2013 Lancia Thema radiator cap

HAZARD WARNING
FLASHERS
The Hazard Warning flasher switch is
located in the center of the instrument
panel between the center air outlets.Press the switch to turn on the
Hazard Warning flashers.
When the switch is activated, all di-
rectional turn signals will flash on and
off to warn oncoming traffic of an
emergency. Press the switch a second
time to turn off the Hazard Warning
flashers.
This is an emergency warning system
and it should not be used when the
vehicle is in motion. Use it when your
vehicle is disabled and it is creating a
safety hazard for other motorists.
When you must leave the vehicle to
seek assistance, the Hazard Warning
flashers will continue to operate even
though the ignition is placed in the
OFF position.
NOTE: With extended use the
Hazard Warning flashers may
wear down your battery. IF YOUR ENGINE
OVERHEATS
In any of the following situations, you
can reduce the potential for overheat-
ing by taking the appropriate action.
 On the highways — slow down.
 In city traffic — while stopped,
place the transmission in NEU-
TRAL, but do not increase the en-
gine idle speed.
NOTE: There are steps that you
can take to slow down an impend-
ing overheat condition:
 If your air conditioner (A/C) is on, turn it off. The A/C system
adds heat to the engine cooling
system and turning the A/C off
can help remove this heat.
 You can also turn the tempera- ture control to maximum heat,
the mode control to floor and the
blower control to high. This al-
lows the heater core to act as a
supplement to the radiator and
aids in removing heat from the
engine cooling system.
CAUTION!
Driving with a hot cooling system
could damage your vehicle. If the
temperature gauge reads “H,” pull
over and stop the vehicle. Idle the
vehicle with the air conditioner
turned off until the pointer drops
back into the normal range. If the
pointer remains on the “H,” turn
the engine off immediately and call
for service.WARNING!You or others can be badly burned
by hot engine coolant (antifreeze) or
steam from your radiator. If you see
or hear steam coming from under
the hood, do not open the hood until
the radiator has had time to cool.
Never try to open a cooling system
pressure cap when the radiator or
coolant bottle is hot.
254

WARNING!
A hot exhaust system can start a fire
if you park over materials that can
burn. Such materials might be
grass or leaves coming into contact
with your exhaust system. Do not
park or operate your vehicle in ar-
eas where your exhaust system can
contact anything that can burn.
In unusual situations involving
grossly malfunctioning engine opera-
tion, a scorching odor may indicate
severe and abnormal catalyst over-
heating. If this should occur, safely
bring the vehicle to a complete stop,
shut the engine OFF, and allow the
vehicle to cool. Thereafter, obtain ser-
vice, including a tune-up to manufac-
turer's specifications immediately.
To minimize the possibility of catalyst
damage:
 Do not shut off the engine or inter- rupt the ignition when the trans-
mission is in gear and the vehicle is
in motion.
 Do not try to start the engine by pushing or towing the vehicle.  Do not idle the engine with any
spark plug wires disconnected or
removed, such as when diagnostic
testing, or for prolonged periods
during very rough idling or mal-
functioning operating conditions.
COOLING SYSTEM
WARNING!
 When working near the radiator cooling fan, disconnect the fan
motor lead or turn the ignition
switch to the LOCK position. The
fan is temperature controlled and
can start at anytime the ignition
switch is in the ON position.
 You or others can be badly
burned by hot engine coolant
(antifreeze) or steam from your
radiator. If you see or hear steam
coming from under the hood, do
not open the hood until the radia-
tor has had time to cool. Never try
to open a cooling system pressure
cap when the radiator is hot.
CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
Coolant ChecksCheck engine coolant (antifreeze) pro-
tection every 12 months (before the
onset of freezing weather, where appli-
cable). If the engine coolant (anti-
freeze) is dirty or rusty in appearance,
the system should be drained, flushed,
and refilled with fresh coolant. Check
the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If
dirty, clean by gently spraying water
from a garden hose vertically down the
face of the condenser.Check the coolant recovery bottle
tubing for brittle rubber, cracking,
tears, cuts, and tightness of the con-
nection at the bottle and radiator.
Inspect the entire system for leaks.
281

With the engine at normal operating
temperature (but not running), check
the cooling system pressure cap for
proper vacuum sealing by draining a
small amount of engine coolant (anti-
freeze) from the radiator drain cock.
If the cap is sealing properly, the
engine coolant (antifreeze) will begin
to drain from the coolant recovery
bottle. DO NOT REMOVE THE
COOLANT PRESSURE CAP WHEN
THE COOLING SYSTEM IS HOT.
Cooling System – Drain, Flush,
And Refill
If the engine coolant (antifreeze) is
dirty or contains a considerable
amount of sediment, clean and flush
with a reliable cooling system cleaner.
Follow with a thorough rinsing to re-
move all deposits and chemicals.
Properly dispose of old engine coolant
(antifreeze).
Refer to the “Maintenance Schedule”
for the proper maintenance intervals.Selection Of Coolant
Use only the manufacturer's recom-
mended engine coolant (antifreeze).
Refer to “Fluids, Lubricants, and
Genuine Parts” in “Maintaining Your
Vehicle” for further information.
CAUTION!
 Mixing of engine coolant (anti-
freeze) other than specified en-
gine coolant (antifreeze), may re-
sult in engine damage and may
decrease corrosion protection. If a
non-specified engine coolant (an-
tifreeze) is introduced into the
cooling system in an emergency, it
should be replaced with the speci-
fied engine coolant (antifreeze) as
soon as possible.
 Do not use plain water alone or alcohol-based engine coolant
(antifreeze) products. Do not use
additional rust inhibitors or anti-
rust products, as they may not be
compatible with the radiator en-
gine coolant (antifreeze) and may
plug the radiator.
(Continued)
CAUTION!(Continued)
 This vehicle has not been de- signed for use with Propylene
Glycol based engine coolant (an-
tifreeze). Use of Propylene Glycol
based engine coolant (antifreeze)
is not recommended.
Adding Coolant
Your vehicle has been built with an
improved engine coolant (antifreeze)
that allows extended maintenance in-
tervals. This engine coolant (anti-
freeze) can be used up to ten years or
240 000 km before replacement. To
prevent reducing this extended main-
tenance period, it is important that
you use the same engine coolant (an-
tifreeze) throughout the life of your
vehicle.
When adding engine coolant (anti-
freeze):
Use only high purity water such as
distilled or deionized water when
mixing the water/engine coolant (an-
tifreeze) solution. The use of lower
282

quality water will reduce the amount
of corrosion protection in the engine
cooling system.Please note that it is the owner's respon-
sibility to maintain the proper level of
protection against freezing according to
the temperatures occurring in the area
where the vehicle is operated.NOTE: Mixing engine coolant
(antifreeze) types will decrease the
life of the engine coolant (anti-
freeze) and will require more fre-
quent engine coolant (antifreeze)
changes.
Cooling System Pressure Cap
The cap must be fully tightened to
prevent loss of engine coolant (anti-
freeze), and to ensure that engine
coolant (antifreeze) will return to the
radiator from the coolant recovery
bottle.The cap should be inspected and
cleaned if there is any accumulation of
foreign material on the sealing surfaces.
WARNING!
 The warning words “DO NOTOPEN HOT” on the cooling sys-
tem pressure cap are a safety pre-
caution. Never add engine cool-
ant (antifreeze) when the engine
is overheated. Do not loosen or
remove the cap to cool an over-
heated engine. Heat causes pres-
sure to build up in the cooling
system. To prevent scalding or in-
jury, do not remove the pressure
cap while the system is hot or
under pressure.
 Do not use a pressure cap other
than the one specified for your
vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine
coolant (antifreeze) is a regulated
substance requiring proper disposal.
Check with your local authorities to
determine the disposal rules for your
community. To prevent ingestion by
animals or children, do not store
ethylene glycol-based engine coolant
(antifreeze) in open containers or allow it to remain in puddles on the
ground. If ingested by a child or pet,
seek emergency assistance immedi-
ately. Clean up any ground spills im-
mediately.
Coolant Level
The coolant bottle provides a quick
visual method for determining that
the coolant level is adequate. With the
engine OFF and cold, the level of the
coolant in the bottle should be be-
tween the ranges indicated on the
bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing engine cool-
ant (antifreeze). Advise your service
attendant of this. As long as the en-
gine operating temperature is satis-
factory, the coolant bottle need only
be checked once a month.
When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill.
283

Points To Remember
NOTE: When the vehicle is
stopped after a few kilometers of
operation, you may observe vapor
coming from the front of the engine
compartment. This is normally a
result of moisture from rain, or
high humidity accumulating on
the radiator and being vaporized
when the thermostat opens, allow-
ing hot engine coolant (antifreeze)
to enter the radiator.
If an examination of your engine com-
partment shows no evidence of radia-
tor or hose leaks, the vehicle may be
safely driven. The vapor will soon dis-
sipate.
 Do not overfill the coolant recoverybottle.
Check engine coolant (antifreeze)
freeze point in the radiator and in
the coolant recovery bottle. If engine
coolant (antifreeze) needs to be
added, contents of coolant recovery
bottle must also be protected against
freezing.
 If frequent engine coolant (anti- freeze) additions are required, or if
the level in the coolant recovery
bottle does not drop when the en-
gine cools, the cooling system
should be pressure tested for leaks.
Maintain engine coolant (antifreeze)
concentration at 50% engine coolant
(antifreeze) (minimum) and dis-
tilled water for proper corrosion pro-
tection of your engine, which con-
tains aluminum components. Make sure that the radiator and coolant recovery bottle overflow
hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air
conditioning, keep the front of the
condenser clean.
 Do not change the thermostat for Summer or Winter operation. If re-
placement is ever necessary, install
ONLY the correct type thermostat.
Other designs may result in unsat-
isfactory engine coolant (anti-
freeze) performance, poor gas mile-
age, and increased emissions. BRAKE SYSTEM
In order to assure brake system per-
formance, all brake system compo-
nents should be inspected periodi-
cally. Refer to the “Maintenance
Schedule” for the proper maintenance
intervals.
WARNING!
Riding the brakes can lead to brake
failure and possibly an accident.
Driving with your foot resting or
riding on the brake pedal can result
in abnormally high brake tempera-
tures, excessive lining wear, and
possible brake damage. You would
not have your full braking capacity
in an emergency.CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
(Continued)
284

Bulb Replacement. . . . . . . .298, 299
Bulbs, Light . . . . . . . . . . . . .58, 298
Camera, Rear . . . . . . . . . . . . . .138
Capacities, Fluid . . . . . . . . . . . .302
Caps, Filler Radiator (Coolant Pressure) . .283
Carbon Monoxide Warning . . . . . .56
Cargo Area Features . . . . . . . . . .150
Cargo Compartment . . . . . . . . . .150
Cellular Phone . . . . . . . . . . . . . .184
Chains, Tire . . . . . . . . . . . . . . .232
Chart, Tire Sizing . . . . . . . . . . . .222
Check Engine Light (Malfunction Indicator Light) . . . . . . . . . . .159
Checking Your Vehicle For Safety . .56
Checks, Safety . . . . . . . . . . . . . . .56
Child Restraint . . . . . .46, 50, 52, 53
Child Restraint Tether Anchors . . . . . . . . . . . . . . .51, 52
Child Safety Locks . . . . . . . . . . . .21
Child Seat . . . . . . . . . . . . . . . . . .47
Clean Air Gasoline . . . . . . . . . . .239
Cleaning Wheels . . . . . . . . . . . . . . . .289
Windshield Wiper Blades . . . .279
Climate Control . . . . . . . . . . . . .184
Clock . . . . . . . . . . . . . . . . . . . .181 Coin Holder
. . . . . . . . . . . . . . .148
Cold Weather Operation . . . . . . .196
Compact Disc (CD) Maintenance . . . . . . . . . . . . .184
Compact Spare Tire . . . . . . . . . .230
Computer, Trip/Travel . . . . . . . . .171
Connector UCI . . . . . . . . . . . . . . . . . .182
Universal Consumer
Interface (UCI) . . . . . . . . . . .182
Conserving Fuel . . . . . . . . . . . . .169
Console, Floor . . . . . . . . . . . . . .148
Console, Overhead . . . . . . . . . . .140
Coolant Pressure Cap (Radiator Cap) . . . . . . . . . . . .283
Cooling System . . . . . . . . . . . . .281
Adding Coolant (Antifreeze) . .282
Coolant Capacity . . . . . . . . . .302
Coolant Level . . . . . . . .281, 283
Disposal of Used Coolant . . . .283
Drain, Flush, and Refill . . . . .282
Inspection . . . . . . . . . . . . . .283
Points to Remember . . . . . . .284
Pressure Cap . . . . . . . . . . . .283
Radiator Cap . . . . . . . . . . . .283
Selection of Coolant
(Antifreeze) . . . . . . . . .282, 302
Corrosion Protection . . . . . . . . . .288 Cruise Control (Speed Control)
. . .121
Cupholders . . . . . . . . . . . .147, 290
Data Recorder, Event . . . . . . . . . .45
Daytime Brightness, Interior Lights . . . . . . . . . . . . . . . . . .114
Deck Lid, Emergency Release . . . . .27
Deck Lid, Power Release . . . . . . . .26
Defroster, Rear Window . . . . . . . .151
Defroster, Windshield . . . . . .57, 187
Delay (Intermittent) Wipers . . . . .115
Diagnostic System, Onboard . . . . .273
Diesel Fuel . . . . . . . . . . . . . . . .240
Dimmer Switch, Headlight . . . . . .112
Dipsticks Oil (Engine) . . . . . . . . . . . . .274
Disposal Antifreeze (Engine Coolant) . .283
Engine Oil . . . . . . . . . . . . . .275
Door Locks . . . . . . . . . . . . . . . . .20
Door Locks, Automatic . . . . . . . . .21
Driving Through Flowing, Rising, or
Shallow Standing Water . . . . .211
Driving to Achieve Maximum Fuel Economy . . . . . . . . . . . . . . . .169
Electrical Power Outlets . . . . . . .145
Electric Rear Window Defrost . . . .151
321

Mini-Trip Computer. . . . . . . . . .171
Mirrors . . . . . . . . . . . . . . . . . . . .67
Automatic Dimming . . . . . . . .67
Electric Powered . . . . . . . . . . .68
Electric Remote . . . . . . . . . . .68
Exterior Folding . . . . . . . . . . .67
Heated . . . . . . . . . . . . . . . . .69
Outside . . . . . . . . . . . . . . . . .67
Vanity . . . . . . . . . . . . . . . . . .69
Mode Fuel Saver . . . . . . . . . . . . . .169
Modifications/Alterations, Vehicle . . .7
Monitor, Tire Pressure System . . .234
Multi-Function Control Lever . . . .112
Navigation System (Uconnect™ gps) . . . . . . .138, 181
New Vehicle Break-In Period . . . . .55
Occupant Restraints . . . . .27, 41, 43
Occupant Restraints (Sedan) . . . . . . . . . . . .38, 41, 43
Octane Rating, Gasoline (Fuel) . . . . . . . . . . . . . .238, 302
Odometer . . . . . . . . . . . . . . . . .158
Oil Change Indicator . . . . . .158, 168
Oil Change Indicator, Reset . .158, 168
Oil, Engine . . . . . . . . . . . .274, 302
Capacity . . . . . . . . . . . . . . .302 Change Interval
. . . . . . .168, 274
Diesel . . . . . . . . . . . . . . . . .275
Dipstick . . . . . . . . . . . . . . . .274
Filter . . . . . . . . . . . . . .275, 302
Materials Added to . . . . . . . .275
Recommendation . .274, 275, 302
Synthetic . . . . . . . . . . . . . . .275
Viscosity . . . . . . . . . . . . . . .302
Oil Filter, Selection . . . . . . . . . . .275
Onboard Diagnostic System . . . . .273
Operating Precautions . . . . . . . . .273
Operator Manual (Owner's Manual) . . . . . . . . . . . . . . . . . .6
Outside Rearview Mirrors . . . . . . .67
Overdrive . . . . . . . . . . . . . . . . .207
Overdrive OFF Switch . . . . . . . . .207
Overhead Console . . . . . . . . . . . .140
Overheating, Engine . . . . . .163, 254
Owner's Manual (Operator Manual) . . . . . . . . . . . . . . . . . .6
Paint Care . . . . . . . . . . . . . . . . .288
Parking Brake . . . . . . . . . . . . . .213
Park Sense System, Rear . . . . . . .134
Passing Light . . . . . . . . . . . . . . .112
Pedals, Adjustable . . . . . . . . . . .119
Pets . . . . . . . . . . . . . . . . . . . . . .55 Placard, Tire and Loading
Information . . . . . . . . . . . . . .225
Power Deck Lid Release . . . . . . . . . .26
Distribution Center (Fuses) . . .294
Door Locks . . . . . . . . . . . . . .21
Mirrors . . . . . . . . . . . . . . . . .68
Outlet (Auxiliary Electrical
Outlet) . . . . . . . . . . . . . . . .145
Seats . . . . . . . . . . . . . . . . . .100
Steering . . . . . . . . . . . . . . . .212
Sunroof . . . . . . . . . . . .140, 142
Tilt/Telescoping Steering
Column . . . . . . . . . . . . . . . .117
Windows . . . . . . . . . . . . . . . .24
Power Steering Fluid . . . . . . . . . .304
Pregnant Women and Seat Belts . . .36
Pretensioners Seat Belts . . . . . . . . . . . . . . . .33
Programming Transmitters (Remote Keyless Entry) . . . . . . .18
Radial Ply Tires . . . . . . . . . . . . .229
Radiator Cap (Coolant Pressure Cap) . . . . . . . . . . . . .283
Radio Operation . . . . . . . . . . . . .184
Radio Remote Controls . . . . . . . .183
Radio (Sound Systems) . . . . . . . .181
Rain Sensitive Wiper System . . . .115
325