2013 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS oil capacities

ENGINE OIL DIPSTICK
A.–MIN
B. – MAX
ENGINE OIL CHECK
Note:Check the level before starting the engine.
Note:Make sure that the level is between the MIN and MAX marks.
1. Make sure that your vehicle is on level ground.
2. Turn the engine off and wait 10 minutes for the oil to drain into the
oil pan.
3. Remove the dipstick and wipe it with a clean, lint-free cloth. Replace
the dipstick and remove it again to check the oil level.
If the level is at the MIN mark, add oil immediately.
Adding engine oil
Note:Do not remove the filler cap when the engine is running.
Note:Do not add engine oil further than the MAX mark. Oil levels above
the MAX mark may cause engine damage.
Only use oils certified for gasoline engines by the
American Petroleum Institute (API). An oil with this
trademark symbol conforms to the current engine and
emission system protection standards and fuel
economy requirements of the International Lubricants
Specification Advisory Council (ILSAC), comprised of
U.S. and Japanese automobile manufacturers.
1. Remove the filler cap.
2. Add engine oil that meets Ford specifications. SeeCapacities and
Specificationsfor more information.
3. Replace the filler cap. Turn it until you feel a strong resistance.
86Maintenance
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

ENGINE SPECIFICATIONS
Engine 6.8L V10 engine
Cubic inches 415
Required fuel Minimum 87 octane
Firing order 1-6-5-10-2-7-3-8-4-9
Ignition system Coil on plug
Spark plug gap 0.039-0.043 inch (1.00-1.10mm)
Compression ratio 9.2:1
Engine drivebelt routing
Engines with A/C
Engines without A/C
Capacities and Specifications127
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

Item CapacityFord part name or
equivalentFord part number /
Ford specification
Engine oil
3,4
7.0 quarts
(6.6L)MotorcraftSAE 5W-20
Premium Synthetic Blend
Motor Oil (US)
MotorcraftSAE 5W-20
Super Premium Motor Oil
(Canada)XO-5W20-QSP (US)
CXO-5W20-LSP12
(Canada) /
WSS-M2C945-A
Automatic transmission
TorqShift5-speed
5,6
18.2 quarts (17.2L)
Motorcraft
MERCONLV AT FXT-10-QLV /
MERCONLV
WSS-M2C938-A
Power steering fluidKeep in FULL
range on dipstick
Parking brake assemblyFill to bottom of fill
plug holeMotorcraft
MERCONVATFXT-5-QM /
MERCONV
WSS-M2C938-A
Rear axle
7,8
4.0 quarts
(3.9L)
(Dana M80)
MotorcraftSAE 75W-140
Synthetic Rear Axle
LubricantXY-75W140-QL /
WSL-M2C192-A and GL-5 8.0 quarts
(7.6L)
(Dana S110)
7.0 quarts
(6.6L)
(Dana S130)
16.0 quarts (15.1L)
(Dana Spicer
17060S)
Capacities and Specifications129
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

Item CapacityFord part name or
equivalentFord part number /
Ford specification
Transmission
/steering/parking brake
linkages and pivots, brake
and clutch pedal shaft (if
equipped)— Premium Long-Life GreaseXG-1-C /
ESA-M1C75-B
Windshield washer fluid Fill as requiredMotorcraftPremium
Windshield Washer
Concentrate (US)
Premium Quality
Windshield Washer Fluid
(Canada)ZC-32-A (US)
CXC-37-(A, B, D, and F)
(Canada) /
WSB-M8B16-A2 / - -
Fuel tank80 gallons (303L)
Motorhome
——
40 gallons (151L)
Commercial chassis
1Capacity is approximate and will vary due to second-stage manufacturer completion of HVAC system.
Fill to the Cold Fill Level on reservoir.2Add the coolant type originally equipped in your vehicle.3Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C945-A, SAE 5W-20 and display the API Certification Mark.4Your engine has been designed to be used with Ford engine oil, which gives a fuel economy benefit
while maintaining the durability of your engine.
Using oils other than the one specified can result in longer engine cranking periods, reduced engine
performance, reduced fuel economy and increased emission levels.
130Capacities and Specifications
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

MOTORCRAFT PART NUMBERS
Component 6.8L V10 engine
Air filter element FA-1782
Battery BXT-65-750
Oil filter FL-820-S
Spark plugs
1
Transmission fluid filter FT-180
1For spark plug replacement, see your authorized dealer. Refer to
scheduled maintenance informationfor the appropriate intervals for
changing the spark plugs.
Note:Replace the spark plugs with ones that meet Ford material and
design specifications for your vehicle, such as Motorcraftor equivalent
replacement parts. The customer warranty may be void for any damage
to the engine if such spark plugs are not used.
VEHICLE IDENTIFICATION NUMBER
The vehicle identification number is located near the cowl to the right of
the air filter.
If you ever find it necessary to communicate with Ford Motor Company
about your vehicle, always include the VIN in your communication.
The Vehicle Identification Number (VIN) contains the following
information:
A. World manufacturer identifier
B. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
Devices and their location
C. Make, vehicle line, series, body
type
D. Engine type
E. Check digit
F. Model year
G. Assembly plant
H. Production sequence number
132Capacities and Specifications
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

EXCEPTIONS
Normal vehicle axle maintenance:Rear axles and power take-off
(PTO) units with synthetic fluid and light-duty trucks equipped with
Ford-design axles are lubricated for life; do not check or change fluid
unless a leak is suspected, service is required or the assembly has been
submerged in water. During long periods of trailer towing with outside
temperatures above 70°F (21°C) and at wide-open throttle for long
periods above 45 mph (72 km/h), non-synthetic rear axle fluids should
be changed every 3000 miles (4800 kilometers) or three months,
whichever comes first. This interval can be waived if the axle is filled
with 75W140 synthetic gear fluid meeting Ford specification
WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of
Traction-Lok rear axles (refer toTechnical specificationsin the
Capacities and Specificationschapter for details).
California fuel filter replacement:If the vehicle is registered in
California, the California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion of the vehicle’s
useful life. Ford Motor Company, however, urges you to have all
recommended maintenance services performed at the specified intervals
and to record all vehicle service.
Class A Motorhome:Change brake fluid every two years.
Hot climate oil change intervals:Vehicles operating in the Middle
East, North Africa, Sub-Saharan Africa or locations with similar climates
using an American Petroleum Institute (API) Certified for Gasoline
Engines (Certification mark) oil of SM or SN quality, the normal oil
change interval is 5000 miles (8000 kilometers).
If the available API “SM” or “SN” oils are not available, then the oil
change service interval is 3000 miles (4800 kilometers).
Engine air filter replacement:Engine air filter life is dependent on
exposure to dusty and dirty conditions. Vehicles operated in these
conditions require frequent inspection and replacement of the engine air
filter.
Scheduled Maintenance151
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

A
Air cleaner filter .......100–101, 132
Ambulance packages ....................9
Antifreeze
(see Engine coolant) ..................87
Automatic transmission
driving an automatic
overdrive ...................................39
fluid, adding ..............................91
fluid, checking ..........................91
fluid, refill capacities ..............128
fluid, specification ..................128
Axle
lubricant specifications ..........128
refill capacities ........................128
B
Battery .........................................98
acid, treating emergencies .......98
jumping a disabled battery ......64
maintenance-free ......................98
replacement, specifications ...132
servicing ....................................98
Brakes ..........................................44
fluid, checking and
adding ..................................94–95
fluid, refill capacities ..............128
fluid, specifications .................128
lubricant specifications ..........128
shift interlock ............................42
C
Capacities for refilling fluids ....128
Cell phone use ............................10
Changing a tire .........................121
Cleaning your vehicle ...............101
engine compartment ..............101wheels ......................................101
Coolant ........................................87
checking and adding ................87
refill capacities ........................128
specifications ..........................128
Cruise control .............................46
Customer Assistance ..................62
Ford Extended Service
Plan ..................................134, 136
Getting assistance outside
the U.S. and Canada ................70
Getting roadside assistance .....62
Getting the service you need ..67
Ordering additional owner’s
literature ...................................72
Utilizing the
Mediation/Arbitration
Program .....................................70
D
Dipstick
automatic transmission fluid ...91
engine oil ...................................86
Driving under special
conditions ....................................43
through water ...........................61
E
Electronic message center .........22
Emergencies, roadside
jump-starting ............................64
Emergency Flashers ...................63
Emission control system ............36
Engine ........................................127
cleaning ...................................101
coolant .......................................87
fail-safe cooling .........................90
idle speed control .....................98
Index153
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

lubrication specifications .......128
refill capacities ........................128
service points ......................84–85
Engine oil
checking and adding ................86
dipstick ......................................86
filter, specifications ................132
refill capacities ........................128
specifications ..........................128
Event data recording ....................6
Exhaust fumes ............................29
F
Fail safe cooling ..........................90
Fluid capacities .........................128
Fuel
cap .............................................33
capacity ...................................128
choosing the right fuel .............32
filling your vehicle with fuel ....33
filter, specifications ..........97, 132
octane rating .....................32, 127
quality ........................................32
running out of fuel ...................32
safety information relating to
automotive fuels .......................30
Fuses ................................74–75, 79
G
Gas cap (see Fuel cap) ..............33
Gauges .........................................16
H
Hazard flashers ...........................63
Headlamps
flash to pass ..............................13
high beam .................................13I
Ignition .................................28, 127
Information displays ...................22
Inspection/maintenance (I/M)
testing ..........................................38
Instrument panel
cluster ........................................18
J
Jump-starting your vehicle ........64
K
Keys
positions of the ignition ...........28
L
Lamps
headlamps, flash to pass ..........13
Lights, warning and indicator ....18
Loading instructions ...................53
Load limits ...................................48
Lubricant specifications ...........128
Lug nuts ....................................126
M
Message center ...........................22
english/metric button ...............24
system check button ................24
warning messages .....................24
Motorcraftparts ......................132
O
Octane rating ..............................32
154Index
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)