2012 TOYOTA HILUX light

552 5-2. Steps to take in an emergency
HILUX_EE (OM0K132E)
*: Slow down until the lamp goes off.
Warning lightWarning light/Details
Fuel system warning light
Indicates:
• The amount of accumulated water in the fuel filter has
reached the specified level if the light flashes.
• Malfunction in the fuel system if the light comes on.
DPF system warning light
Indicates:
• Vehicles without DPF system switch: The amount of
accumulated deposit in the DPF catalytic converter has
reached the specified level if the light comes on. Regen-
erate the filter. (P. 555)
• Vehicles without DPF system switch: Malfunction in the
DPF system if the light flashes.
• Vehicles with DPF system switch: Regenerate the filter
with the DPF system switch if the light turns on or
flashes. (P. 226)

5
553 5-2. Steps to take in an emergency
When trouble arises
HILUX_EE (OM0K132E)
Follow the correction procedures.
After taking the specified steps to correct the suspected problem,
check that the warning light goes off.
Warning lightWarning light/DetailsCorrection procedure
Open door warning light
Indicates that a door is not fully
closedCheck that all the
doors are closed.
Low fuel level warning light
Indicates remaining fuel is
approximately 12.0 L
(3.2 gal., 2.6 Imp.gal.) or less
Refuel the vehicle.
(for driver)
Driver’s seat belt reminder
light (warning buzzer)
*
Warns the driver to fasten his/
her seat beltFasten the seat belt.

554 5-2. Steps to take in an emergency
HILUX_EE (OM0K132E)
*: Driver’s seat belt buzzer:
The driver’s seat belt buzzer sounds to alert the driver that his or her seat
belt is not fastened. The buzzer sounds intermittently for 30 seconds after
the vehicle reaches a speed of 15 km/h (9 mph). Then, if the seat belt is still
unfastened, the buzzer will sound in a different tone for 90 more seconds.
Warning lightWarning light/DetailsCorrection procedure
(for front
passenger)
Front passenger’s seat
belt reminder light
Warns the front passen-
ger to fasten his/her seat
belt
Fasten the seat belt.
Unengaged “Park” warn-
ing light (if equipped)
The transmission “Park”
mechanism is not
engaged.Shift front drive control lever
to “H2” or “H4” or “L4”.
Low engine oil level warn-
ing light
Indicates that engine oil
level is lowCheck the level of engine oil
and add more oil if neces-
sary.
(remains on)Engine oil change
reminder light
Indicates that the engine
oil should be changed
Comes on approximately
30000 km (18000 miles)
after the engine oil has
been changed (and the oil
maintenance date has
been reset)Have the engine oil and oil
filter checked and/or
changed by any authorized
Toyota dealer or repairer, or
another duly qualified and
equipped professional. After
changing the engine oil, the
oil change system should
be reset. (P. 484)

5
555 5-2. Steps to take in an emergency
When trouble arises
HILUX_EE (OM0K132E)
Key reminder buzzer
The buzzer indicates that the key has not been removed with the engine off
and the driver’s door opened.
If the DPF system warning light comes on
The deposit collected in the filter needs to be regenerated.
To regenerate the filter, the following driving methods are recommended
*:
By driving continuously (for example, at around 60 km/h [37 mph] for
approximately 20 minutes).
By avoiding short trips, or by driving continuously (leaving the engine
running for long periods of time).
The DPF warning light will extinguish when regeneration is complete. How-
ever, if this driving cannot be carried out, or if the light does not extinguish
even after driving, have the vehicle inspected by any authorized Toyota
dealer or repairer, or another duly qualified and equipped professional imme-
diately.
For details of the DPF system. (P. 226)
*: When driving, pay sufficient attention to weather, road conditions, terrain
and traffic conditions, and drive according to traffic laws.

556 5-2. Steps to take in an emergency
HILUX_EE (OM0K132E)
CAUTION
If both the ABS and the brake system warning lights remain on (vehi-
cles with VSC system)
Stop your vehicle in a safe place immediately and contact any authorized
Toyota dealer or repairer, or another duly qualified and equipped profes-
sional. The vehicle will become extremely unstable during braking, and the
ABS system may fail, which could cause an accident resulting in death or
serious injury.
NOTICE
If the malfunction indicator lamp comes on when the boost pressure in
the turbocharger is abnormally high
Never drive at high speed or race the engine even after the lamp goes off.
If the fuel system warning light flashes
Never drive the vehicle with the warning light flashing. Continued driving with
water accumulated in the fuel filter will damage the fuel injection pump.

5
565 5-2. Steps to take in an emergency
When trouble arises
HILUX_EE (OM0K132E)Remove the wheel ornament.
Ty p e A
Pry off the wheel ornament,
using the beveled end of the
wheel nut wrench as shown.
To protect the wheel ornament,
place a rag between the wheel
nut wrench and the wheel orna-
ment.
Ty p e B
Pry off the wheel ornament,
using the beveled end of the
wheel nut wrench as shown.
To protect the wheel ornament,
place a rag between the wheel
nut wrench and the wheel orna-
ment.
Slightly loosen the wheel nuts
(one turn).
STEP2
STEP3

5
567 5-2. Steps to take in an emergency
When trouble arises
HILUX_EE (OM0K132E)Raise the vehicle until the tire is
slightly raised off the ground.
When positioning the jack under
the rear axle housing, make sure
the groove on the top of the jack
fits with the rear axle housing.
If the tire is still underneath the
vehicle, leave the vehicle jacked
up and use a tool to pull the tire
out.
Remove all the wheel nuts and
the tire.
When resting the tire on the
ground, place the tire so that the
wheel design faces up to avoid
scratching the wheel surface.
STEP6
STEP7
CAUTION
When take out the spare tire
Be careful not to touch the exhaust, as you may burn yourself.
Be careful not to injure yourself by trapping your hands in or becoming
caught in the rear under protection.

576
5-2. Steps to take in an emergency
HILUX_EE (OM0K132E)
If the engine will not start
If the engine will not start even though correct starting procedures
are being followed (
P. 162), consider each of the following points:
The engine will not start even though the starter motor
operates normally.
One of the following may be the cause of the problem:
There may not be sufficient fuel in the vehicle’s tank.
(P. 587)
There may be a malfunction in the engine immobilizer system.
(P. 103)
The starter motor turns over slowly, the interior lights and
headlights are dim, or the horn does not sound or sounds at
a low volume.
One of the following may be the cause of the problem:
The battery may be discharged. (P. 579)
The battery terminal connections may be loose or corroded.
The starter motor does not turn over, the interior lights and
headlights do not turn on, or the horn does not sound.
One of the following may be the cause of the problem:
One or both of the battery terminals may be disconnected.
The battery may be discharged. (P. 579)
Contact any authorized Toyota dealer or repairer, or another duly
qualified and equipped professional, if the problem cannot be
repaired, or if repair procedures are unknown.