2014.5 Citroen C4 DAG maintenance

9
C4-2_en_Chap00b_vue-ensemble_ed01-2014
9
C4-2_en_Chap00b_vue-ensemble_ed01-2014
TECHNICAL DATA - MAINTENANCE
Running out of Diesel fuel ............. 174
Checking   levels  
...................... 178-180
-

 
oil
-

 
brake
  fluid
-
 
coolant
-

 
power
  steering   fluid
-
 
screenwash
  /   headlamp   wash   fluid
-
 
additive
  (Diesel   with   particle  
emissions

  filter)
AdBlue
  additive....................... 183-189
Changing
  bulbs....................... 202-207
-
 
front
-

 
rear Petrol

  engines......................... 223-226
Diesel   engines  
........................ 227-231
Dimensions
 
.................................... 232
Identification
  markings  
................... 233
b

onnet  
........................................... 175
Petrol

  underbonnet  
........................ 176
Diesel

  underbonnet  
....................... 177Checking

  components  
............ 181-182
-

 
battery
-

 
air
  filter   /   passenger   compartment  
filter
-

 
oil
  filter
-
 
particle
  emissions   filter   (Diesel)
-
 
brake
  pads   /   discs
b
attery  
.................................... 212-214
Energy
  economy   mode.................. 215
Engine   compartment   fuses  
..... 208,
  211
oVERVIEW

11 
ECO-DRIVING
Limit the causes of excess consumption
Spread loads throughout  the  vehicle;  place  the  heaviest  items
 in  the  bottom  of  the  boot,  as  close  as  possible  to  the  
rear

  seats.
Limit
 
the
 
loads
 
carried
 
in
 
the
 
vehicle
 
and
 
reduce
 
wind
 
resis
-
tance
 
(roof
 
bars,
 
roof
 
rack,
 
bicycle
 
carrier
,  
trailer
...).  
Use
 
a
 
roof

  box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
 
the
 
end
 
of
 
winter
,  
remove
 
snow
 
tyres
 
and
 
refit
 
your
 
sum
-
mer
  tyres.
Observe the recommendations on maintenance
Check the  tyre  pressures  regularly ,  when  cold,  referring  to  the
  label   in   the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
before
  a   long   journey,
-
 
at
  each   change   of   season,
-
 
after
  a   long   period   out   of   use.
Don't
 
forget
 
the
 
spare
 
wheel
 
and
 
the
 
tyres
 
on
 
any
 
trailer
 
or
 
caravan.
Have

 
your
 
vehicle
 
serviced
 
regularly
 
(engine
 
oil,
 
oil
 
filter
,
 air

 
filter
,  
passenger
 
compartment
 
filter
...)  
and
 
observe
 
the schedule

 
of
 
operations
 
recommended
 
in
 
the
 
manufacturer's service

  schedule.
With
 
a
 
BlueHDi
 
Diesel
 
engine,
 
if
 
the
 
SCR
 
system
 
is
 
faulty
 
your

 
vehicle
 
becomes
 
polluting;
 
go
 
to
 
a
 
CITROËN
 
dealer
 
or
 
a

 
qualified
 
workshop
 
without
 
delay
 
to
 
have
 
the
 
emissions
 
of
 
nitrous

  oxides   brought   back   to   the   legal   level.
When
 
refuellin
g,  
do
 
not
 
continue
 
after
 
the
 
third
 
cut-of
f  
of
 
the
 
nozzle

  to   avoid   any   overflow.
At
 
the
 
wheel
 
of
 
your
 
new
 
vehicle,
 
it
 
is
 
only
 
after
 
the
 
first
 
1 

800  
miles
 
(3
 
000
 
kilometres)
 
that
 
you
 
will
 
see
 
the
 
fuel
 
consumption

  settle   down   to   a   consistent   average.

33
48 
C4-2_en_Chap03_confort_ed01-2014
RECOMMENDATIONS FOR VENTILA TION AND AIR CONDITIONING
In order for  these  systems  to  be  fully  ef fective,  follow  the  operation  and  maintenance
  guidelines   below:
F
 
T
o  
obtain
 
an
 
even
 
air
 
distribution,
 
take
 
care
 
not
 
to
 
obstruct
 
the
 
exterior
 
air

 
intake
 
grille
s  
located
 
at
 
the
 
base
 
of
 
the
 
windscreen,
 
the
 
nozzles,
 
the
 
vents

 
and
 
the
 
air
 
outlets,
 
as
 
well
 
as
 
the
 
air
 
extractor
 
located
 
in
 
the
 
boot.
F

 
Do
 
not
 
cover
 
the
 
sunshine
 
sensor
,  
located
 
on
 
the
 
dashboard;
 
this
 
is
 
used

  for   regulation   of   the   air   conditioning   system.
F
 
Operate
 
the
 
air
 
conditioning
 
system
 
for
 
at
 
least
 
5
 
to
 
10
 
minutes,
 
once
 
or
 
twice

  a   month   to   keep   it   in   perfect   working   order.
F
 
Ensure
 
that
 
the
 
passenger
 
compartment
 
filter
 
is
 
in
 
good
 
condition
 
and
 
have

  the   filter   elements   replaced   regularly.
  W

e  
recommend
 
the
 
use
 
of
 
a
 
combined
 
passenger
 
compartment
 
filter
.  
Thanks

 
to
 
its
 
special
 
active
 
additive,
 
it
 
contributes
 
to
 
the
 
purification
 
of
 
the

 
air
 
breathed
 
by
 
the
 
occupants
 
and
 
the
 
cleanliness
 
of
 
the
 
passenger
 
compartment

 
(reduction
 
of
 
allergic
 
symptoms,
 
bad
 
odours
 
and
 
greasy
 
deposits).
F

 
T
o  
ensure
 
correct
 
operation
 
of
 
the
 
air
 
conditioning
 
system,
 
you
 
are
 
also
 
advised

 
to
 
have
 
it
 
checked
 
regularly
 
as
 
recommended
 
in
 
the
 
mainte
-
nance
  and   warranty   guide.
F
 
If
 
the
 
system
 
does
 
not
 
produce
 
cold
 
air
,  
switch
 
it
 
of
f  
and
 
contact
 
a
 
CITROËN

  dealer   or   a   qualified   workshop.
When
 
towing
 
the
 
maximum
 
load
 
on
 
a
 
steep
 
gradient
 
in
 
high
 
temperatures,
 
switching

 
of
f  
the
 
air
 
conditioning
 
increases
 
the
 
available
 
engine
 
power
 
and
 
so

  improves   the   towing   ability. If
 
after
 
an
 
extended
 
stop
 
in
 
sun
-
shine,  
the
 
interior
 
temperature
 
is
 very
 high,  first  ventilate  the  pas -
senger  compartment  for  a  few  moments.
Put
 
the
 
air
 
flow
 
control
 
at
 
a
 
set
-
ting
 
high
 
enough
 
to
 
quickly
 
change

 
the
 
air
 
in
 
the
 
passenger
 
compartment.
The

 
air
 
conditioning
 
system
 
does

 
not
 
contain
 
chlorine
 
and
 
does

 
not
 
present
 
any
 
danger
 
to
 
the

  ozone   layer.
The
 
condensation
 
created
 
by
 
the

 
air
 
conditioning
 
results
 
in
 
a
 
discharge

 
of
 
water
 
under
 
the
 
ve
-
hicle
  which   is   perfectly   normal.
Stop & Start
The
 
heating
 
and
 
air
 
conditioning
 
systems
 
only
 
work
 
when
 
the
 
engine
 
is
 
running.

 
T
o  
maintain
 
a
 
comfortable
 
temperature
 
in
 
the
 
passenger
 
compart
-
ment,
 
you
 
can
 
temporarily
 
deactivate
 
the
 
Stop
 
&
 
Start
 
system
 
(see
 
the
 
corresponding

  section).
COMFORT

99
148 
C4-2_en_Chap09_conduite_ed01-2014
Moving off
F With your  foot  on  the  brake,  select  position
P or N.
F
 
Start
  the   engine.
If
 
this
 
procedure
 
is
 
not
 
followed,
 
there
 
is

 
an
 
audible
 
signal,
 
accompanied
 
by
 
a
 
message

  in   the   multifunction   screen.
F
 
With
 
the
 
engine
 
running,
 
press
 
the
 
brake

  pedal.
F
 
Release
 
the
 
parking
 
brake,
 
unless
 
it
 
is

  programmed   to   automatic   mode.
F

Select position
R, D or M.
F
 
Gradually
  release   the   brake   pedal.
The
  vehicle   moves   off   immediately.
If position N
 
is
 
engaged
 
inad
-
vertently
 
while
 
driving,
 
allow
 
the
 
engine

 
to
 
return
 
to
 
idle
 
then
 
en
-
gage
  position   D   to   accelerate.
When
 
the
 
engine
 
is
 
running
 
at
 
idle,

 
with
 
the
 
brakes
 
released,
 
if position

R, D or M
 
is
 
selected,
 
the

 
vehicle
 
moves
 
even
 
without
 
the

  accelerator   being   pressed.
When
 
the
 
engine
 
is
 
running,
 
never

 
leave
 
children
 
in
 
the
 
ve
-
hicle
  without   supervision.
When
 
carrying
 
out
 
maintenance
 
with

 
the
 
engine
 
running,
 
apply
 
the

 
parking
 
brake
 
and
 
select
 
po
-
sition P. A
 message

 
is
 
displayed
 
if
 
you
 
try
 
to
 move
 the  gear  lever  from  position  P
without   pressing   the   brake   pedal.
n

ever select position N while the
vehicle
  is   moving.
n

ever select positions P or R
unless
 
the
 
vehicle
 
is
 
completely
 
stationary

.
Sport and snow programmes
These two special  programmes  supple -
ment  the  automatic  operation  in  very  
specific

  conditions   of   use.
Sport programme "S"
F

Press button
"S",  
after
 
starting
 
the
 
engine.
The

 
gearbox
 
automatically
 
favours
 
a
 
dynamic

  style   of   driving.
S
 
appears
 
in
 
the
 
instrument
 
panel.
Snow programme "

T"
F

Press
button "T",  
after
 
starting
 
the
 
engine.
The

 
gearbox
 
adapts
 
to
 
driving
 
on
 
slip
-
pery
  roads.
This
 
programme
 
improves
 
starting
 
and
 
drive

  when   traction   is   poor.
T
 
appears
 
in
 
the
 
instrument
 
panel.
Return to automatic operation
F At any  time,  press  the  button  select -
ed  again  to  quit  the  programme  en -
gaged
 
and
 
return
 
to
 
auto-adaptive
 
mode.
Automatic operation
F Select position D for automatic
changing   of   the   six   gears.
The
 
gearbox
 
then
 
operates
 
in
 
auto-
adaptive

 
mode,
 
without
 
any
 
intervention
 
on

 
the
 
part
 
of
 
the
 
driver
.  
It
 
continuously
 
selects

 
the
 
most
 
suitable
 
gear
 
accord
-
ing
 
to
 
the
 
style
 
of
 
driving,
 
the
 
profile
 
of
 
the

  road   and   the   load   in   the   vehicle.
For
 
maximum
 
acceleration
 
without
 
touching

 
the
 
lever
,  
press
 
the
 
accelera
-
tor
 
pedal
 
down
 
fully
 
(kick
 
down).
 
The
 
gearbox

 
changes
 
down
 
automatically
 
or

 
maintains
 
the
 
gear
 
selected
 
until
 
the
 
maximum

  engine   speed   is   reached.
On
 
braking,
 
the
 
gearbox
 
changes
 
down
 
automatically

 
to
 
provide
 
efficient
 
engine
 
braking.
If you release the accelerator sharply

,
the
 
gearbox
 
will
 
not
 
change
 
to
 
a
 
higher
 
gear

  for   safety   reasons.
DRIVING

99
156 
C4-2_en_Chap09_conduite_ed01-2014
Maintenance
In the event  of  a  malfunction  with  the  system,
 the  "ECO OFF" switch warn-
ing
 
lamp
 
flashes,
 
then
 
comes
 
on
 
con
-
tinuously.
have
 
it
 
checked
 
by
 
a
 
CITROËN
 
dealer
 
or

  a   qualified   workshop.
Operating fault
Before doing anything  under  the  bonnet,
 deactivate  the  Stop  &  
Start

 
system
 
to
 
avoid
 
any
 
risk
 
of
 
injury

 
resulting
 
from
 
automatic
 
operation

  of   START
 
mode.
This
 
system
 
requires
 
a
 
specific
 
battery
 
with

 
a

 
special
 
specification
 
and
 
technol
-
ogy
 
(reference
 
numbers
 
available
 
from
 
a

 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
work
-
shop).
Fitting
 
a
 
battery
 
not
 
listed
 
by
 
CITROËN 

introduces  
the
 
risk
 
of
 
mal
-
function
  of   the   system.
The
 
Stop
 
&
 
Start
 
system
 
makes
 
use

 
of
 
advanced
 
technology
.  
All
 
work

 
on
 
this
 
type
 
of
 
battery
 
must
 
be

 
done
 
only
 
by
 
a
 
CITROËN
 
dealer

  or   a   qualified   workshop.
In the event of a fault in ST
o

P
mode,
 
the

 
vehicle

 
may

 
stall.

 
All

 
of

 
the

 
instrument

 
panel

 
warning

 
lamps

 
come
 
on.
Depending
 
on

 
version,

 
an

 
alert

 
message

 
may

 
also

 
be

 
displayed

 
asking

 
you

 
to

 
put

 
the

 
gear

 
lever

 
into position

N
 
and

 
put

 
your

 
foot

 
on

 
the
 
brake
 
pedal.
It is then necessary to switch off
the
 
ignition,

 
then

 
restart

 
the

 
en

-
gine
 
using
 
the
 
key.
DRIVING

1010
181 
C4-2_en_Chap10_verification_ed01-2014
CHECKSParticle emission filter (Diesel)
The start of saturation of the particle
emissions  filter   is   indicated   by:
-
 
fixed
 
illumination
 
of
 
the
 
par
-
ticle
 
emissions
 
filter
 
warning lamp,

 
accompanied
 
by
 
an audible

 
signal
 
and
 
a
 
message that

 
there
 
is
 
a
 
risk
 
of
 
blockage of

  the   particle   emissions   filter.
The presence of this label, in particular
with
 
the

 
Stop

 
&

 
Start

 
system,

 
indicates

 
the

 
use

 
of

 
a

 
specific

 
12

 
V

 
lead-acid

 
bat

-
tery
 
with

 
special

 
technology

 
and

 
specifi

-
cation.
 
The

 
involvement

 
of

 
a

 
CITROËN

 
dealer

 
or

 
a

 
qualified

 
workshop

 
is

 
essen

-
tial
 
when

 
replacing

 
or

 
disconnecting

 
the

 
battery

. On
 
a
 
new
 
vehicle,
 
the
 
first
 
op
-
erations
 
of
 
regeneration
 
of
 
the
 
particle

 
emissions
 
filter
 
may
 
be
 
accompanied

 
by
 
the
 
smell
 
of
 
"burning",

 
which
 
is
 
perfectly
 
nor
-
mal.
Following
 
prolonged
 
operation
 
of

 
the
 
vehicle
 
at
 
very
 
low
 
speed
 
or

 
at
 
idle,
 
you
 
may
,  
in
 
excep
-
tional
 
circumstances,
 
notice
 
the
 
emission

 
of
 
water
 
vapour
 
at
 
the
 
exhaust

 
on
 
acceleration.
 
This
 
does

 
not
 
af
fect  
the
 
behaviour
 
of
 
the

  vehicle   or   the   environment.
As
 
soon
 
as
 
the
 
traffic
 
conditions
 
per
-
mit,
 
regenerate
 
the
 
filter
 
by
 
driving
 
at
 
a
 
speed

 
of
 
at
 
least
 
40
 
mph
 
(60
 
km/h)
 
until
 
the

  warning   lamp   goes   off.
If
 
the
 
warning
 
lamp
 
stays
 
on,
 
refer
 
to
 
the

  "Additive   level"   section.
Unless
 otherwise
 indicated,
 check
 these
 components
 in
 accordance
 with
 
the

 
manufacturer's

 
service

 
schedule

 
and

 
according
 
to
 
your
 
engine.
Otherwise,
 
have

 
them

 
checked

 
by

 
a

 
CITROËN

 
dealer

 
or

 
a

 
qualified

 
work

-
shop.
Air filter and passenger compartment filter
Refer to  the  manufacturer's  service
 schedule  for  details  of  
the

 
replacement
 
intervals
 
for
 
these

  components.
Depending
 
on
 
the
 
environ
-
ment
 
(e.g.
 
dusty
 
atmosphere)
 
and
 
the
 
use

 
of

 
the
 
vehicle
 
(e.g.
 
city
 
driving),
 
re
-
place them twice as often if neces-
sary.
A
 clogged

 
passenger
 
compartment
 
fil
-
ter
 
may

 
have
 
an
 
adverse
 
ef
fect  
on
 
the
 
performance

 
of
 
the
 
air
 
conditioning
 
sys
-
tem
 
and
 
generate   undesirable   odours.
Oil filter
Replace the oil  filter  each  time  the
  engine   oil   is   changed.
Refer
 
to
 
the
 
manufacturer's
 
service

 
schedule
 
for
 
details
 
of

 
the
 
replacement
 
interval
 
for
 
this

 
component.
12 V battery
The battery  does  not  require  any
  maintenance.
However,
 
check
 
that
 
the
 
ter
-
minals
 
are
 
clean
 
and
 
correctly
 
tightened,

 
particularly
 
in
 
sum
-
mer
 
and
 
winter.
When
 
carrying
 
out
 
work
 
on
 
the
 
battery
,  
refer

 
to

 
the
 
"12 
V  
battery"
 
section
 
for
 
details

 
of
 
the
 
precautions
 
to
 
be
 
taken
 
before

 
disconnecting
 
the
 
battery
 
and
 
following

  its   reconnection.
CHECKS

1010
182 
C4-2_en_Chap10_verification_ed01-2014
Automatic gearbox
The gearbox does  not  re -
quire  any  maintenance  (no  oil  
change).
 Refer

 
to
 
the
 
manufacturer's
 
service

 
schedule
 
for
 
details
 
of
 
the

 
level
 
checking
 
interval
 
for
 
this

  component.
Electric parking brake
This system  does  not  require  any
 routine  servicing.  However ,  
in

 
the
 
event
 
of
 
a
 
problem,
 
have

 
the
 
system
 
checked
 
by
 
a

 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
work
-
shop.
Manual parking brake
Only use  products  recommended by
 CITROËN  or  products  of  equiva -
lent
  quality   and   specification.
In order to  optimise  the  opera -
tion  of  units  as  important  as  
those

 
in
 
the
 
braking
 
system,
 
CITROËN

 
selects
 
and
 
of
fers  
very

  specific   products.
After
 
washing
 
the
 
vehicle,
 
damp
-
ness,
 
or
 
in
 
wintry
 
conditions,
 
ice
 
can

 
form
 
on
 
the
 
brake
 
discs
 
and
 
pads:

 
braking
 
efficiency
 
may
 
be
 
reduced.

 
Make
 
light
 
brake
 
ap
-
plications
 
to
 
dry
 
and
 
defrost
 
the
 
brakes.
If a loss of ef

fectiveness of this
system
 
is

 
noticed,

 
the

 
parking

 
brake

 
must

 
be

 
checked,

 
even

 
between

 
two
 
services.
Checking
 
this

 
system

 
must

 
be

 
done

 
by

 
a

 
CITROËN

 
dealer

 
or

 
a

 
quali

-
fied
 
workshop.
Brake pads
Brake wear  depends  on  the  style
 of  driving,  particularly  in  
the

 
case
 
of
 
vehicles
 
used
 
in
 
town,

 
over
 
short
 
distances.
 
It
 
may

 
be
 
necessary
 
to
 
have
 
the
 
condition

 
of
 
the
 
brakes
 
checked,
 
even
 
between

 
vehicle   services.
Unless
 
there
 
is
 
a
 
leak
 
in
 
the
 
circuit,
 
a
 
drop

 
in

 
the
 
brake
 
fluid
 
level
 
indicates
 
that

 
the
 
brake   pads   are   worn.
Brake disc wear
For information  on  checking  brake
 disc  wear ,  contact  a  
CITROËN

 
dealer
 
or
 
a
 
quali
-
fied
  workshop. For
 
more
 
information,
 
refer
 
to
 
the
 
"Electric parking

  brake   -   Operating   faults"   section.
Manual gearbox
The gearbox
 does  not  re -
quire  any  maintenance  (no  oil  
change).
Refer

 
to
 
the
 
manufacturer's
 
service

 
schedule
 
for
 
the
 
checking

 
interval
 
for
 
this
 
com
-
ponent.
Electronic gearbox
The gearbox  does  not  re -
quire  any  maintenance  (no  oil  
change).
 Refer

 
to
 
the
 
manufacturer's
 
service

 
schedule
 
for
 
details
 
of
 
the

 
checking
 
interval
 
for
 
this
 
component.
CHECKS

1111
222
C4-2_en_Chap11_info-pratique_ed01-2014
Installation of radio
communication transmitters
Before 
installin
g  
any
 
after-
market

 
radio
 
communication
 
transmitter

,  
you
 
can
 
contact
 
a
 
CITROËN

 
dealer
 
for
 
the
 
speci
-
fication
 
of
 
transmitters
 
which
 
can

 
be
 
fitted
 
(frequency
,  
maxi
-
mum
 
power
,  
aerial
 
position,
 
specific

 
installation
 
require
-
ments),
 
in
 
line
 
with
 
the
 
V
ehicle  
Electromagnetic

 
Compatibility

 

Directive   (2004/104/EC). Depending
 on  the  legislation  in  force
in the country, certain safe-
ty
 
equipment
 
may
 
be
 
compul
-
sory:
 
high
 
visibility
 
safety
 
vests,
 
warning

 
triangles,
 
breathalyzers,
 
spare

 
bulbs,
 
spare
 
fuses,
 
fire
 
ex
-
tinguisher,
 
first
 
aid
 
kit,
 
mud
 
flaps
 
at

  the   rear   of   the   vehicle.
The
 
fitting
 
of
 
electrical
 
equip
-
ment
 
or
 
accessories
 
which
 
are
 
not

 
recommended
 
by
 
CITROËN
 
may

 
result
 
in
 
a
 
failure
 
of
 
your
 
ve
-
hicle's
 
electronic
 
system
 
and
 
ex
-
cessive
  electrical   consumption.
Contact
 
a
 
CITROËN
 
dealer
 
for

 
information
 
on
 
the
 
range
 
of
 
recommended

 
equipment
 
and
 
 
accessories.
"Multimedia":
audio

 
systems,
 
steering
 
mounted
 
au
-
dio
 
controls,
 
speakers,
 
Hi-Fi
 
module,
 
Bluetooth

 
hands-free
 
system,
 
port
-
able
 
satellite
 
navigation
 
system,
 
semi-
integral
 
support
 
bracket
 
for
 
portable
 
navigation

 
system,
 
mapping
 
update
 
CD,

 
driving
 
assistant,
 
portable
 
video
 
screen,

 
portable
 
video
 
support
 
bracket,
 
230 

V/50  
Hz
 
socket,
 
230
 
V/50
 
Hz
 
adap
-
tor, iPhone
® compatible  mobile  phone  charger
,
 mobile  phone/smartphone  
bracket,

 
Wi-Fi   on   board... By
 
going
 
to
 
a
 
CITROËN 
dealer,  
you
 
can
 
also

 
obtain
 
cleaning
 
and
 
maintenance
 
products

 
(interior
 
and
 
exterior) 
-  in-
cluding  
ecological
 
products
 
in
 
the
 
"TECHNA

TURE"  
range
 
-,
 
products
 
for
 
topping

 
up
 
(screenwash...),
 
touch-up
 
pens

 
and
 
paint
 
aerosols
 
for
 
the
 
exact
 
colour

 
of
 
your
 
vehicle,
 
recharges
 
(car
-
tridge  
for
 
the
 
temporary
 
puncture
 
repair
 
kit...),

  ...
PRACTICAL INFORMATION