2013 CITROEN NEMO battery

136



Battery



Models with Stop & Start



A.
Protective cover.

B.
Positive metallic point on your vehicle.

C.
Slave battery.

D.
Earth on your vehicle.

E.
Terminal release button.

F.
Check sensor button.

G.
State of charge sensor.

H.
Metal negative point of your vehicle.
Charging the battery using a battery charger
- Follow the instructions for use given by
the battery charger manufacturer.

- Check that the battery posts and
terminals are clean. If they are covered
with sulphate (white or greenish deposit),
disconnect them and clean them.

- Reconnect connector F
of the check
sensor G
.

- Refit the protective cover A
to the
metallic point B
.

Starting using another battery


- Remove the protective cover A
from the
metallic point B
.

- Connect the red cable to metallic point B
,
then the (+) terminal to the slave battery C
.

- Connect one end of the green or black
cable to the (-) terminal of the slave
battery C
.

- Connect the other end of the green or
black cable to the earth point D
of your
vehicle (never to the metallic point H
of
your vehicle).

- Operate the starter, let the engine run.

- Wait for the engine to return to idle, then
disconnect the cables.

- Refit the protective cover A
to the
metallic point B
.



Do not disconnect the battery to charge it.


- Press the release button E
to disconnect
the terminal F
.

- Disconnect the connector F
of the check
sensor G
.

- Remove the protective cover A
from the
metallic point B
.

- Connect the charger cables: (+) on the
metallic point B
; (-) on the metallic point H
. Never remove the check sensor G
from the metallic point H
, except
when replacing the battery.

137
7
QUICK HELP



Battery


Batteries contain harmful substances
such as sulphuric acid and lead. They
must be disposed of in accordance with the
law and must not, in any circumstances be
discarded with household waste.
Take used batteries to an authorised waste
disposal site.

It is advisable to disconnect the battery
if the vehicle is not to be used for a
period of more than one month. To do
this on models with Stop & Start:


- press the release button E
to disconnect
connector F
,

- disconnect connector F
of check sensor G
.
Never remove the check sensor G
from the
metallic point H
, except when replacing the
battery.





The presence of this label, in particular
with the Stop & Start system, indicates
the use of a 12 V lead-acid battery with
special technology and specification;
the involvement of a CITROËN dealer or
a qualified workshop is essential when
replacing or disconnecting the battery.
Failure to observe this recommendation may
cause premature wear of the battery.

After refitting the battery by a
CITROËN dealer or a qualified
workshop, the Stop & Start system will
only be active after a continuous period of
immobilisation of the vehicle, a period which
depends on the climatic conditions and the
state of charge of the battery (up to about
8 hours).
Before charging

The charging operation must be carried out in a
ventilated area away from naked fl ames or any
possible sources of sparks to eliminate the risks of
explosion and fi re.
Do not attempt to charge a frozen battery: it must fi rst
be thawed to eliminate the risks of explosion. If the
battery has frozen, before charging it have it checked
by a specialist who will check that the internal
components have not been damaged and that the
container is not cracked, which could mean that
there is a risk of a leak of toxic and corrosive acid.


Before disconnecting
Never disconnect a terminal when the engine is
running.
Before disconnecting the battery, you must wait
for 2 minutes after switching off the ignition.
Close the windows and doors before
disconnecting the battery.
After reconnecting
After every reconnection of the battery,
switch on the ignition and wait 1 minute
before starting to allow the electronic
systems to be initialised. If difficulties are
experienced after this, contact a CITROËN
dealer or a qualified workshop.
If the battery has been disconnected
for some time, it may be necessary to
reinitialise the following functions:


- the display parameters (date, time,
language, distance and temperature
units),

- the radio stations,

- the central locking.
Some settings are cleared and must be
reprogrammed. Contact a CITROËN dealer
or a qualified workshop.

153
7
QUICK HELP



Changing a fuse



Marking


Rating


Functions


F16
7.5 A Engine management control unit - electronic gearbox control unit and gear lever -
T20 relay coil

F17
15 A Supply for ignition coil - injectors - engine management control unit (1.3 HDi)

F18
7.5 A Engine management control unit (1.3 HDi) - T09 relay coil

F19
7.5 A Air conditioning compressor

F20
30 A Supply for heated rear screen, electric door mirrors heater elements

F21
15 A Fuel pump (1.4 petrol and 1.3 HDi)

F22
20 A Engine management control unit (1.3 HDi)

F23
20 A ABS hydraulic block electrovalves supply

F24
7.5 A ABS

F30
15 A Foglamps

F81
60 A Pre-heat unit (1.3 HDi)

F82
30 A Electronic gearbox pump - electronic gearbox supply

F84
10 A Electronic gearbox control unit and electrovalves

F85
30 A Cigar lighter - 12 V accessory socket

F87


7.5 A Reversing lamps - water in Diesel sensor - airflow sensor - T02, T05, T14, T17 and T19 relay coils
(except 1.3 HDi)

5 A Reversing lamps - water in Diesel sensor - airflow sensor - T02, To5, T14, T17 and T19 relay coils -
battery state of charge sensor (except 1.3 HDi)

156



Fuel


FILLING WITH FUEL

Capacity of the fuel tank: approximately 45 litres.


Low fuel level

When the minimum fuel tank level
is reached, this warning lamp
comes on. When it first comes on,
you have approximately 6
litres
of fuel remaining. Refuel without delay to
avoid running out of fuel. Refuelling must be done with the engine off.


- Open the fuel filler flap.

- Hold the filler cap with one hand.

- With the other hand, insert the key, then
turn it a third of a turn.

- Remove the filler cap and hang it on the
hook, located on the inside of the filler
flap.

FUEL CIRCUIT DEACTIVATED

In the event of a serious collision, a device
automatically cuts off the fuel supply to the
engine and the vehicle's electrical supply.
It also triggers the automatic unlocking of
the doors and switching on of the courtesy
lights. A message appears on the instrument
panel display according to version.
Turn the key to the STOP position to prevent
discharging of the battery.
Check that there is no smell or leak of fuel
outside the vehicle.






With Stop & Start, never refuel with the
system in STOP mode; you must switch
off the ignition with the key.
When the fuel filler flap is open, a
safety system prevents sliding of the
side door (Combi).
A label affixed to the inside of the flap
reminds you of the type of fuel to be used.
Opening the filler cap may cause a noise
resulting from the inrush of air. This vacuum
is quite normal and results from the sealing
of the fuel system.
When filling the fuel tank, do not continue
after the 3rd cut-off of the nozzle; this could
cause malfunctions.
After filling the fuel tank, lock the filler cap
and close the flap.

164



Checks


CHECKS


Bleeding water from
the Diesel filter

If this warning lamp comes
on, you must bleed the filter;
otherwise bleed the filter
regularly, every time the engine is
changed.
To remove the water, unscrew the bleed
screw or the water in Diesel sensor, located
at the base of the filter. Operate until all of
the water has flowed out. Then tighten the
bleed screw or the water sensor.
HDi engines use advanced technology. All
work requires specialist knowledge, which
all CITROËN dealers have.


Battery

At the start of winter, have your battery
checked by a CITROËN dealer or a qualified
workshop.


Air filter and passenger compartment filter

A blocked passenger compartment filter
may reduce the performance of the
air conditioning system and generate
undesirable odours. The replacement
intervals for these components are indicated
in the servicing booklet.
Depending on the environment (dusty
atmosphere...) and the use of the vehicle
(urban driving...), change them twice as
often if necessary, refer to the "Under the
bonnet" section of chapter 7.


Brake pads

Brake pad wear depends on the style of
driving, in particular for vehicles which are
used in town, over short distances. It may
be necessary to check the brake pad wear,
even between services.
Unless there is a leak on the system, a drop
in the brake fluid level indicates that the
brake pads are worn.


Brake disc/drum wear

For all information on checking the brake
disc/drum wear, contact a CITROËN dealer
or a qualified workshop.


Parking brake

Where the parking brake travel is too great
or there is a reduction in the performance
of the system, the parking brake should be
adjusted, even between services.
Have the system checked by a CITROËN
dealer or a qualified workshop.


Oil filter

Change the filter regularly, in accordance
with the servicing schedule.





The presence of this label, in particular with
the Stop & Start system, indicates the use
of a specific 12 V lead-acid battery with
special technology and specification, for
which the involvement of a CITROËN dealer
or a qualified workshop is required when
replacing or disconnecting the battery.
Failure to observe this recommendation may
shorten the life of the battery.

167
8
VISUAL SEARCH



Exterior



EXTERIOR (LIGHT VAN)

Right-hand side:
fuel fi ller cap, fuel tank ................... 156
fuel cut-off ...............................156-157
Load space .............................108-109
Rear doors ......................31, 33, 36-40
Opening/Closing to 180° ........... 37, 39
Rear lamps, direction indicators,
3rd brake lamp ......... 41-42, 146-147

Number plate lamps ...................... 146
Rear parking assistance ..................72
Spare wheel, changing a wheel,
tools .................................... 138-140
Towing, lifting .................................154
Towbar ................................... 131-132
Dimensions ................................ 58-59

Brakes, pads........................ 162, 164
Hill start assist ............................... 54
Braking assistance ................114-115
Trajectory control ...................115-117
Tyres, pressures .......................... 155
Accessories ............................133-134
Roof rack ....................................... 133

Key, remote control, battery ....... 31-33
Central locking .................... 31, 37, 39
Opening/Closing front windows ...... 32
Confi dential card............................. 34
Alarm .............................................. 35
Wiper blades................................. 148
Door mirrors .................................... 46
Side repeater ................................ 145

Front lamps, foglamps, direction
indicators ................. 41-42, 143-145
Headlamp beam height adjustment ... 42
Changing bulbs.......................143-147
Opening/Closing doors ...31, 33, 36-40
Opening the bonnet ....................... 159
Menu - autoclose ................. 37, 39, 70

168



Exterior



EXTERIOR (COMBI)

Accessories ............................133-134
Roof bars ....................................... 133
Key, remote control, battery ........31-33
Central locking ..................... 31, 37, 39
Opening/Closing front windows ....... 32
Confi dential card.............................. 34
Alarm ............................................... 35
Wiper blades.................................. 148
Door mirrors ..................................... 46
Side repeater ................................. 145

Front lamps, fog amps, direction
indicators ................. 41-42, 143-145
Headlamp beam height adjustment ... 42
Changing bulbs.......................143-147
Opening/Closing doors ...31, 33, 36-40
Child lock ......................................... 40
Rear windows .................................. 47
Opening the bonnet ....................... 159
Menu - autoclose ................. 37, 39, 70 Dimensions ................................ 60-63

Brakes, pads......................... 162, 164
Hill start assist ................................ 54
Braking assistance .................114-115
Trajectory control ....................115-117
Tyres, pressures ................... 142, 155 Right-hand side:
fuel fi ller cap, fuel tank .................. 156
fuel cut-off .............................. 156-157
Rear fi ttings ............................110-111
Rear doors ..................... 31, 33, 36-40
Opening/closing to 180° ........... 37, 39
Rear lamps, direction indicators,
3rd brake lamp .........41-42, 146-147
Number plate lamps ..................... 146
Rear parking sensors ..................... 72
Spare wheel, changing a wheel,
tools, temporary puncture
repair kit ...............138-140, 141-142
Towing, lifting ................................ 154
Towbar ................................... 131-132

169
8
VISUAL SEARCH



Interior


INTERIOR (LIGHT VAN)

Rear view mirror ..............................46
Front courtesy lamp ....................... 112
Changing a courtesy
lamp bulb ....................................145
Folding seat ..................................... 97
Child seats ......................124-126, 128
12 V socket .................................... 106
Parking brake ................................ 113 Battery (+), charging,
starting .................................135-137
Seat belts................................ 118-119
Airbags ...................................120-123

Deactivating the passenger’s airbag .....122
Seats, adjustments .....................95-96
Tools, jack ...................................... 138
Load space ............................ 108-109


●
stowing rings,

●
storage tray,

●
torch,

●
vertical partition.
Rear courtesy lamp ....................... 112
Accessories ........................... 133-134