2015 AUDI Q7 warning

260 Checking and filling
& WARNING
Stop! Before working in the engine com­
partment, always read and heed all WARN­
INGS
~ A in Working in the engine com­
partment on page
256 . The engine com­
pa rtment of any motor ve hicle is a poten­
tially d angerous area and can c ause ser i­
ous personal injury.
- The eng ine depends on o il to lubr icate
and cool a ll of its moving pa rts. The en­
gine o il m ust be che cked reg ularly and
k ept at the required leve l.
- Make it a habi t to have the eng ine oi l lev­
el checked every time you fill the fue l
tank .
- Too litt le engi ne oil may cause seve re e n­
gine damage.
Checking the engine oil level
The dipstick indicates the engine oil level .
Fig. 2 4 3 Illustrat ion of principle 1: Markers on oil dip ­
st ick
Fig. 2 44 Illustrat ion of p rinciple 2: Ma rkers on o il dip­
st ick
Before you chec k anythin g in the eng ine com­
partment,
a lw ays read and heed all WARN-
INGS ~.&. in Working in the engine compart­
ment on page
256.
Determin ing oil level
• Park yo ur vehicle so that it is horizontally
level.
• W hile at operat ing state tempe rature, brief­
ly let the engine run at idle and then s hut it
off .
.. Wait approx. two minutes .
.. Pull out the oil dipstick. Wipe off the oil dip­
stick w ith a clean cloth, and slide it back in
as far as it w ill go.
• Pull it back out and read off the o il level
~ fig. 243 o r ~ fig. 244. Top off the eng ine
oil, if applicable ~
page 261.
Oil level within range 0
• Do not add oil.
Oil le ve l within range@
• Yo u can add oil. Afterwards, the oil leve l
should be within range
G).
Oil level within range 0
• You must add oil. Afterwards , the oil leve l
should be wi thin range
G) .
The oil leve l needs to be checked at regular in­
te rva ls. The best times to do th is are whenev ­
er you refuel and prior to long trips .
Depend ing on the way the vehicle is dr iven
and the ope rat ing cond itions, oi l consumption
can be up to
1 quart pe r 1,200 miles (I liter
per
2,000 k m). Consumption m ay be higher
within the first
3,000 miles (5,000 km) .

M N
0 ..J
'SI: ,...., \!) ..,.,
,...., ..,., ,....,
Adding engine oil~
Fig. 2 45 Eng ine co mpa rtment : cove r on the e ngin e o il
filler neck
Before you c heck anything in the engine com­
partment,
a lw ays r ead and h eed all WARN ­
ING S
9 A in Working in the engine compart­
ment on page 256 .
"' Shut the engine off.
"' Unsc rew the cap~ to the engine oil fill ing
hole
9 fig . 245, 9page 258, fig. 242 .
"'Carefu lly top off with 0.5 q uarts (0.5 liters)
of the appropriate oi l
9page 258.
"'Check the oil leve l again after two minutes
9 page 260, Checking the engine oil level.
"' Top off the oil again, if necessary.
"' Screw the cap back on the filling hole and
slide the oil d ipst ick in as far as it will go .
A WARNING
Stop! Before working in the engine com­
pa rtment, always read and heed all WARN­
INGS
9 .&. in Working in the engine com ­
partment on page 256.
The engine com ­
partment of any motor vehicle is a poten­
tially dangerous area and can cause ser i­
ous personal injury.
A WARNING
Spilled o il is a fire hazard.
- The oil fille r cap must be properly se­
c u red to prevent oil from being sprayed
on the hot engine and exhaust system
when the eng ine is running.
- The oil leve l must not be above range ~
- danger of converter or eng ine damage!
Checkin g and fillin g 261
Contact an authorized deale rship to draw
off oil, if necessary .
-Audi doe s not re commend the u se of oil
additives. They m ay damage the engine
and ad ve rse ly affe ct you r New Vehicle
War ra nty.
@ For the sake of the environment
- Under no circumstances can the oil come
in contact with the sewage network or
the soi l.
- Observe and follow legal regulations
when disposing of empty oil containers .
· Changing the engine oil
Engine oil must be changed at intervals listed
in the Warranty
& Maintenance booklet.
T he eng ine oi l and oil fi lter m ust be changed
accord ing to the mileage and time intervals
specified in yo ur vehicle's Warranty
& Mainte­
nance booklet. Do not exceed these intervals -
harmful s ludge and deposits from old engine
o il can reduce engine performance and can
lead to expens ive engine repa irs .
Changing oi l at reg ular intervals is so very im­
portant because the lubricat ing properties of
o il decrease gradually during normal vehicle
use. If you are not sure when to have the oil
c h anged, ask your authorized Audi Serv ice Ad­
viso r.
Under some circumstances the engine oil
shou ld eve n be changed more often than
spec ified for normal use. Change o il more of­
ten if you often dr ive short d istances , operate
the ve hicl e in dusty a reas or mostly under
stop- and-go t raffic conditions, or when you
use your veh icle where temperatures stay be ­
l ow freezing point for long periods.
Dete rgent additives in the oil will make fres h
o il look dark after the engine has been ru n­
ning for a sho rt time. This is normal and is not
a reaso n to change the oil more often than
recommended.
ll>-
•
•

26 2 Ch eck ing and filling
8_ WARNING
Stop! Before working in the engine com­
partment, always read and heed all WARN ­
INGS
~ .&. in Working in the engine com­
partment on page
256 . The engine com­
partment of any motor veh icle is a poten­
tially dangerous area and can cause ser i­
ous personal injury.
8_ WARNING ,,,__
If you must change the engine oil in your
vehicle:
- Always wea r eye protection .
- T o reduce the ris k of burns from hot en-
gine oil let the engine cool down to the
touch.
- Whe n removing the oil drain plug with
yo ur fingers, stay as far away as poss ible.
Always keep your forearm paralle l to the
ground to he lp prevent hot oil from run­
ning down your arm.
- Drain the oi l into a container designed
for this pu rpose, one large enough to
hold at least the total amount of oil in
your engine.
- To reduce the risk of poisoning, never use
empty food or beverage containers that
might m islead someone into dr ink ing
from them.
- Engine oil is poisonous. Keep it well out
of the reach of children.
- Cont inuous contact with used engine oil
is harmful to your skin. Always protect
your sk in by washing thoroughly with
soap and water .
(D Note
Never mix oil additives with your engine
oil. These additives can damage your en­
gine and adverse ly affect your Audi Limit­
ed New Vehicle Warranty.
@i For the sake of the environment
- Before changing the oil, first make sure
you know where you can properly dispose of the old oil.
-
.
- Always dispose of used oil p roperly. Nev ­
er dump it on garden soil, in wooded
areas, into st reams or down sewage
dra ins.
- Recycle used oi l by taking it to a used en­
gine oil collection facility in your area, or
contact a service station.
- We strongly recommend that yo u have
your oil changed by an authorized Audi
dealer or a qualified workshop with the
special tools and expert ise required, and
proper means of disposal.
Engine cooling system
Coolant
The engine coolant performs two functions: it
keeps the engine from overheating and it pro­
tects the engine from freezing in the winter.
T he cooling sys tem is sealed and genera lly re­
quires little attention.
The cooling system has been fi lled at the fac­
tory with a permanent coolant which does not need to be changed. The coo lant cons ists of a
mixtu re of specially conditioned water and the
manufacturer's g lycol -basedcoo la nt add
i-
tive G l3 antifreeze with anticorrosion addi ­
tives (SO% for USA mode ls; 60% for Canadian
models). This mixture both assures the neces­
sary frost protection and protects metal com­
ponents in the eng ine's cooling system from
corros ion and scaling.
It also ra ises the bo il­
i ng po int of the coolant .
Do not reduce the concentration of the cool­
ant in the summer by adding p lain wate r. Th e
proportion of coo lant additiv e mu st be at
l e as t 50 °/4 but not m ore than 60°/4
to main­
ta in ant ifreeze protect io n and cooling eff ic ien­
c y.
If the coo lant fros t protection is too low,
the coolant could freeze and damage the vehi­
cle heating and engine cooling system.
For year- round driving, antifreeze is added at
t h e factory fo r temperatures down to:
- -31°F(-35°C)USA
- - 40 °F ( - 40 °C) Canada.

M
"' 0 ..J
"". rl I.O
"' rl
"' rl
If you must add coolant, use a mixture of wa­
ter and coolant additive. Mixing the coolant
addit ive with distilled water is recommended .
.&_ WARNING
Before you check anything in the engine
compartment, always read and heed all
WARNINGS
¢ .&. in Working in the engine
compartment on page 256 .
(D Note
-Before winter sets in, have the coolant
checked to see if the coolant additive in
your vehicle is suffic ient to meet the cli ­
mate cond itions . Th is is especially impor­
tant if you live in a region where the w in­
te r is extremely cold. If necessary, in­
crease the proport ion of coolant additive
to 60% .
- When adding coolan t addi tive to you r
cooling system , remember:
- We recommend using only coolant ad­ ditive G12 ++ or G13 for your vehicle.
This coo lant additive is available at au­
thorized Aud i dealers . Other types of
antifreeze can significantly reduce cor­
rosion protection . Th e resu lting co rro­
sion c an cause a loss of coo la nt and se­
r ious engine damage.
- Do not add a ny type of radiator leak sea l­
ant to your veh icle's engine coo lant.
Adding rad iator repair fluid may adverse ­
l y affect the function and performance of
your cooling system and could result in damage not covered by your New Vehicle Limited Warranty.
-
Checkin g and fillin g 263
Checking the engine coolant level
The engine coolant level can be checked with
a quick glance .
F ig . 2 4 6 En gin e compar tmen t: Coolant expan sio n ta nk
Befo re you check anyth ing in the eng ine com ­
partment,
alw ays r ead and he ed all WARN­
INGS ¢ A in Working in the engine comport­
ment on page 256 .
.,.. Park your vehicle on a level su rface.
.,.. Tu rn
off t he ignition .
.,.. Let the engine cool down.
.,.. Plac e a thick rag over the coolant expans ion
tank ¢
fig. 246, ¢ page 258, fig. 242 and
carefull y twist the cap counter-clockwise
¢_&. .
.,.. Read the engine coolant level in the open
coo lant expansion tank. W it h a co ld eng ine,
the coolant leve l should be between the
"min " and "max" markings. W hen the en­
gi ne is wa rm, the level may be slightly above
t he "max" marking.
T he location of the coo lant expansion tank
can be seen in the engi ne compa rtment illus­
trat ion
¢ page 258 .
To obtain an accu rate reading, the engine
must be switched off.
The expansion ta nk in your vehicle i s equ ipped
with an electric coolant level sensor .
When the coolant leve l is too low, the warning
light i n the Auto-Check System¢
page 32 will
blink unti l you add coolant and the level has
been restored to normal. Even though there is
an electric coo lant level senso r, we still rec­
ommend you check the coolant level from
t ime to t ime .

264 Check ing and filling
Coolant lo ss
Coolant loss may indicate a l ea k in t he cooling
system. In the event of coolant loss, the cool ­
ing system should be inspected immediately
by your authorized Audi dealer. It is not
enough merely to add coolant.
I n a
se ale d system, losses can occur only if
the boiling point of the coolant is exceeded as
a result of overheating.
A WARNING
The cooling system is under pressure and
can get very hot. Reduce the risk of scald­
ing from hot coolant by following these
steps.
- Turn off the engine and allow it to cool
down.
- Protect your face, hands and arms from
escaping fluid and steam by covering the
cap with a large, thick rag .
- Turn the cap slowly and very carefully in
a counter-clockwise direction wh ile ap­
plying light, downward pressure on the
top of the cap .
- To avoid being burned, do not spill ant i­
freeze or coolant on the exhaust system
or hot eng ine parts. Under certain condi­
t io ns, the ethy lene g lycol in engine cool­
an t ca n ca tch f ire.
0 Note
Do not add any type of radiator leak seal­
ant to your vehicle's eng ine coolant. Add­
ing radiato r repair fluid may adve rsely af­
fect the function and performance of your
cooling system and could res ult in damage
not covered by your New Vehicle Limited
Warranty .
Adding coolant
Be very careful when adding engine coolant.
Before you check anything i n the engine com­
pa rtmen t,
a lwa ys read and heed all WARN ­
INGS c:::> A in Working in the engine compart ­
ment on page 256.
.. Tu rn off the engine .
.. Let the engine cool down.
.. Place a thick rag over the coo lant expansion
tank
c> page 263 , fig. 246 and carefully
twist the cap counter-clockwise c> ,&. .
.. Add coo lant m ixed in the correct rat io
c:::> page 262, Coolant.
.. Twist the cap o n again tightly.
Rep lacement engine coo lant must conform to
exact spec ificat ions
c> page 262, Coolant.
We recommend using only coo lant add it ive
G12 ++, G13 or in an emergency G12 +. Do
not
use a different add itive. In an emergency use
plain water until you can get the correct addi­
t ive and can restore the correct ratio . This
shou ld be done as soon as poss ib le.
If you have lost a considerab le amount of
coolant, the n you should add cold ant ifreeze
and co ld water on ly when the eng ine is cold .
Always use
new engine coolant when refilling.
Do not fi ll coo lant above the "MAX" mark. Ex­
cess coolant will be forced o ut through the
pressure relief valve in the cap when the en­
gine becomes hot.
A WARNING
- The cooling system is under pressure and
can get very hot. Reduce the risk of
scalding from hot coolant by following
these steps.
- Turn off the engine and allow it to coo l
down.
- Protect your face, hands and arms from
escaping fluid and steam by covering
the cap with a large, th ick rag.
- Turn the cap s low ly and very carefully
in a counter-clockwise direction while
applying light, downward pressure on
the top of the cap.
- To avoid being burned, do not spill an­
tifreeze or coolant on the exhaust sys­
tem or hot engi ne parts. Under certain
cond it ions, the ethylene g lycol in e n­
gine coolant can catch fire .

M
"' 0 ..J
"". rl I.O
"' rl
"' rl
-Antifreeze is poisonous . Always store an­
t ifreeze in its or iginal container and well
out of the reach of children.
- If you drain the coolant, it must be
caught and safely stored in a proper con­
tainer clearly marked "poison".
(D Note
- Coolant pollutes the environment and
could cause an engine fire. Excess coo l­
ant will be forced out through the pres­
sure re lief va lve in the cap when the en­
gine becomes hot.
- If, in an emergency, only water can be
added, the correct ratio between water
and antifreeze ¢
page 262 must be re­
stored as soon as possib le.
@ For the sake of the environment
Drained coolant should not be reused. Al­
ways dispose of used coolant while observ­ ing all environmental regulations .
Radiator fan
The radiator fan switches on automatically by
itself
The radiator fan is driven by the engine via the
V-belt . The viscous clutch regulates the speed
of the fan accord ing to the temperature of the
coolant .
An auxiliary electric radiator fan* switches on
and off depending on coolant temperature
and other vehicle operating conditions .
After you switch the engine off, the auxilia ry
fan can continue running for up to 10 minutes
- even with the ignition off. It can even switch
on again later by itself¢& , if
- the temperature of the engine coolant rises due to the heat build-up from the engine in
the engine compartment, or
- the engine compartment hea ts up because
the vehicle is parked in intense sunlight .
Checking and fillin g 265
A WARNING
-To reduce the risk of personal injury nev­
er touch the rad iator fan.
- The auxiliary electric fan is temperature
controlled and can switch on suddenly
even when the engine is not running .
- The auxiliary radiator fan switches on au­
tomatically when the engine coolant reaches a certain temperature and will
continue to run until the coo lant temper­
ature drops.
Brake fluid
Checking brake fluid level
The brak e fluid lev el can be check ed with a
quick glance.
N
N
-N ,.
:8
Fi g. 247 En gin e compa rtm en t: cover o n the bra ke fluid
reservoir
Before you check anything in the eng ine com­
partment ,
always read and heed all WARN­
INGS ¢ A in Working in the engine compart­
ment on page 256.
.,. Read the brake fluid level from the brake
fluid reservoir ¢
fig. 247, ¢ page 258,
fig. 242.
The brake fluid level must be be­
tween the "MIN" and "MAX" markings .
The brake fluid reservoir is located at the rear
partition of the eng ine compartment on the
left side ¢
page 258.
The fluid level may drop slightly after some
time due to t he automatic adjustment of the
brake pads. This is not cause for alarm. ..,_

26 6 Ch eck ing and filling
If the brake fluid level falls considerably be­
low the "MIN" mark, the brake warning/indi­
cator light (U .S . mode ls:
11111 , Canadian
models: .) will come on
<=> page 19 and
<=> page 32. Do not continue to operate the ve­
h icle . The complete brake system should be
thoroughly checked by an authorized Aud i
dea ler or qualified workshop and the cause
corrected. If the brake fluid level is too low,
the brake warning/indicator light will illum i­
nate . Contact an authorized Aud i dealer
im­
m ediatel y.
@ Tips
The brake fluid rese rvoir is located unde r­
neath the cove r.
Changing brake fluid
Hove the broke fluid changed by on experi­
enced technician.
Brake fluid absorbs moisture from the a ir . If
the water content in the brake fluid is too
h igh , corrosion in the brake system may result
after a per iod of t ime. The bo iling po int of the
brake fluid wi ll also decrease considerably and
decrease braking performance.
Therefore, the brake flu id must be changed
e ver y tw o year s. Always use new b rake fluid
which conforms to Federal Motor Vehicle
Standard "FMVSS 1 16 DO T 4".
The brake flu id reservo ir can be difficult to
reach, therefore, we recommend that you
have the brake f luid changed by you r author­
ized
Audi dea ler. Your dea ler has the correct
too ls, the right brake fluid and the know -how
to do this for you.
A WARNING
- Brake fluid is poisonous . It must be stor­
ed only i n the closed orig inal container
o ut of the reach of children!
- Brake fa ilure can result from old or inap­
propriate b rake fluid. Observe these pre­
caut ions: -
Use only brake fluid that meets SAE
specification
J 1703 and conforms to
Federa l Motor Vehicle Standard 116.
Always check with your authorized Audi
dealer to make sure you are using the
correct brake fluid . The correct type of
brake f lu id is also ind icated on the
brake flu id reservoir.
- T he brake fluid must be new. Heavy use
of the bra kes ca n cause a vapo r lock if
the b rake fluid is left in the system too
l ong . This can seriously affect the effi ­
c iency of the brakes as well as your
safety. This co uld resu lt in an accident.
(D Note
Bra ke fluid will damage the paint of you r
vehicle .
(® For the sake of the environment
Because of the p rob lem of p roper disposal
of b ra ke fluid as well as the spec ial too ls
r equired and the necessary expertise, we
re commend that yo u have the brake fluid
changed by yo ur authorized Aud i dea ler.
Battery
General information
U nder normal ope rat ing cond itions , the bat­
tery in yo ur Audi does not need any ma inte­
nance. With
high o utside tempe ra tur es or
l ong dai ly drives we recommend that you have
the e lectrolyte level checked by an authorized
Audi dealer or qualif ied workshop. The elec­
trolyte level should also be checked each time
the battery is charged
<=> page 268.
Have the battery checked when yo u take your
vehicle in for service. You are well advised to replace a battery that is o lder than 5 years .
With certain types of airbag deployment, the battery is disconnected from the veh icle elec­
trical system for safety reasons<=>.&
in Re ­
pair , core and disposal of the airbags on
page 196.
~

M N
0 ...J
'SI: ,...., \!) ..,.,
,...., ..,., ,....,
Disconne cting the batt ery t erminals
Some vehicle functions (power w indow regu ­
l ators, for example) are lost if the battery ter­
minals are disconnected . These functions have
to be re learned after the battery terminals are
connected again. To prevent this, the battery
should only be disconnected from the vehicle
electrical system when absolutely necessary
for repairs .
Vehicle s not driven fo r lo ng period s
If you do not drive your vehicle over a period
of several days or weeks, electrical compo­
nents are gradually cut back or switched off .
This reduces energy consumption and main­
tains starting capab ility over a longer per iod
¢ page 228 .
Take into consideration that when you unlock
your vehicle, some convenience functions,
such as the inter ior lights or the power seat
adjustment, may not be available . The con­
ve nience funct ions w ill be available again
when yo u turn on the ignition and start the
engine.
Winter op eration
During the winter months, battery capacity
tends to decrease as tempe ratures d rop . This
i s because more powe r is also consumed while
start ing, and the headl ights, rea r window de ­
fogger, etc., are used more often.
Avo id unnecessary power consumption, par­
ticularly in c ity t raffic or when t rave ling on ly
short d istances. Let you r autho rized Aud i
dealer check the capacity of the vehicle bat­
tery before winter sets in ¢
page 268. A well
charged battery wi ll not only prevent starting
prob lems when the weather is cold, but will
also last longer .
If your vehicle is left standing for severa l
weeks at extremely low temperat ures, the
veh icle battery should be removed and
stored where it will not freeze. This will
prevent it from bei ng damaged and hav ing
to be replaced.
Checkin g and fillin g 267
Working on the battery
Be especially careful when working on or near
the battery.
The battery is located under the driver 's seat.
Before you check anyth ing under the dr iver's
seat,
read and h eed all WARNINGS G &_ .
Always heed the safety warnings , when work­
ing on the vehicle battery or the vehicle e lec­
trical system to prevent injury .
The following WARNINGS are ver y
important when working on the batter y:
Alway s heed the following WARN IN G SY M-
BOLS a nd safety p re caution s when working
on the battery .
®
Alway s wear e ye prote ction.
~
Batt ery acid contain s sulfuric acid. Al -
w ay s we ar gloves and eye prot ection.
@
No
-spa rk s
- flam es
- smoking .
~
When a b atter y is ch arged , it produces
h y drogen g as w hic h is e xplosi ve and
could cause pe rsonal injur y.
®
Alw ays keep the batt ery well out of
r e a ch of childr en.
A WARNING
Whenever working on the battery or on
the electrical system, there is the risk of
injury, accident and even fire. Read and
heed the following WARNINGS:
- Always wear eye protection. Do not let
battery ac id or any lead particles get on
your skin or clothing. Shield your eyes.
Exp losive gases can cause blindness or
other inju ry.
- Battery acid conta ins sulfuric acid. Sulfu­
ric acid can cause blindness and severe
bu rns.
- Always wear g loves and eye protection.
Do not tilt the battery because acid
~
•
•