2014 TOYOTA HIGHLANDER HYBRID belt

JOBNAME:1491132-2014-hhvWG-E PAGE:13SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
WHAT ISCOVERED AND
HOW LONG
Basic Warranty
Thiswarranty coversrepairs and
adjustments neededtocorrect defects in
materials orworkmanship ofany part
supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 36months or
36,000 miles,whichever occursfirst,with
the exception ofwheel alignment and
wheel balancing, whicharecovered for
12 months or12,000 miles,whichever
occurs first.
Hybrid System Warranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofthe components listed
here andsupplied byToyota, subjectto
the exceptions indicatedunder“What Is
Not Covered” onpages 14-15.
•Battery controlmodule (battery
voltage sensor)
• Hybrid battery
• Hybrid control module (power
management controlmodule)
• Inverter withconverter
Coverage isfor 96months or
100,000 miles,whichever occursfirst.
Powertrain Warranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofany component listed
below andinthe next column and
supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 60months or
60,000 miles,whichever occursfirst.
Engine
Cylinder blockandhead andallinternal
parts, timing gearsandgaskets, timing
chain/belt andcover, valvecovers, oilpan,
oil pump, engine mounts, enginecontrol
computer, waterpump, fuelpump, seals
and gaskets.
Transaxle/Motor/Generator
Case andallinternal parts,transaxle
mounts, sealsandgaskets.
Front-Wheel-Drive System
Final drive housing andallinternal parts,
axle shafts, driveshafts, constant velocity
joints, fronthubandbearings, sealsand
gaskets.
New Vehicle Limited Warranty
WARRANTY
YourWarranties inDetail13

JOBNAME:1491132-2014-hhvWG-E PAGE:14SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
Restraint SystemsWarranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofany seatbelt orair bag
system supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 60months or
60,000 miles,whichever occursfirst.
For vehicles soldandregistered inthe
state ofKansas, thewarranty forseatbelts
and related components is10 years,
regardless ofmileage.
Corrosion Perforation Warranty
Thiswarranty coversrepairorreplacement
of any original bodypanel thatdevelops
perforation fromcorrosion (rust-through),
subject tothe exceptions indicatedunder
“What IsNot Covered” onpages 14-15.
Coverage isfor 60months, regardless of
mileage.
For information onhow toprotect your
vehicle fromcorrosion, seethesection
entitled “Corrosion Preventionand
Appearance Care”inthe
Owner’s Manual.
Towing
Whenyourvehicle isinoperable dueto
failure ofawarranted part,towing service
to the nearest authorized Toyotadealership
is covered.
WHAT ISNOT COVERED
Thiswarranty doesnotcover damage or
failures resulting directlyorindirectly from
any ofthe following:
•Fire, accidents ortheft
• Abuse ornegligence
• Misuse —for example, racingor
overloading
• Improper repairs
• Alteration ortampering, including
installation ofnon-Genuine Toyota
Accessories
• Lack ofor improper maintenance,
including useoffluids otherthan
those specified inthe
Owner’s Manual
•Installation ofnon-Genuine Toyota
Parts
• Airborne chemicals, treesap, road
debris (including stonechips), rail
dust, salt,hail,floods, windstorms,
lightning andother environmental
conditions
• Water contamination
Thiswarranty alsodoes notcover the
following:
Tires
Tires arecovered byaseparate warranty
provided bythe tire manufacturer. See
page 29.
Normal WearandTear
Noise, vibration, cosmeticconditions and
other deterioration causedbynormal wear
and tear.
New Vehicle Limited Warranty
WARRANTY
14YourWarranties inDetail

JOBNAME:1491132-2014-hhvWG-E PAGE:19SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
Hybrid System
•Battery controlmodule (battery
voltage sensor) (8/80)*
• Battery thermistor
• Electric vehiclejunction box
• Generator
• Hybrid battery*
• Hybrid control module (power
management controlmodule) (8/80)*
• Inverter withconverter*
• Motor
• System mainrelayandbattery current
sensor
Ignition System
•Distributor andinternal parts
• Ignition coiland ignitor
• Ignition wires
• Spark plugs†
Positive Crankcase Ventilation
(PCV) System
•Oil filler cap
• PCV valve ororifice
Other PartsUsedinAbove
Systems
• Data linkconnector (8/80)
• Hoses, clamps, fittings,tubingand
mounting hardware
• Malfunction indicatorlightandbulb
(8/80)
• Pulleys, beltsandidlers
• Sealing gaskets anddevices
• Sensors, solenoids, switchesand
valves
* Covered undertheHybrid System Warranty foreight years or100,000 miles,whichever occursfirst.
† Warranted untilfirstrequired maintenance undertermsofthe California EmissionControlWarranty.
8/80 =Covered foreight years or80,000 miles,whichever occursfirst.
Federal Emission ControlWarranty
WARRANTY
YourWarranties inDetail19

JOBNAME:1491132-2014-hhvWG-E PAGE:23SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
Vehicles equipped withaCalifornia
Certified Emission ControlSystem that
are sold, registered andoperated in
California orany state thatadopts
California emissionwarrantyprovisions
are covered bythis warranty. Currently,
Connecticut, Delaware,Maine,
Maryland, Massachusetts, NewJersey,
Oregon, Pennsylvania, RhodeIsland,
Vermont andWashington arethe other
states towhich thiswarranty applies.
Vehicles coveredbythis warranty are
also covered bythe Federal Emission
Control Warranty (seepage 17).
YOUR WARRANTY RIGHTS
AND OBLIGATIONS
TheCalifornia AirResources Board(CARB)
and Toyota arepleased toexplain the
emission controlsystem warranty foryour
2014 vehicle. InCalifornia, newmotor
vehicles mustbedesigned, builtand
equipped tomeet thestate’s stringent
anti-smog standards. CARBregulations
require thatToyota mustwarrant the
emission controlsystem onyour vehicle
for the time periods indicated onthe next
page, provided therehasbeen noabuse,
neglect orimproper maintenance ofyour
vehicle.
Your emission controlsystem mayinclude
parts suchasthe fuel injection system,
ignition system, catalytic converter and
engine computer. Alsoincluded maybe
hoses, belts,connectors andother
emissions-related assemblies.
Where awarrantable conditionexists,
Toyota willrepair yourvehicle atno cost
to you, including diagnosis, partsand
labor.
California EmissionControlWarranty
WARRANTY
YourWarranties inDetail23

JOBNAME:1491132-2014-hhvWG-E PAGE:45SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
60,000 milesor72 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Replace cabinairfilter Replace engineairfilter Replace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive belts4
__Drive shaftboots
__ Engine/Inverter coolant5
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Rear differential oil
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads: Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading6: Replace automatic transmission fluid Replacefrontdifferential oil Replacereardifferential oil Tightennutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Initial inspection at60,000 miles/72 months.Inspectevery15,000 miles/18 monthsthereafter.5Referto“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
6Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog45

JOBNAME:1491132-2014-hhvWG-E PAGE:47SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
75,000 milesor90 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Rotate tires Visually inspectbrakelinings/drums andbrake pads/discs
Note: If0W-20 oilWAS NOTused atthe last oilchange, replaceengineoiland oilfilter.1
Inspect thefollowing:
__Ball joints anddust covers
__ Brake linesandhoses
__ Drive belts
__ Drive shaftboots
__ Engine/Inverter coolant
3
__Exhaust pipesandmountings
__ Radiator, condenser and/orintercooler
__ Steering gearbox
__ Steering linkageandboots
Note: Driving inheavy traffic, ondirt roads orinurban, dustyordesert areasmay
shorten thelifeofthe cabin airfilter. Replacement maybeneeded ifyou notice reduced
air flow from theairconditioner andheater orifthe windows fogeasily whenyouuse
the Fresh mode.Consult yourdealer ifany ofthese conditions occur.
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Inspect engineairfilterReplace engineoiland oilfilter1
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading4:Replace engineoiland oilfilter1
Tighten nutsandbolts onchassis andbody
Repeated tripsofless than fivemiles intemperatures below32°F/0°C:Replace engineoiland oilfilter1
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceengineoiland oilfilter1
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Referto“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
4Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog47

JOBNAME:1491132-2014-hhvWG-E PAGE:49SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
90,000 milesor108 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Replace cabinairfilter Replace engineairfilter Replace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive belts
__ Drive shaftboots
__ Engine/Inverter coolant
4
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Rear differential oil
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads: Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading5: Tightennutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
5Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog49

JOBNAME:1491132-2014-hhvWG-E PAGE:51SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
105,000 milesor126 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Rotate tires Visually inspectbrakelinings/drums andbrake pads/discs
Note: If0W-20 oilWAS NOTused atthe last oilchange, replaceengineoiland oilfilter.1
Inspect thefollowing:
__Ball joints anddust covers
__ Brake linesandhoses
__ Drive belts
__ Drive shaftboots
__ Engine/Inverter coolant
4
__Exhaust pipesandmountings
__ Radiator, condenser and/orintercooler
__ Steering gearbox
__ Steering linkageandboots
Note: Driving inheavy traffic, ondirt roads orinurban, dustyordesert areasmay
shorten thelifeofthe cabin airfilter. Replacement maybeneeded ifyou notice reduced
air flow from theairconditioner andheater orifthe windows fogeasily whenyouuse
the Fresh mode.Consult yourdealer ifany ofthese conditions occur.
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Inspect engineairfilterReplace engineoiland oilfilter1
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading5:Replace engineoiland oilfilter1
Tighten nutsandbolts onchassis andbody
Repeated tripsofless than fivemiles intemperatures below32°F/0°C:Replace engineoiland oilfilter1
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceengineoiland oilfilter1
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Initialreplacement forengine coolant isat 100,000 miles/120 monthsandforinverter coolantinitialreplacement is
at 150,000 miles/230 months.Replaceevery50,000 miles/60 monthsthereafter. Referto“Engine/Inverter Coolant”
in the “Explantion ofMaintenance Items”section inthe back ofthis guide formore information.
4Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
5Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog51