2015 Lexus GS350 fuel cap

24
Evaporative Control System
•
Charcoal canister
• Diaphragm valve
• Fuel filler cap
• Fuel tank
• Vapor liquid separator
Exhaust Gas Recirculation
(EGR) System
•
EGR gas temperature sensor
• E G R v a l v e
• Associated parts
Ignition System
•
Distributor and internal parts
• Ignition coil and ignitor
• Ignition wires
• S p a r k p l u g s *
Positive Crankcase Ventilation
(PCV) System
•
Oil filler cap
• PCV valve or orifice
Other Parts Used in
Systems Listed
•
Data link connector (8/80)
• Hoses, clamps, fittings, tubing
and mounting hardware
• Malfunction indicator
light and bulb (8/80)
• Pulleys, belts and idlers
• Sealing gaskets and devices
• Sensors, solenoids,
switches and valves
Your Warranties in Detail
FEDERAL EMISSION CONTROL WARRANTY
WARRANTY
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
*Warranted until first required maintenance under terms of the California Emission Control Warranty.

51
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
36 Months or 30,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Engine coolant (see page 69)
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

55
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
72 Months or 60,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Replace spark plugs1
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Engine coolant (see page 69)
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
__ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires2
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Required under the terms of the Emission Control Warranty.
2Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

59
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
108 Months or 90,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Engine coolant (see page 69)
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
__ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

63
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
144 Months or 120,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Replace spark plugs1
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires2
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1Required under the terms of the Emission Control Warranty.
2 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

67
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
180 Months or 150,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace engine coolant (see page 69)
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

70
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
Engine Oil and Oil Filter
Replace the oil filter and drain and
refill the engine oil at specified intervals.
SAE 0W-20 oil is the best choice
for good fuel economy and good
starting in cold weather. If SAE 0W-20
is not available, SAE 5W-20 may be
used; however, it must be replaced
with SAE 0W-20 at the next oil
change. See your Lexus dealer for
oil specifically formulated for your
vehicle’s engine.
Your vehicle is equipped with a
replaceable oil-filter element and
oil-filter cap O-ring; replace both
at each oil change. For instructions
on how to reset the reminder light,
refer to your Owner’s Manual.
Note: If you do the majority of your
driving under any of the special
operating conditions indicated on
page 44, you should replace the
engine oil and oil filter every six
months or 5,000 miles, regardless
of the oil used or the certification
of the vehicle.
Exhaust Pipes and Mountings
Visually inspect the exhaust pipes,
muffler and hangers for cracks,
deterioration and damage. Start the
engine and listen carefully for any
exhaust leakage. Tighten connections
and replace parts as necessary.
Fuel Lines and Connections,
Fuel Tank Band and Fuel Tank
Vapor Vent System Hoses
Visually inspect for corrosion,
damage, cracks, and loose or leaking
connections. Tighten connections
and replace parts as necessary.
Fuel Tank Cap Gasket
Visually inspect for cracks,
deterio ration and damage
and replace if necessary.
Nuts and Bolts on Chassis
Check that tightness of the seat-
mounting bolts and front/rear
suspension-member retaining bolts
matches torque measurements
specified in the Repair Manual.
Rack-and-Pinion Assembly
Inspect the rack-and-pinion assembly
for signs of leakage, damage and
loose electrical connections. Tighten
connections and if you discover any
leakage or damage, have it repaired
immediately by a qualified technician.
Road Test
While driving the vehicle, check
for proper operation of engine,
transmission, brakes and steering.
Also check the parking brake, and
check for ab normal noise or vibration
from any part of the vehicle.

INDEX
Axle shaft boots ....................................................... 48–67,* 6 8
Ball joints and dust covers ............................................. 48–67,* 6 8
Body inspection ....................................................... 48–67,* 6 8
Body repairs......................................................................7
Brakes
Fluid...................................................................42, 68
Lines and hoses .................................................. 48–67,* 6 8
Pads, calipers and rotors ......................................... 48–67,* 6 8
Cabin air filter ......................................................... 48–67,* 69
Complimentary services
Maintenance services ..............................................4, 45–46
Other services ...........................................................5–6
Differential oil ......................................................... 48–67,* 69
Dispute resolution .........................................................9–13, 21
Drive belt.............................................................. 48–67,* 69
Driver’s floor mat...................................................... 48–67,* 69
Emergency repairs ......................................................... 37–38
Engine air filter ........................................................ 48–67,* 69
Engine coolant .................................................... 42, 48–67,* 69
Engine oil and oil filter ............................................. 42, 48–67,* 70
Exhaust pipes and mountings.......................................... 48–67,* 70
Fuel lines and connections, fuel tank band and
fuel tank vapor vent system hoses ..................................... 48–67,* 70
Fuel tank cap gasket................................................... 48–67,* 70
Inspections, general maintenance ..........................................42–43
*See scheduled maintenance log for maintenance interval.
73