2012 SSANGYONG RODIUS height

07-74411-01
Coil Spring ▶
Description 4WD 2WD
Spring rate (kg/mm)10.01 ± 5% 10.01 ± 5%
Coil diameter (mm)16.7 16.7
Inner diameter
(mm)D 158.3 58.3
D 288.3 88.3
Spring identificationNone + Red or Blue Yellow + Red or Blue
Number of windings8.49 8.49
Number of active windings6.99
CVW (Curved
Vehicle Weight)Height (mm)256.0 256.0
Weight (kg)976.9 ± 4% 834.9 ± 4%
Stress (kg/mm)69.53 59.42
Winding directionClockwise Clockwise

07-10
(2) Coil Spring
High tensile steel used.
Minimum length should be 20 mm longer than the fully compressed length.
Spring seat used. -
-
-
Description 4WD 2WD
Part number45110-21000 45110-21000
Spring rate (kg/mm)12.0 ±5% 12.0 ±5%
Coil diameter (mm)15.9 15.9
Inner diameter (mm)69.1 69.1
Pitch (mm)85.0 85.0
Number of windings9.55 9.55
Number of active windings8.35 8.35
CVW (Curved Vehicl
e
Weight)Height (mm)250 250
Weight (kg)880 880
Stress (kg/mm)
62.1 62.1
Winding directionClockwise Clockwise
Spring length (mm)323.3 323.3
Dimension ▶

08-114850-03
Let the engine run for 1 to 2 minutes and
stop it. If the brake pedal stroke is
shortened as pumping the brake pedal,
the system is normal. If not, the system is
defective.
Depress the brake pedal several times with
engine off. If the brake goes down when
starting engine with pedal depressed, the
system is normal. If not, the system is
defective. 1.
2.
Depress the brake pedal when the engine
is running. If the pedal height is not
changed for 30 seconds after stopping the
engine, the system is normal. If not, the
system is defective. 3.
If the above three checks are OK, the system
is normal. If any condition is not met, check
the valve, vacuum hose and brake booster.
3) Brake Booster
OK
NG
Engine stopped
Engine running

12-54170-01
2) Tire Unit Indication
Aspect ratio (%)
= Nominal section height (H) / Nominal section
width (W)
X 100
3) Tire Inflation Pressure (35 psi)
Proper inflation pressure Excessive inflation pressure Low inflation pressure
The contact area between the
ground and tire faces the tread
layer completely. Thus the
driving force and the braking
force are optimized, and the tire
is worn out evenly resulting in
increased life.The contact area between the
ground and tire is not
enough, so the tire is worn
out unevenly and the tire is
vulnerability to outside
influence.The contact area between the
ground and tire is excessive,
so a lot of heat is generated
and the tire is worn out
unevenly and abnormally.
Tread widthTread widthTread width

02-38810-03
1. SPECIFICATIONS
1) SDM
* Energy reservation for 150 ms even after shutting off the power.
2) Seat Belt
▶Front Seat Belt
Description Specification
Operating voltage 9 ~ 16V
Operating temperature-30 ~ 85℃
Accelerometer dynamic range -50 ~ 50G
Impact record Diagnostic Trouble Code
Description Specification
3-point seat belt<00bd00470073009000940090009b008c008b0047009300960088008b0047009b00a00097008c0047008900a00047009a009b009600970097008c00990047004f0093008c0095008e009b008f00470096008d0047009e008c0089008900900095008e006100
47005a00530059005700570047009400940050>
Height adjuster<00bd0047007a0090008b008c00470089009c009b009b009600950047009b00a00097008c0047004f009a009b009900960092008c006100470059005c0047009400940047009f0047005a0047009a009b008c0097009a004700640047005e005c0047009400
940050>
Pre-tensioner
(optional)· Retract distance: over 120 mm
· Retracting time: 8 to 12 ms
· Slide button type
· Retracting tension: 2 to 3.2 kN
· Spool-out limit: below 50 mm
· Seat belt warning lamp (driver’s)
Buckle · Swivel type
· Seat belt warning lamp (driver’s)

02-8
Height Adjuster Front Seat Belt
Passenger's Air Bag
Air Bag Unit
Belt Type BuckleFoxed Type BuckleDriver's Air Bag
1. LAYOUT
Front Seat
1) Components
Driver’s Passenger’s

03-2
Sliding adjust lever
Seat warmer switch
Back flat adjust lever
1. LAYOUT AND COMPONENTS
1) Components of Seat
Seat Control Switch (Driver's Seat)
Seat position control Seat height control Reclining control
Back supporter
(Driver’s seat)
Sliding control

03-18
Seat cushion height adjustment
Seat moves up/down
controlled by seat height
control switch
Seatback reclining
Seat back reclining controlled
by seat reclining control
switch