
3) When driving on a downhill, try not to
apply the brake but use the engine
brake effectively. Overuse of the foot
brake may result in total brake failure.
4) Avoid reckless high speed driving and
try to drive at a safe speed suitable for
the road conditions while maintaining a
constant speed.
72F-08-015
5) The higher the speed, the narrower the
driver’s visual range becomes. In such
a state, it is difficult to anticipate any
hazard and the driver feels much
fatigued.
6) Never do sharp handling during high
speed driving. You will lose your control
over your vehicle.
7) When overtaking or changing the lane
while driving at a high speed, keep an
ample vehicle-to-vehicle distance. / R Q J G L V W D Q F H G U L Y L Q J
1) Be sure to perform safety checks before
starting a trip.
2) Take rest at certain intervals to prevent
an accident which may occur when you
are sleepy or tired.
72F-08-020
1 L J K W W L P H G U L Y L Q J
1) Drive more slowly at night than in the
daytime, for the visual range is
restricted at night.
2) Don’t overtake other vehicles at night.
Darkness bothers your sense of speed
and hinders your judgment on the vehi-
cle-to-vehicle distance.
3) Don’t use the high headlight beam
unless its use is inevitable. Its dazzle
may blitz the driver of the oncoming
vehicle, thus causing an accident.
4) Always keep the window glasses clean.
Don’t operate the windshield wiper
Page 226 of 288
Downloaded from www.Manualslib.com manuals search engine 7-3INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
Engine
1-1
l
l
l
R
l
R
l
R
l
R
1-2- - RRRRRRRR
1-3
l
l
l
l
l
l
l
l
l
l
1-
) ) ) ) ) ) ) ) ) )
1-
Engine Coolant (Level, Leakage)
Engine oil and engine oil
F I L T E R
Cooling system hoses and connections (Leakage and Damage)
Engine Mounting and -anifold &ixing . O I S E , E A K A G E $ A M A G E E T C
Exhaust System (Noise, Leakage etc.
-l-l-I-I-l
1- Exhaust Gas Recirculation Valve
D13A engine ----C--C--
FUEL
2-1.
Air cleaner filter element
Paved-road
Clean after 5,000 KM. Replace after every 40,000 KM.
Dusty Condition
Clean after 2,500 KM or as required. Replace after every 40,000 KM.
Replace more frequently if dust condition is severe.
2-2.
Fuel tank cap, fuel lines and connections (Leakage and Damage)
-
l
-
-
-
l
-
-
-
l
2-3.
Fuel Filter and Water Draining
I
l
I
R
I
R
I
R
I
R
CLUTCH AND TRANSMISSION
3-1.
Clutch fluid (level, leakage)
l
l
l
R
l
R
l
R
l
R
3-2.Clutch slipping (Dragging or Excess Damage) llllllllll
3-3.
Manual Transmission/Transfer or Differential Oil (Level, Leakage)
Replace at 1,60,000 km or 10 years whichever comes first
I
I
I
I
I
I
I
I
I
I
DRIVE SHAFT
4-1.
Drive shaft boot (boot damage)
-
l
l
l
l
l
l
l
l
l
BRAKE
5-1.
Brake Fluid (Level, Leakage)
I
I
I
R
I
R
I
R
I
R
5-2. Brake pedal (pedal - wall clearance) I I I I I I I I I I
5-3.
Parking brake lever and cable (Play, damage)
I
I
I
I
I
I
I
I
I
I
5-4.Brake disc and pad (Wear) – I I I I I I I I I
Page 227 of 288
Downloaded from www.Manualslib.com manuals search engine 7-4
INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
5-5.
Brake drum and shoes (Wear)
-
-
I
I
I
I
I
I
I
I
5-6.Master cylinder and wheel cylinder or caliper, brake hoses and pipes (Fluid
leakage, damage)IIIIIIIIII
5-7.
Master cylinder sub assembly, wheel cylinder boot kit & caliper seal set
I
I
I
I
I
R
I
I
I
R
WHEEL
6-1.
Tyres (air pressure, abnormal wear, crack and rotation)
I
I&O
I&O
I&O
I&O
I&O
I&O
I&O
I&O
I&O
6-2. Wheels (Damage) I I I IIIIIII
6-3.
Front/Rear wheel bearing (Loose, damage)
I
I
I
I
I
I
I
I
I
I
FRONT / REAR SUSPENSION
7-1.
Suspension strut (Oil leakage, damage)
I
I
I
I
I
I
I
I
I
I
7-2. Suspension arms / Knuckle support (Loose, damage) – I I I I I I I I I
7-3.
Rear spring (Damage)
I
I
I
I
I
I
I
I
I
I
7-4.Shock absorbers (Oil leakage, damage) I I I I IIIIII
7-5.
All bolts and nuts (Loose)
–
T
T
T
T
T
T
T
T
T
7-6.Torsion rods – I I I I I I I I I
STEERING
8-1.
Steering wheel (Play, loose)
I
I
I
I
I
I
I
I
I
I
8-2.Steering column and tie rods (Loose, damage, wear) I I I I I I I I I I
ELECTRICAL
9-1.
Battery electrolyte (Level, leakage)
I
I
I
I
I
I
I
I
I
I
9-2. Wiring harness connection (Loose, damage) – I I I I I I I I I
9-3.
Lighting system (Operation, stains, damage)
I
I
I
I
I
I
I
I
I
I
9-4.Horn (Operation) IIIIII I II I
9-5.
System Voltage
)
I
I
I
I
I
I
I
I
I
BODY
10-1.
All chassis bolts and nuts (Tighten)
–
I
T
T
T
T
T
T
T
T
10-2. All latches, hinges and locks (Function)) I I&L I&L I&L I&L I&L I&L I&L I&L I&L
Page 228 of 288
Downloaded from www.Manualslib.com manuals search engine 7-5INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
ROAD TEST11-1.
Operation of Brakes, gear shifting and speedometer
I
I
I
I
I
I
I
I
I
I
11-2.
Body and chassis noise
I
I
I
I
I
I
I
I
I
I
AIR CONDITIONER
12-1.
Check belt tension
I
I
I
I
I
I
I
I
I
I
12-2. Tighten compressor mounting bolt – T T T T T T T T T
12-3.
All hose joint (Check, tighten)
I
I
I
I
I
I
I
I
I
I
12-4.Check fun ctioning of R E C I R C U L A T I N G flap I I I I I I I I I I
12-5.
Clean condenser with low pressure water
–
C
C
C
C
C
C
C
C
C
12-6.Check belt for frayed edges I I I I I I I I I I
12-7.
Check all mounting bolts
I
I
I
I
I
I
I
I
I
I
12-8. Air conditioner filter element I I I I R I I R I I
Page 235 of 288
Downloaded from www.Manualslib.com manuals search engine
, 1 6 3 ( & 7 , 2 1 $ 1 ' 0 $ , 1 7 ( 1 $ 1 & (
0 6 (
V S H H G P D Q X D O W U D Q V D [ O H
71LS10701
7 R F K H F N W K H J H D U R L O O H Y H O X V H W K H I R O
O R Z L Q J S U R F H G X U H 1) Park the vehicle on a level surface with
the parking brake applied. Then, stop
the engine.
2) Remove the oil filler and level plug.
3) If gear oil flows from the plug hole, the oil
level is correct. Reinstall the plug. If gear
oil does not flow from the plug hole, add
oil through the filler plug hole until oil
flows a little from the plug hole. 7 L J K W H Q L Q J W R U T X H I R U R L O I L O O H U D Q G O H Y H O
S O X J
0 D Q X D O W U D Q V D [ O H R U
1 P N J P O E I W
* H D U 2 L O & K D Q J HSince special procedures, materials and
tools are required, it is recommended that
you trust this job to your D X W K R U L V H G 0 D U X W L
6 X ] X N L Z R U N V K R S.
& $ 8 7 , 2 1
$ I W H U G U L Y L Q J W K H Y H K L F O H W K H J H D U R L O
W H P S H U D W X U H P D \ E H K L J K H Q R X J K W R
E X U Q \ R X : D L W X Q W L O W K H R L O I L O O H U D Q G
O H Y H O S O X J L V F R R O H Q R X J K W R W R X F K
Z L W K \ R X U E D U H K D Q G V E H I R U H L Q V S H F W
L Q J J H D U R L O O H Y H O
(2)
( ; $ 0 3 / (
NOTICE
: K H Q W L J K W H Q L Q J W K H S O X J D S S O \ W K H
I R O O R Z L Q J V H D O L Q J F R P S R X Q G R U
H T X L Y D O H Q W W R W K H S O X J W K U H D G V W R S U H
Y H Q W R L O O H D N D J H
0 $ 5 8 7 , 6 8 = 8 . , % R Q G 1 R