2012 TOYOTA AYGO brake

258 4-3. Do-it-yourself maintenance
AYGO_WE_99E96E
CAUTION
When raising your vehicle
Make sure to observe the following precautions to reduce the possibility of
death or serious injury:
When using a floor jack, follow the instructions of the manual provided with
the jack.
Do not use the jack that was supplied with your vehicle.
Do not put any part of your body underneath the vehicle when it is sup-
ported only by the floor jack.
Always use floor jack and/or automotive jack stands on a solid, flat, level
surface.
Do not start the engine while the vehicle is supported by the floor jack.
Stop the vehicle on level, firm ground, firmly set the parking brake and shift
the shift lever to E, M or R (vehicles with a multi-mode manual transmis-
sion) or R (vehicles with a manual transmission).
Make sure to set the floor jack properly at the jack point.
Raising the vehicle with an improperly positioned floor jack will damage
the vehicle and may cause the vehicle to fall off the floor jack.
Lift up the vehicle using a floor jack
such as the one shown in the illustra-
tion.
Do not jack the vehicle at the front
under cover and the rear suspension.
The front under cover and the rear sus-
pension may be damaged.Front under
cover
FrontRear
suspension

285 4-3. Do-it-yourself maintenance
4
Maintenance and care
AYGO_WE_99E96E
Fuse layout and amperage ratings
Engine compartment (top side)
FuseAmpereCircuit
1 DRL 5 A Daytime running lights
2 FOG FR 20 A Front fog lights
3 H-LP LH 10 A Left-hand headlights
4 H-LP RH 10 A Right-hand headlights
5STA 7.5 AMulti-mode manual transmission,
multiport fuel injection system/
sequential multiport fuel injection
system
6 EFI NO.2 7.5 AMultiport fuel injection system/
sequential multiport fuel injection
system, multi-mode manual trans-
mission
7 MET 5 A Gauges and meters
8 SUB-LP 30 A DRL, FOG FR fuses
9ABS NO.2
*125 A Anti-lock brake system
VSC NO.2
*230 AAnti-lock brake system and vehicle
stability control system

286 4-3. Do-it-yourself maintenance
AYGO_WE_99E96E
*1: Vehicles without VSC system
*2: Vehicles with VSC system
*3: Replace the fuse with one of the same ampere rating as the original 10 AM2 30 AStarting system, IG1, IG2, STA
fuses
11 HAZARD 10 ATurn signal lights, emergency
flashers, gauges and meters
12 H-LP MAIN 20 A H-LP LH, H-LP RH fuses
13 DOME 15 AGauges and meters, interior light,
audio system, tachometer
14 EFI 15 AElectric cooling fan, multiport fuel
injection system/sequential multi-
port fuel injection system
15 HORN 10 A Horn
16 SPARE 7.5 A Spare fuse
17 SPARE 10 A Spare fuse
18 SPARE 15 A Spare fuse
19 AMT 50 A Multi-mode manual transmission
20 RADIATOR30 A
*3
Electric cooling fan
40 A*3
21ABS
*140 AAnti-lock brake system
VSC*250 AAnti-lock brake system and vehicle
stability control system
22 EMPS 50 A Electric power steering system
FuseAmpereCircuit

288 4-3. Do-it-yourself maintenance
AYGO_WE_99E96EInstrument panel (right side)
FuseAmpereCircuit
1STOP 10 A
Stop lights, high mounted stoplight,
anti-lock brake system, multi-mode
manual transmission
2 D/L 25 APower door lock system, wireless
remote control system
3 DEF 20 A Rear window defogger
4TAIL 7.5 ADaytime running light system, tail
lights, license plate lights, position
lights, headlight beam level control
system, instrument panel lights
5 OBD 7.5 A On-board diagnosis system
6ECU-B 7.5 AMulti-mode manual transmission,
daytime running light system, vehi-
cle stability control system, gauges
and meters, rear fog light

289 4-3. Do-it-yourself maintenance
4
Maintenance and care
AYGO_WE_99E96EInstrument panel (left side)
FuseAmpereCircuit
1ECU-IG 7.5 A
Anti-lock brake system, vehicle sta-
bility control system, electric power
steering system, electric cooling fan
2BACK UP 10 ABack-up lights, power door lock
system, wireless remote control
system, power windows, rear win-
dow defogger, tachometer, air con-
ditioning system, heater system
3 WIP 20 AWindshield wiper and washer, rear
window wiper and washer
4 ACC 15 A Power outlet, audio system
5IG1 7.5 AWindshield wiper and washer, rear
window wiper and washer, anti-lock
brake system, electric power steer-
ing system, electric cooling fan,
back-up lights, power door lock
system, wireless remote control
system, power windows, rear win-
dow defogger, tachometer, air con-
ditioning system, heater system
6IG2 15 AMultiport fuel injection system/
sequential multiport fuel injection
system, SRS airbag system,
gauges and meters, daytime run-
ning light system, multi-mode man-
ual transmission

5
305
5-1. Essential information
When trouble arises
AYGO_WE_99E96E
If your vehicle needs to be towed
Before towing
The following may indicate a problem with your transmission. Contact
any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional before towing.
The engine is running but the vehicle will not move.
The vehicle makes an abnormal sound.
Emergency towing
If a tow truck is not available in
an emergency, your vehicle may
be temporarily towed using a
cable or chain secured to the
emergency towing eyelet. This
should only be attempted on
hard surfaced roads for short
distances at low speeds.
A driver must be in the vehicle to
steer and operate the brakes.
The vehicle’s wheels, drive train,
axles, steering and brakes must
be in good condition.
If towing is necessary, we recommend having your vehicle towed by
any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional, such as a commercial towing service,
using a lift-type truck or flatbed truck.
Use a safety chain system for all towing, and abide by all state/pro-
vincial and local laws.

5
307 5-1. Essential information
When trouble arises
AYGO_WE_99E96E
Towing with a sling-type truck
Do not tow with a sling-type truck
to prevent body damage.
Towing with a wheel-lift type truck
From the front
Release the parking brake.
From the rear
We recommend using a towing
dolly under the front wheels.
When not using a towing dolly,
turn the engine switch to the “ON”
position (vehicles with a multi-
mode manual transmission) or
the “ACC” position (vehicles with
a manual transmission) and shift
the shift lever to N.

308 5-1. Essential information
AYGO_WE_99E96E
Using a flatbed truck
If your Toyota is transported by a
flatbed truck, it should be tied
down at the locations shown in
the illustration.
If you use chains or cables to tie
down your vehicle, the angles
shaded in black must be 45.
Do not overly tighten the tie
downs or the vehicle may be
damaged.
Front
Before emergency towing
Release the parking brake.
Shift the shift lever to N.
Turn the engine switch to the “ACC” (engine off) or “ON” (engine
running) position.
Emergency towing eyelet location
P. 318