2013 FIAT FREEMONT air conditioning

WARNING!
 Us
e only refrigerants and compressor
lubricants approved by the manufac-
turer for your air conditioning system. Some un-
approved refrigerants are flammable and can
explode, injuring you. Other unapproved refrig-
erants or lubricants can cause the system to fail,
requiring costly repairs.
 The air conditioning system contains refriger-
ant under high pressure.To avoid risk of personal
injury or damage to the system, adding refriger-
ant or any repair requiring lines to be discon-
nected should be done by an experienced techni-
cian.
Refrigerant Recovery And Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product.
However, the manufacturer recommends that air con-
ditioning service be performed by authorized dealer
or other service facilities using recovery and recycling
equipment.
NOTE: Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, com-
pressor oil, and refrigerants. A/C AIR FILTER
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Car maintenance should be done at a
FIAT Dealership. For routine and minor
maintenance operations you wish to
carry out yourself, we do recommend you have
the proper equipment , genuine FIAT spare parts
and the necessary fluids; do not however carry out
these operations if you have no experience.
WARNING!
Do not remove the A/C air filter while
t
he blower is operating or personal in-
jury may result .
The A/C air filter is located in the fresh air inlet behind
the glove box. Perform the following steps to replace
the filter:
1. Open the glove box and remove all contents.
2. Push the retaining tab on each side of the glove box inward while gently pulling the glove box door
outward until both tabs clear the door opening in
the instrument panel. (fig. 177)
3. Pivot the glove box downward.
4. Disengage the two retaining tabs that secure the
298
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
C
ARETECHNICAL
SPECIFICATIONSCONTENTS

 Do not overfill the coolant recovery bottle.
 Check coolant freeze point in the radiator and in thecoolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also
be protected against freezing.
 If frequent coolant additions are required, or if the level in the coolant recovery bottle does not drop
when the engine cools, the cooling system should be
pressure tested for leaks.
 Make sure that the radiator and coolant recovery bottle overflow hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air conditioning, keep the front of the
condenser clean.
 Do not change the thermostat for Summer or Win- ter operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs
may result in unsatisfactory coolant performance,
poor gas mileage, and increased emissions.
BRAKE SYSTEM
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake fail-
ure
and possibly an accident . Driving
with your foot resting or riding on the brake
pedal can result in abnormally high brake tem-
peratures, excessive lining wear, and possible
brake damage.You would not have your full brak-
ing capacity in an emergency.Car maintenance should be done at a
FIAT Dealership. For routine and minor
maintenance operations you wish to
carry out yourself, we do recommend you have
the proper equipment , genuine FIAT spare parts
and the necessary fluids; do not however carry out
these operations if you have no experience.
Master Cylinder – Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the “Brake Warning Light” indicates system failure.
Check the fluid level in the master cylinder when
performing underhood services.
Clean the top of the master cylinder area before
removing the cap. If necessary, add fluid to bring the
fluid level up to the requirements described on the
brake fluid reservoir.
307
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the
fabric. Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car
to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
CLEANING THE CUP HOLDERS
Clean with a damp cloth or towel using a mild deter-
gent.VEHICLE STORAGE
If you will not be using your vehicle for more than 21
days, you may want to take steps to preserve your
battery.
 Disengage the mini-fuse in the Power Distribution
Center labeled IOD (Ignition Off-Draw).
 Or disconnect the negative cable from the battery.
 Anytime you store your vehicle, or keep it out of service (i.e., vacation) for two weeks or more, run
the air conditioning system at idle for about five
minutes in the fresh air and high blower setting. This
will ensure adequate system lubrication to minimize
the possibility of compressor damage when the sys-
tem is started again.
314
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
C
ARETECHNICAL
SPECIFICATIONSCONTENTS

CONTENTS
About Your Brakes. . . . . . . . . . . . . . . . . . . . . .118, 207
ABS (Anti-Lock Brake System) . . . . . . . . . .119, 120, 243
Adding Engine Coolant (Antifreeze) . . . . . . . . . . . . . .305
Adding Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .163
Adding Washer Fluid . . . . . . . . . . . . . . . . . . . . . . . .301
Additives, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . .326
Airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .187, 194
Airbag Deployment . . . . . . . . . . . . . . . . . . . . . . . .195
Airbag Light. . . . . . . . . . . . . . . . . . . .193, 196, 199, 239
Airbag, Side . . . . . . . . . . . . . . . . . . . . . . .189, 192, 194
Airbag, Window (Side Curtain) . . . . . . . . . .190, 192, 194
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . . . .296
Air Conditioner Maintenance . . . . . . . . . . . . . . . . . .297
Air Conditioning Filter . . . . . . . . . . . . . . . . . . . .73, 298
Air Conditioning, Operating Tips . . . . . . . . . . . . . . . .74
Air Conditioning, Rear Zone . . . . . . . . . . . . . . . . . . .70
Air Conditioning Refrigerant . . . . . . . . . . . . . . .297, 298
Air Conditioning System . . . . . . . . . . . . . . . . . . .68, 297
Air Pressure, Tires . . . . . . . . . . . . . . . . . . . . . .241, 317
Alarm (Security Alarm). . . . . . . . . . . . . . . . . . . .15, 244
Alarm System (Security Alarm) . . . . . . . . . . . . . . .15, 17
All Wheel Drive (AWD) . . . . . . . . . . . . . . . . . . . . .222
Alterations/Modifications, Vehicle . . . . . . . . . . . . . . . . .5
Antifreeze (Engine Coolant) . . . . . . . . . . . .304, 305, 327 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . .306
Anti-Lock Brake System (ABS) . . . . . . . . . . . . . .119, 120
Anti-Lock Warning Light . . . . . . . . . . . . . .120, 121, 243
Anti-Theft Security Alarm (Theft Alarm) . . . . . . . . . . .15
Anti-Theft System . . . . . . . . . . . . . . . . . . . . . . . . .244
Arming Theft System (Security Alarm) . . . . . . . . . . . . .15
Auto Down Power Windows . . . . . . . . . . . . . . . . . .109 Automatic Dimming Mirror . . . . . . . . . . . . . . . . . . . .60
Automatic Door Locks . . . . . . . . . . . . . . . . . . . . . .102
Automatic Headlights . . . . . . . . . . . . . . . . . . . . . . . .75
Automatic Oil Change Indicator . . . . . . . . . . . . . . . . .25
Automatic Temperature Control (ATC) . . . . . . . . . . . .68
Automatic Transmission . . . . . . . . . . . . . . . . . .211, 308
Adding Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . .309
Fluid and Filter Changes . . . . . . . . . . . . . . . . . . .309
Fluid Level Check . . . . . . . . . . . . . . . . . . . . . . .309
Gear Ranges . . . . . . . . . . . . . . . . . . . . . . .213, 217
Auto Unlock, Doors . . . . . . . . . . . . . . . . . . . . . . . .102
Auxiliary Electrical Outlet (Power Outlet) . . . . . . . . . .94
Auxiliary Power Outlet . . . . . . . . . . . . . . . . . . . . . . .94
Back-Up Lights. . . . . . . . . . . . . . . . . . . . . . . . . . . .268
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .296 Gas Caution . . . . . . . . . . . . . . . . . . . . . . . . . . .297
Keyless Transmitter Replacement (RKE) . . . . . . . . .13
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . .296
Belts, Seat . . . . . . . . . . . . . . . . . . . . . . . . . . .167, 199
Body Mechanism Lubrication . . . . . . . . . . . . . . . . . .299
Booster Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . .181
Brake Assist System . . . . . . . . . . . . . . . . . . . . . . . .122
Brake Control System, Electronic . . . . . . . . . . . . . . .120
Brake, Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . .207
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118, 307
Brake System . . . . . . . . . . . . . . . . . . . . . . . . .118, 307
Anti-Lock (ABS) . . . . . . . . . . . . . . . . . . . . .119, 120
Fluid Check . . . . . . . . . . . . . . . . . . . . . . . . . . .307
Master Cylinder . . . . . . . . . . . . . . . . . . . . . . . .307
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .207
333
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Exhaust Gas Caution . . . . . . . . . . . . . . . . .111, 199, 303
Exhaust System . . . . . . . . . . . . . . . . . . . . . . . . . . .199
Exterior Folding Mirrors . . . . . . . . . . . . . . . . . . . . . .62
Exterior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . .75
Exterior Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . .201
Fabric Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .312
Filler Location Fuel . . . . . . . . . . . . . . . . . . . . . . . . .163
FiltersAir Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . .296
Air Conditioning . . . . . . . . . . . . . . . . . . . . .73, 298
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . .328
Engine Oil Disposal . . . . . . . . . . . . . . . . . . . . . .296
Flashers Hazard Warning . . . . . . . . . . . . . . . . . . . . . . . . .89
Turn Signal . . . . . . . . . . . . . . . . . . . . . .77, 201, 240
Flash-To-Pass . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77
Flooded Engine Starting. . . . . . . . . . . . . . . . . . . . . .204
Floor Console . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
Fluid Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . .327
Fluid Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .201
Fluid Level Checks Automatic Transmission . . . . . . . . . . . . . . . . . . .309
Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .307
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . .304
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . .294, 295
Manual Transmission . . . . . . . . . . . . . . . . . . . . .309
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . .128
Fluids, Lubricants and Genuine Parts . . . . . . . . . . . . .328
Fog Lights . . . . . . . . . . . . . . . . . . . . . .76, 240, 266, 267
Fog Light Service . . . . . . . . . . . . . . . . . . . . . . .266, 267
Fog Lights, Rear. . . . . . . . . . . . . . . . . . . . . . . .244, 267
Folding Rear Seat . . . . . . . . . . . . . . . . . . . . . . . .52, 57 Freeing A Stuck Vehicle . . . . . . . . . . . . . . . . . . . . . .276
Fuel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .324, 327
Adding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .163
Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . .326
Conserving . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . .327, 328
Ethanol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .324
Filler Cap (Gas Cap) . . . . . . . . . . . . . . . . . . . . .163
Gasoline . . . . . . . . . . . . . . . . . . . . . . . . . . . . .324
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23
Octane Rating . . . . . . . . . . . . . . . . . . . . . .324, 328
Requirements . . . . . . . . . . . . . . . . . . . . . . . . . .324
Saver Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . .328
Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . .327
Fueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .163
Fuel Optimizer . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Fuel Saver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Fuel System Caution . . . . . . . . . . . . . . . . . . . . . . . .164
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .271
Gas Cap (Fuel Filler Cap) . . . . . . . . . . . . . . . . .127, 163
Gas Gauge (Fuel Gauge) . . . . . . . . . . . . . . . . . . . . . . .7
Gasoline, Clean Air . . . . . . . . . . . . . . . . . . . . . . . .325
Gasoline (Fuel) . . . . . . . . . . . . . . . . . . . . . . . . . . .324 Conserving . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Gauges Coolant Temperature . . . . . . . . . . . . . . . . . . . . . .7
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Gear Ranges . . . . . . . . . . . . . . . . . . . . . . . . . .213, 217
336
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Recommendation . . . . . . . . . . . . . . . . . . . . . . .327
Viscosity . . . . . . . . . . . . . . . . . . . . . . .295, 296, 327
Onboard Diagnostic System . . . . . . . . . . . . . . . . . . .126
Operating Precautions . . . . . . . . . . . . . . . . . . . . . .126
Operator Manual (Owner's Manual) . . . . . . . . . . . . . . .4
Outside Rearview Mirrors . . . . . . . . . . . . . . . . . . . . .60
Overhead Console . . . . . . . . . . . . . . . . . . . . . . . . . .87
Owner's Manual (Operator Manual) . . . . . . . . . . . . . . .4
Paint Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .311
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . .207
Park Sense System, Rear . . . . . . . . . . . . . . . . . . . . .136
Passenger Seat Back Tilt (Easy Entry System) . . . . . . . .55
Passing Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77
Pets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .197
Power Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118
Distribution Center (Fuses) . . . . . . . . . . . . . . . .272
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . .102
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61
Outlet (Auxiliary Electrical Outlet) . . . . . . . . . . . .94
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43
Steering . . . . . . . . . . . . . . . . . . . . . . . . . .127, 128
Sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98
Transfer Unit . . . . . . . . . . . . . . . . . . . . . . . . . .310
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108
Power Transfer Unit . . . . . . . . . . . . . . . . . . . . . . . .310
Pregnant Women and Seat Belts . . . . . . . . . . . . . . . .176
Preparation for Jacking . . . . . . . . . . . . . . . . . . . . . .248
Pretensioners Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . .171
Programming Transmitters (Remote Keyless Entry) . . . .12 Radial Ply Tires . . . . . . . . . . . . . . . . . . . . . . . . . . .318
Radiator Cap (Coolant Pressure Cap) . . . . . . . . . . . .306
Radio Operation . . . . . . . . . . . . . . . . . . . . . . . . . .163
Radio Remote Controls. . . . . . . . . . . . . . . . . . . . . .144
Radio (Sound Systems) . . . . . . . . . . . . . . . . . . . . . .143
Rear Air Conditioning. . . . . . . . . . . . . . . . . . . . . . . .70
Rear Axle (Differential) . . . . . . . . . . . . . . . . . . . . . .310
Rear Camera . . . . . . . . . . . . . . . . . . . . . . . . . . . . .141
Rear Cupholder . . . . . . . . . . . . . . . . . . . . . . . . . . . .97
Rear Drive Assembly . . . . . . . . . . . . . . . . . . . . . . .310
Rear Fog Lights . . . . . . . . . . . . . . . . . . . . . . . . . . .244
Rear Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111
Rear Park Sense System. . . . . . . . . . . . . . . . . . . . . .136
Rear Seat, Folding . . . . . . . . . . . . . . . . . . . . . . . .52, 57
Rearview Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . .60
Rear Window Defroster . . . . . . . . . . . . . . . . . . . . . .84
Rear Window Features . . . . . . . . . . . . . . . . . . . . . . .83
Rear Wiper/Washer . . . . . . . . . . . . . . . . . . . . . . . . .83
Reclining Front Seats . . . . . . . . . . . . . . . . . . . . . . . .47
Reclining Rear Seats. . . . . . . . . . . . . . . . . . . . . . .54, 57
Recreational Towing . . . . . . . . . . . . . . . . . . . . . . . .236
Refrigerant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .298
Release, Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . .116
Reminder, Lights On . . . . . . . . . . . . . . . . . . . . . . . . .76
Reminder, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . .176
Remote Keyless Entry (RKE) . . . . . . . . . . . . . . . . . . .12
Remote Sound System (Radio) Controls . . . . . . . . . . .144
Repeater Lights, Side. . . . . . . . . . . . . . . . . . . . . . . .268
Replacement Bulbs . . . . . . . . . . . . . . . . . . . . . . . . .264
Replacement Keys . . . . . . . . . . . . . . . . . . . . . . . . . .11
Replacement Tires . . . . . . . . . . . . . . . . . . . . . . . . .322
Resetting Oil Change Indicator . . . . . . . . . . . . . .25, 240
Restraint, Head . . . . . . . . . . . . . . . . . . . . . . . . . . . .49
340
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS