2012 VOLVO V60 sensor

08 Maintenance and service
Engine compartment
08
314
Volvo recommends Castrol oil products.
When driving under adverse conditions, see
page 359.
IMPORTANT
In order to fulfil the requirements for the
engine's service intervals all engines are
filled with a specially adapted synthetic
engine oil at the factory. The choice of oil
has been made very carefully with regard to
service life, starting characteristics, fuel
consumption and environmental impact.
An approved engine oil must be used in
order that the recommended service inter-
vals can be applied. Only use a prescribed
grade of oil for both filling and oil change,
otherwise you will risk affecting service life,
starting characteristics, fuel consumption
and environmental impact.
Volvo Car Corporation disclaims all war-
ranty liability if engine oil of the prescribed
grade and viscosity is not used.
Volvo recommends that oil changes are car-
ried out at an authorised Volvo workshop.
Volvo uses different systems for warning of
low/high oil level or low/high oil pressure. Cer-
tain variants have an oil pressure sensor, and
then the lamp for oil pressure is used. Other
variants have an oil level sensor, and then thedriver is informed via the warning symbol in the
centre of the instrument unit as well as by dis-
play texts. Certain models have both variants.
Contact a Volvo dealer for more information.
Change the engine oil and oil filter in accord-
ance with the intervals specified in the Service
and Warranty Booklet.
Using oil of a higher than specified grade is
permitted. If the car is driven in adverse con-
ditions, Volvo recommends using an oil of a
higher grade, see page 359.
For capacities, see page 360 and onwards.
Engine with oil dipstick2
G021734
Dipstick and filler pipe.
Checking the oil level in a new car is especially
important before the first scheduled oil change.
Volvo recommends checking the oil level every
2 500 km. The most accurate measurements
are made on a cold engine before starting. The
measurement will be inaccurate if taken imme-
diately after the engine is switched off. The
dipstick will indicate that the level is too low
because the oil has not had time to flow down
into the oil sump.
G021737
The oil level must be between the MIN and MAX
marks.
Measurement and filling if required1. Ensure that the car is level. After switching
off the engine it is important to wait
2Only applies to petrol and 4-cyl. diesel.
ProCarManuals.com

08 Maintenance and service
Engine compartment
08
315
5 minutes to allow the oil time to run back
to the sump.
2. Pull up and wipe the dipstick.
3. Re-insert the dipstick.
4. Pull it out and check the level.
5.
If the level is close to MIN then 0.5 litres
should be added. If the level is significantly
below, then an additional amount is
required.
6. If required, check the level again, do it after
driving a short distance. Then repeat steps
1 - 4.
WARNING
Never fill above the MAX mark. The level
should never be above MAX or below MIN
as this could lead to engine damage.
WARNING
Do not spill oil onto the hot exhaust manifold
due to the risk of fire.
Engine with electronic oil level sensor3
Filler pipe.4
You do not need to take action with respect to
the engine oil level before a message is shown
in the display, see the illustration below.
Message and graph in the display.
Message
Engine oil level
The oil level is checked using the electronic oil
level gauge with the thumbwheel when the
engine is switched off,see page 142.
WARNING
If the message Oil service required is
shown, visit a workshop. The oil level may
be too high.
3Only applies to 5-cyl. diesel.4Engines with electronic oil level sensor have no dipstick (5-cyl. diesel).
ProCarManuals.com

08 Maintenance and service
Fuses
08
336* Option/accessory, for more information, see Introduction.
FunctionA
Relay coil, relay, vacuum pump
(5-cyl. petrol)5
Headlamp control5
--
--
--
Internal relay coils5
Auxiliary lamps*20
Horn15
Relay coil, main relay, engine
management system, Engine
control module (5, 6-cyl. petrol)10
Transmission control module15
Compressor A/C (not 5-cyl. die-
sel), Coolant pump (5-cyl. diesel
Start/Stop)15
FunctionA
Relay coil, relay, compressor A/
C (not 5-cyl. diesel), Relay coil,
relay, coolant pump (5-cyl. die-
sel Start/Stop)
Relay coils in central electrical
unit in engine compartment cold
zone Start/Stop5
Actuator solenoid, starter
motorA30
Ignition coils (4-cyl. petrol),
Glow control module (5-cyl. die-
sel)10
Ignition coils (5, 6-cyl. petrol),
Capacitor (6-cyl.)20
Engine control module (petrol)10
Engine control module (diesel)15
FunctionA
Valves (1.6 l petrol), Mass air
flow sensor (1.6 l petrol)
Mass air flow sensor (D4162T),
Control valve, fuel flow
(D4162T)10
Mass air flow sensor (5, 6-cyl.),
Control valves (5-cyl. diesel),
Injectors (5, 6-cyl. petrol),
Engine control module (6-cyl.)15
Compressor A/C (5, 6-cyl.),
Engine valves, Engine control
module (6-cyl.) Solenoids (6-cyl.
without turbo), Actuator motors,
intake manifold (6-cyl. without
turbo), Mass air flow sensor (4-
cyl. 2.0 l petrol), Oil level sensor
(5-cyl. diesel)
Coolant pump (D4162T)10
Lambda-sonds (4-cyl. petrol),
Lambda-sond (diesel), Control
module, radiator roller cover
(manual 5-cyl. 2.0 l diesel)10
EVAP valve (5, 6-cyl. petrol),
Lambda-sonds (5, 6-cyl. petrol)15
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.339
Box AFunctionA
Folding head restraint*15
Infotainment control module5
Audio control module*
Digital radio*, TV*10
Audio15
Telematics*, Bluetooth*5
--
Sun roof*, Interior lighting
roof, Climate sensor5
12 V socket, tunnel console15
Seat heating, rear right*15
Seat heating, rear left*15
--
Seat heating (passenger
side)15
Seat heating (driver's side)15
Box AFunctionA
Parking assistance*, Park-
ing camera*, Towbar control
module *
BLIS*5
AWD control module*10
Active chassis Four-C*10
Box BFunctionA
Rear window wiper15
--
Interior lighting, Driver's
door control panel, power
windows, Power seats,
front*, Remote controlled
garage door opener*7.5
Information display (DIM)5
Adaptive cruise control,
ACC*, collision warning sys-
tem*10
Interior lighting, Rain sensor7.5
Steering wheel module7.5
Box BFunctionA
Central locking system, fuel
filler flap10
Rear window washer15
Windscreen washers15
Unlocking, tailgate10
--
Fuel pump20
Climate panel5
Steering lock15
Siren alarm*, Data link con-
nector OBDII5
--
Airbags10
Collision warning system5
Accelerator pedal, PTC ele-
ment air preheater*, Dim-
ming, interior rearview mir-
ror*, Seat heating, rear*7.5
ProCarManuals.com

09 Specifications
Symbols in the display09

* Option/accessory, for more information, see Introduction.383
SymbolMeaningPage
Left-hand direc-
tion indicators74
Right-hand
direction indica-
tors74
DRIVe - Start/
Stop*74, 123, 127
Other information symbols in the
combined instrument panel
SymbolMeaningPage
Adaptive cruise
control*171,
177, 183
Adaptive cruise
control*183
Adaptive cruise
control*, Distance
Warning* (Distance
Alert)183, 186
Adaptive cruise
control*, Distance
Warning* (Distance
Alert)183, 186
SymbolMeaningPage
Adaptive cruise
control*183
Adaptive cruise
control*, Distance
Warning* (Distance
Alert)178, 185
Adaptive cruise
control*, Distance
Warning* (Distance
Alert)178, 185
Adaptive cruise
control*177
Radar sensor*183,
186, 197
Start/Stop*, Adap-
tive cruise control*127, 183
Speed limiter173
SymbolMeaningPage
Camera sensor*,
Laser sensor*191,
197,
201, 203
Auto Brake*, Dis-
tance Warning*
(Distance Alert), City
Safety
TM, Collision
warning system*
186,
191, 197
G025102
Fuel-driven engine
block heater and
passenger com-
partment heater*163
ABL system*89
Fuel filler flap, right-
hand side273
Low battery163
Parking brake135
Rain sensor*97
ProCarManuals.com

10 Alphabetical Index
10
386
A
ACC – Adaptive cruise control................. 175
Active Bending Lights (ABL)...................... 89
Active chassis – FOUR-C........................170
Active Xenon headlamps........................... 89
Adaptation............................................... 115
Adapting driving characteristics.............. 170
Adaptive cruise control............................ 175
fault tracing......................................... 182
radar sensor........................................ 181
Adaptive cruise control fault tracing........ 182
Additional heater (Diesel)......................... 165
Adjusting headlamp pattern...................... 93
halogen headlamp................................ 94
Adjusting the steering wheel...................... 87
Airbag
activating/deactivating, PACOS........... 22
driver's and front passenger side......... 20
key switch off........................................ 22
AIRBAG ..................................................... 20
Airbag system ........................................... 19
Air conditioning........................................ 159
general................................................ 152Air conditioning, AC................................. 159
Air distribution.................................. 154, 161
Air quality system IAQS .......................... 159
Air vents................................................... 154
Alarm.......................................................... 65
alarm indicator...................................... 65
alarm signals......................................... 66
arming................................................... 65
checking the alarm............................... 49
deactivate............................................. 65
deactivating a triggered alarm.............. 66
reduced alarm level.............................. 66
Alcolock................................................... 108
Allergy and asthma inducing sub-
stances.................................................... 153
All-wheel drive, AWD............................... 130
All Wheel Drive (AWD).............................. 130
Approach light, duration......................48, 93
Audio
settings....................................... 226, 227
surround.....................................220, 227
audio system .......................................... 222
Audio system........................................... 220
functions............................................. 226
overview.............................................. 222Audio volume .......................................... 223
phone.................................................. 254
phone/media player............................ 254
ring signal, phone............................... 254
Auto
climate control settings...................... 158
Automatic car washes.............................344
Automatic gearbox.................................. 117
manual gear positions (Geartronic)..... 118
towing and recovery........................... 289
trailer................................................... 284
Automatic locking...................................... 61
Automatic relocking................................... 59
Auxiliary heater........................................ 165
AUX input......................................... 222, 240
AWD, All-wheel drive............................... 130
B
Backrest..................................................... 82
front seat, lowering............................... 82
Backrest rear seat, lowering...................... 85
Bag holder .............................................. 279
ProCarManuals.com

10 Alphabetical Index
10
387
Battery.............................................327, 369
maintenance....................................... 327
remote control ................................... 250
remote control key/PCC....................... 53
start assistance................................... 116
symbols on the battery....................... 328
warning symbols................................. 328
Bioethanol E85........................................ 275
Blind spot (BLIS)...................................... 211
Blind Spot Information System, BLIS...... 211
Bluetooth
Ÿ
handsfree ........................................... 251
media ................................................. 243
microphone off ..................................253
streaming audio ................................. 243
transfer call to mobile ........................ 253
Bonnet, opening...................................... 312
Brake and clutch fluid..............................317
Brake light.................................................. 90
Brakes...................................................... 131
anti-lock braking system, ABS........... 131
brake light............................................. 90
brake system...................................... 131
electric parking brake......................... 133
Emergency Brake Assistance, EBA ... 131
emergency brake lights........................ 90filling brake fluid.................................. 318
symbols in the combined instrument
panel...................................................132
Bulbs, see Lighting.................................. 319
C
Calls
incoming............................................. 253
operation............................................. 253
Camera sensor................................189, 195
Car care................................................... 344
Car care, leather upholstery.................... 346
Cargo area
cargo cover......................................... 281
lighting.................................................. 92
loading................................................278
mounting points.................................. 279
safety grille.......................................... 281
safety net............................................ 280
Cargo cover............................................. 281
Car upholstery......................................... 346
Car wash.................................................. 344
Catalytic converter................................... 274
recovery..............................................290CD ........................................................... 236
Centre console........................................ 144
Chassis settings......................................170
Checking and topping up the coolant..... 316
Checking the engine oil level................... 313
Children..................................................... 31
child safety locks.................................. 38
child seats and side airbags................. 24
location in the car.................................31
safety.................................................... 31
Child safety locks...................................... 64
Child seat................................................... 31
Child seats................................................. 31
integrated two-stage booster cushion. 36
ISOFIX fixture system for child seats. . . 38
recommended...................................... 33
size classes for child seats with the ISO-
FIX fixture system................................. 38
upper mounting points for child seats. . 42
Cigarette lighter socket............................ 216
City Safety™............................................ 188
Cleaning
automatic car washes......................... 344
car wash............................................. 344
rims..................................................... 345
ProCarManuals.com

10 Alphabetical Index
10
388
seatbelts............................................. 347
upholstery........................................... 346
Clean Zone Interior Package (CZIP)........ 153
Climate control........................................ 152
general................................................ 152
sensors............................................... 152
Clock, setting............................................. 78
CO
2 emissions ........................................ 363
Collision..................................................... 30
Collision warning.............................192, 193
Collision warning system
radar sensor........................ 181, 188, 193
Collision Warning with Auto Brake*......... 192
Colour code, paint................................... 348
Combined instrument panel.................... 142
Comfort inside the passenger compart-
ment......................................................... 215
Comfort lighting......................................... 93
Compass................................................. 105
calibration........................................... 105
Condensation in headlamps.................... 344
controls
centre console ...........................223, 263Controls
centre console.................................... 144
Controls, lights........................................... 88
Cooling system........................................ 270
Corner Traction Control .......................... 168
Crash, see Collision................................... 30
Cruise control.......................................... 171
CZIP (Clear Zone Interior Package)......... 153
D
DAB Radio............................................... 233
Deadlock
deactivation.......................................... 62
temporary deactivation......................... 63
Deadlocks.................................................. 62
Defroster.................................................. 159
Diesel.......................................................275
Diesel particle filter..................................276
Dipstick, electronic.................................. 315
Direction indicators.................................... 91
Disengaging the gear selector inhibitor. . . 120
Display lighting.......................................... 88Distance Warning....................................185
Dolby Surround Pro Logic II.................... 220
Door mirrors............................................. 102
Driveable punctured tyres........................ 304
Driver Alert Control.................................. 199
Driver Alert System.................................. 199
Driving...................................................... 270
cooling system.................................... 270
with the tailgate open.........................271
with trailer........................................... 283
Driving in water........................................ 270
Driving with a trailer
towball load........................................ 355
towing capacity..................................355
DSTC, see also Stability control system.. 169
DVD ......................................................... 236
E
ECC, electronic climate control...............155
Economical driving.................................. 270
ECO pressure.......................................... 301
Eco Start/Stop DRIVe.............................. 123
ProCarManuals.com