2013 TOYOTA HILUX air condition

512 4-3. Do-it-yourself maintenance
HILUX_OM_OM0K134E_(EE)
Checking interval
Inspect and replace the air conditioning filter according to the maintenance
schedule. In dusty areas or areas with heavy traffic flow, early replacement
may be required. (For scheduled maintenance information, please refer to
the “Toyota Service Booklet” or “Toyota Warranty Booklet”.)
If air flow from the vents decreases dramatically
The filter may be clogged. Check the filter and replace if necessary.
NOTICE
When using the air conditioning system
Make sure that a filter is always installed.
Using the air conditioning system without a filter may cause damage to the
system.
Remove the filter and replace
it with a new one.
The “UP” marks shown on
the filter should be pointing up.
STEP5

524 4-3. Do-it-yourself maintenance
HILUX_OM_OM0K134E_(EE)
FuseAmpereCircuit
8PWR SEAT30 APower seat
9PTC NO.250 APower heater
10H-LP CLN40 AHeadlight cleaners
11FR HTR50 AAir conditioning system, A/C fuse
12ABS NO.230 AABS, TRC and VSC
13ABS NO.140 AABS, TRC and VSC
14ALT100 A
Charging system, PWR SEAT, H-
LP CLN, FR HTR, AM1, IG1, PTC
NO.1, PTC NO.2, PWR OUT,
STOP, TAIL and OBD fuses
15GLOW80 AEngine glow system
16BATT P/I50 AFOG, HORN and EFI fuses
17AM230 AEngine starter, ST, IGN, INJ and
MET
18MAIN40 AH-LP RH, H-LP LH, H-LP RL and
H-LP LL fuses
19H-LP RL15 ARight-hand headlight (Low)
20H-LP LL15 ALeft-hand headlight (Low)
21H-LP RH15 ARight-hand headlight (High) and
right-hand headlight (Low)
22H-LP LH15 ALeft-hand headlight (High) and left-
hand headlight (Low)
23EFI No.210 A
Multiport fuel injection system/
sequential multiport fuel injection
system

525 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_OM_OM0K134E_(EE)
FuseAmpereCircuit
24ECU-B10 A
Door courtesy switches, power
door lock system, wireless remote
control system, steering sensor
and headlights
25RAD15 AAudio system
26DOME7.5 A
Interior lights, engine switch light,
personal light, gauges and meters,
clock, multi-information display,
wireless remote control system,
daytime running light system and
fog light
27A/F20 AEmission control system
28ALT-S7.5 ACharging system
29TURN-HAZ15 AEmergency flashers and turn signal
lights
30ECU-B No.27.5 AAir conditioning system
31DCC30 AECU-B, DOME and RAD fuses

527 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_OM_OM0K134E_(EE)
FuseAmpereCircuit
4OBD7.5 AOn-board diagnosis system
5INJ15 A
Multiport fuel injection system/
sequential multiport fuel injection
system
6ECU-IG &
GAUGE10 A
Air conditioning system, charging
system, rear differential lock sys-
tem, ABS, TRC, VSC, emergency
flashers, turn signal lights, back-up
lights, multiport fuel injection sys-
tem/sequential multiport fuel injec-
tion system, shift lock control
system, rear window defogger,
headlights, door courtesy switches,
power door lock system, wireless
remote control system, steering
sensor, daytime running light sys-
tem, cruise control, headlight clean-
ers, seat heaters, outside rear view
mirror defoggers, multi-information
display and passenger’s seat belt
reminder light
7WIP20 AWindshield wiper and washer
8IGN7.5 A
Multiport fuel injection system/
sequential multiport fuel injection
system, SRS airbags and fuel pump
9ACC7.5 A
Audio system, power outlet, clock,
power rear view mirror control sys-
tem, shift lock control system and
multi-information display

528 4-3. Do-it-yourself maintenance
HILUX_OM_OM0K134E_(EE)
FuseAmpereCircuit
10CIG15 ACigarette lighter
11MET7.5 AGauges and meters and DPF sys-
tem
12A/C10 AAir conditioning system
13ST7.5 A
Starting system, gauges and
meters and multiport fuel injection
system/sequential multiport fuel
injection system

548
HILUX_OM_OM0K134E_(EE)
5-1. Essential information
Emergency flashers
NOTICE
To prevent battery discharge
Do not leave the emergency flashers on longer than necessary when the
engine is not running.
Use the emergency flashers if the vehicle malfunctions or is
involved in an accident.
Vehicles without automatic air conditioning system
Press the switch to flash all
the turn signal lights. To turn
them off, press the switch
once again.
Vehicles with automatic air conditioning system
Press the switch to flash all
the turn signal lights. To turn
them off, press the switch
once again.

5
555
5-1. Essential information
When trouble arises
HILUX_OM_OM0K134E_(EE)
If you think something is wrong
If you notice any of the following symptoms, your vehicle probably
needs adjustment or repair. Contact any authorized Toyota dealer or
repairer, or another duly qualified and equipped professional, as
soon as possible.
Visible symptoms
Fluid leaks under the vehicle.
(Water dripping from the air conditioning after use is normal.)
Flat-looking tires or uneven tire wear
Engine coolant temperature gauge needle continually points
higher than normal.
Audible symptoms
Changes in exhaust sound
Excessive tire squeal when cornering
Strange noises related to the suspension system
Pinging or other noises related to the engine
Operational symptoms
Engine missing, stumbling or running roughly
Appreciable loss of power
Vehicle pulls heavily to one side when braking
Vehicle pulls heavily to one side when driving on a level road
Loss of brake effectiveness, spongy feeling, pedal almost
touches the floor

5
563 5-2. Steps to take in an emergency
When trouble arises
HILUX_OM_OM0K134E_(EE)
If the malfunction indicator lamp comes on while driving
For some models, the malfunction indicator lamp will come on if the fuel tank
becomes completely empty. If the fuel tank is empty, refuel the vehicle
immediately. The malfunction indicator lamp will go off after several trips.
If the malfunction indicator lamp does not go off, contact any authorized
Toyota dealer or repairer, or another duly qualified and equipped
professional.
Key reminder buzzer
The buzzer indicates that the key has not been removed with the engine off
and the driver’s door opened.
If the DPF system warning light comes on
The deposit collected in the filter needs to be regenerated.
To regenerate the filter, the following driving methods are recommended
*:
By driving continuously (for example, at around 60 km/h [37 mph] for
approximately 20 minutes).
By avoiding short trips, or by driving continuously (leaving the engine
running for long periods of time).
The DPF warning light will extinguish when regeneration is complete. How-
ever, if this driving cannot be carried out, or if the light does not extinguish
even after driving, have the vehicle inspected by any authorized Toyota
dealer or repairer, or another duly qualified and equipped professional imme-
diately.
For details of the DPF system. (P. 227)
*: When driving, pay sufficient attention to weather, road conditions, terrain
and traffic conditions, and drive according to traffic laws.