2014.5 Citroen C4 PICASSO RHD check engine

307
The various caps and covers allow access for checking   the   levels   of   the   various   fluids,   for  
r

eplacing   certain   components   and   for   priming  
t

he   fuel   system.
Diesel engines
1. Screenwash   and   headlamp   wash   reservoir.
2. C oolant r eservoir.
3.
 B

rake   fluid   reservoir.
4.
 B

attery   /   Fuses.
5.
 F

usebox.
6.
 A

ir   filter.
7.
 E

ngine   oil   dipstick.
8.
 E

ngine   oil   filler   cap.
9.
 P

riming
 pu
mp*.
*
  According   to   engine.
8
Checks

308
Fuel
Capacity of the tank: approximately 57 litres (petrol) or 55 litres (Diesel).
Low fuel levelRefuelling
When the low fuel level is reached, t
his   warning   lamp   in   the   instrument  
p

anel   comes   on,   accompanied   by   an  
a

udible   warning,   a   message   and   the  
l

ast   bar   of   the   fuel   gauge   comes   on  
i

n   orange.
F
 
T
ake   care   to   select   the   pump   that   delivers  
t

he   correct   type   of   fuel   for   your   vehicle.
F
 
I
ntroduce   the   nozzle   so   as   to   push   in   the  
m

etal   non-return   flap   A.
F
 
M
ake   sure   that   the   nozzle   is   pushed   in   as  
f

ar   as   possible   before   starting   to   refuel   (risk  
o

f   blowback).
F
 
M
aintain   this   position   throughout   the  
r

efuelling
 ope
ration.
F
 
P
ush   the   fuel   flap   to   close   it.
If you are filling your tank to the top, do
not persist after the 3rd cut- off; this could
cause malfunctions.
A
  label   on   the   inside   of   the   fuel   filler   flap  
r

eminds   you   of   the   type   of   fuel   to   use,  
d

epending   on   your   engine   type.
Additions
  of   fuel   must   be   of   at   least   5   litres   to  
b

e   registered   by   the   fuel   gauge.
When
 
it
 
first   comes   on,   about 6 litres of fuel
remain
 
in
 
the   tank.
Until
 
sufficient   fuel   has   been   added,   this   warning
 l

amp
 
appears   every   time   the   ignition   is   switched
 o

n,
 
accompanied   by   an   audible   warning   and   a
 m

essage.
  This   audible   warning   and   message
 a

re
 
repeated   with   increasing   frequency   as   the
 f

uel
 
level
 
drops   towards   "0 ".
Refuel
 
as
 
soon   as   possible   to   avoid   running   out.Opening
  the   filler   flap   may   result   in   an   inrush   of  
a

ir.   This   is   entirely   normal   and   results   from   the  
s

ealing   of   the   fuel   system.
F
 
P
ress   the   rear   edge   of   the   flap   to   open   it  
(

the   filler   cap   is   part   of   it).
With Stop & Start, never refuel with the
system
  in   STOP   mode;   you   must   switch  
o

ff
 
the   ignition   with   the   START/STOP  
b

utton.
Checks

309
The petrol or Diesel engine of your vehicle is fitted   with   a   catalytic   converter,   a   device   which  
h

elps   to   reduce   the   level   of   harmful   emissions  
i

n   the   exhaust   gases.
For petrol engines, you must use unleaded
fuel.
The
  filler   neck   is   narrower,   allowing   only  
u

nleaded   petrol   nozzles   to   be   introduced.
If you have put in the wrong fuel
for your vehicle, you must have the
fuel tank drained and filled with
the correct fuel before star ting
the


engine.
Fuel cut- of f
Your vehicle is equipped with a safety device which cuts off the fuel supply in the event of
a collision.
8
Checks

310
Misfuel prevention (diesel)*
Operation
When a petrol filler nozzle is introduced into the f
uel   filler   neck   of   your   Diesel   vehicle,   it   comes  
i

nto   contact   with   the   flap.   The   system   remains  
c

losed   and   prevents   filling.
Do not persist but introduce a Diesel type
filler nozzle.
*
  Depending   on   country   of   sale.
Mechanical
  device   which   prevents   filling   the   tank   of   a   Diesel   vehicle   with   petrol.   It   avoids   the   risk   of   engine   damage   that   can   result   from   filling   with   the  
w

rong   fuel.
It   remains   possible   to   use   a   fuel   can   to  f
ill   the   tank.
In   order   to   ensure   a   good   flow   of   fuel,  
d

o   not   place   the   nozzle   of   the   fuel   can  
i

n   direct   contact   with   the   flap   of   the  
m

isfuel   prevention   device   and   pour  
s

l ow l y.Travelling abroad
As Diesel fuel pump nozzles may be   different   in   other   countries,   the  
p

resence   of   the   misfuel   prevention  
d

evice   may   make   refuelling   impossible.
Before
  travelling   abroad,   we  
r

ecommend   that   you   check   with   the  
C

ITROËN   dealer   network,   whether   your  
v

ehicle   is   suitable   for   the   fuel   pumps   in  
t

he   country   in   which   you   want   to   travel.
Checks

311
Fuel used for petrol engines
The petrol engines are compatible with E10   bio-petrol   (containing   10   %   ethanol),  
c

onforming   to   European   standards   EN   228   and  
E

N
 1
5376.
E85
  type   fuels   (containing   up   to   85   %   ethanol)  
a

re   reserved   exclusively   for   vehicles   marketed  
f

or   the   use   of   this   type   of   fuel   (BioFlex  
v

ehicles).   The   quality   of   the   ethanol   must  
c

omply   with   European   standard   EN   15293.
Fuel used for Diesel
engines
The Diesel engines are compatible with biofuels   which   conform   to   current   and   future  
E

uropean   standards   (Diesel   fuel   which  
c

omplies   with   standard   EN   590   mixed   with  
a

  biofuel   which   complies   with   standard  
E

N 14214)   available   at   the   pumps   (containing  
u

p   to   7   %   Fatty   Acid   Methyl   Ester).
B30
  biofuel   can   be   used   in   certain   Diesel  
e

ngines.   However,   this   use,   even   occasional,  
r

equires strict application of the special
servicing
  conditions.   Contact   a   CITROËN  
d

ealer   or   a   qualified   workshop.
The use of any other type of (bio)fuel
(vegetable
  or   animal   oils,   pure   or   diluted,  
d

omestic   fuel...)   is   strictly   prohibited   (risk   of  
d

amage   to   the   engine   and   fuel   system).
8
Checks

312
Running out of fuel (Diesel)
On vehicles fitted with HDi engines, the fuel system   must   be   primed   if   you   run   out   of   fuel;  
r

efer   to   the   corresponding   engine   compartment  
v

iew.
1.6 HDi engine
F Fill   the   fuel   tank   with   at   least   five   litres   of  d
iesel.
F
 
O
pen   the   bonnet.
F
 
I
f   necessary,   unclip   the   styling   cover   for  
a

ccess   to   the   priming   pump.
F
 
S
queeze   and   release   the   priming   pump  
r

epeatedly   until   resistance   is   felt   (there  
m

ay   be   resistance   at   the   first   press).
F
 
O
perate   the   starter   until   the   engine   starts  
(

if   the   engine   does   not   start   at   the   first  
a

ttempt,   wait   around   15   seconds   before  
t

rying
 ag
ain).
F
 
I
f   the   engine   does   not   start   after   a   few  
a

ttempts,   operate   the   priming   pump   again  
t

hen   start   the   engine.
F
 
R
efit   the   styling   cover   and   clip   it   in   place.
F
 
C
lose   the   bonnet.
If
 
the
 
tank
 
on
 
your
 
vehicle
 
is
 
fitted
 
with
 
a

 
misfuel
 
prevention
 
device,
 
refer
 
to
 
the
 
"

Misfuel
 
prevention
 
(Diesel)"
 
section.
If
 
the
 
engine
 
does
 
not
 
start
 
first
 
time,
 
d

on't
 
keep
 
trying
 
but
 
start
 
the
 
procedure
 
a

gain
 
from
 
the
 
beginning.
1.6 BlueHDi engine
F Fill   the   fuel   tank   with   at   least   five   litres   of  D
iesel.
F
 
S
witch   on   the   ignition   (without   starting   the  
e

ngine).
F
 
W
ait   around   6   seconds   and   switch   off   the  
ig

nition.
F
 
R
epeat   the   operation   10   times.
F
 
O
perate   the   starter   to   run   the   engine.
Checks

313
Checking levels
Take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns) and the cooling fan could start at any   time   (even   with   the   ignition   off).
Engine oil level
The check is carried out either when the   ignition   is   switched   on   using   the  
o

il   level   indicator   in   the   instrument  
p

anel for vehicles with an electric oil
level
  gauge,   or   using   the   dipstick.Checking using the dipstick
Refer to the "Petrol engine" or "Diesel engine" section   for   the   location   of   the   dipstick   in   the  
e

ngine   compartment   of   your   vehicle.
F
 
T
ake   the   dipstick   by   its   coloured   grip   and  
r

emove   it   completely.
F
 
W
ipe   the   end   of   the   dipstick   using   a   clean  
n

on-fluffy   cloth.
F
 
R
efit   the   dipstick   and   push   fully   down,   then  
p

ull   it   out   again   to   make   the   visual   check:  
t

he   correct   level   is   between   the   marks   A
and
  B.
It
 
is
 
normal
 
to
 
top
 
up
 
the
 
oil
 
level
 
between
 
t

wo
 
services
 
(or
 
oil
 
changes).
 
CITROËN
 
r

ecommends
 
that
 
you
 
check
 
the
 
level,
 
and
 
top
 
u

p
 
if
 
necessary,
 
every
 
3
 
000
 
miles
 
(5
 
000
 
kms).
Check
 
all
 
of
 
these
 
levels
 
regularly,
 
in
 
line
 
with
 
the
 
manufacturer's   service   schedule.   Top   them   up   if   necessary,   unless   other wise   indicated.
If
 
a
 
level
 
drops
 
significantly,
 
have
 
the
 
corresponding   system   checked   by   a   CITROËN   dealer   or   a   qualified   workshop.
To
 
ensure
 
that
 
the
 
reading
 
is
 
correct,
 
y

our
 
vehicle
 
must
 
be
 
parked
 
on
 
a
 
level
 
s

ur face
 
with
 
the
 
engine
 
having
 
been
 
off
 
f

or
 
more
 
than
 
30
 
minutes. A = M
aX
B

= MI
n
I

f   you   find   that   the   level   is   above   the   A   mark   or  
belo

w the B   mark,   do not star t the engine.
-
 
I
f   the   level   is   above   the   MAX
 
mark   (risk  
o

f   damage   to   the   engine),   contact   a  
C

ITROËN   dealer   or   a   qualified   workshop.
-
 
I
f   the   level   is   below   the   MIN
 
mark,   you  
m

ust   top   up   the   engine   oil.
8
Checks

314
Topping up the engine oil level
Refer to the "Petrol engine" or "Diesel engine" section for the location of the oil filler cap in the
engine
  compartment   of   your   vehicle.
F

U
nscrew the oil filler cap to reveal the filler
aperture.
F
 
A
dd   oil   in   small   quantities,   avoiding   any  
s

pills   on   engine   components   (risk   of   fire).
F
 
W
ait   a   few   minutes   before   checking   the  
l

evel   again   using   the   dipstick.
F
 
A
dd   more   oil   if   necessary.
F
 
A
fter   checking   the   level,   carefully   refit   the  
o

il   filler   cap   and   the   dipstick   in   its   tube.
Engine oil change
Refer to the manufacturer's service schedule for   details   of   the   interval   for   this   operation.
In
  order   to   maintain   the   reliability   of   the   engine  
a

nd   emission   control   system,   never   use  
a

dditives   in   the   engine   oil.
After
  topping   up   the   oil,   the   check   when  
s

witching   on   the   ignition   with   the   oil  
l

evel   indicator   in   the   instrument   panel  
i

s   not   valid   during   the   30   minutes   after  
t

opping   up.
Oil grade
Before topping-up the oil or changing the oil, c
heck   that   the   oil   is   the   correct   grade   for   your  
e

ngine   and   conforms   to   the   manufacturer's  
r

ecommendations.
Checks