2012 Seat Ibiza SC service

228If and when
Xenon 1)
//adaptive headlights*
- D1S2)
- LED 3)
- LED3)
- PY 21W
Fog light - H11
WARNING
● Take particular care when working on components in the engine com-
partment if the engine is warm. Risk of burns.
● Bulbs are highly sensitive to pressure. The glass can break when you
touch the bulb, causing injury.
● The high voltage element of gas discharge bulbs* (xenon light) must
be handled correctly. Otherwise, there is a risk of death.
● When changing bulbs, please take care not to injure yourself on sharp
parts in the headlight housing.
CAUTION
● Remove the ignition key before working on the electric system. Other-
wise, a short circuit could occur.
● Switch off the lights or parking lights before you change a bulb.
Dipped and full beam
Side
DRL (day light)
Turn signals
Fog light/cornering
For the sake of the environment
Please ask your specialist retailer how to dispose of used bulbs in the prop-
er manner.
Note
● Depending on weather conditions (cold or wet), the front lights, the fog
lights, the tail lights and the turn signals may be temporarily misted. This
has no influence on the useful life of the lighting system. By switching on
the lights, the area through which the beam of light is projected will quickly
be demisted. However, the edges may continue to be misted.
● Please check at regular intervals that all lighting (especially the exterior
lighting) on your vehicle is functioning properly. This is not only in the inter-
est of your own safety, but also that of all other road users.
● Before changing a bulb, make sure you have the correct new bulb.
● Do not touch the glass part of the bulb with your bare hands, use a cloth
or paper towel instead. Otherwise, the fingerprints left on the glass will va-
porise as a result of the heat generated by the bulb, they will be deposited
on the reflector and will impair its surface. 
1)
With this type of headlight, the user can replace the turn signal bulb. Replacement of the
dipped/main beam bulb must be done by a Technical Service, given that complex elements
must be removed from the vehicle and the automatic control system that incorporates it
must be reset.
2) The Xenon bulbs discharge 2.5 times the light flux and have an average lifespan of 5 times
more than that of halogen bulbs, this means that, except due to unusual circumstances,
there is no need to change the bulbs for the whole life of the vehicle.
3) In the event that there is a fault in the LEDs, the complete headlight must be replaced.

240If and when
Interior light and front reading light
Fig. 166 Front reading
light
To remove the glass
– Insert a fine screwdriver between the casing and the glass
⇒ Fig. 166.
– Carefully remove the glass, levering it to avoid possible dam-
age.
To replace the bulbs
– Pull the bulbs outwards.
– To remove the central bulb, hold and press to one side.
Assembly
– Proceed in the reverse order, pressing gently on the outer edge
of the side light. –
First fit the glass with the fastening tabs over the frame of the
switch. Next press the front part until the two long tabs click on
the support. 
Additional brake light*
Given the difficulty involved in the replacement of this light it should be
done by the Technical Service. 

250Description of specifications
Drawbar loads
The maximum permitted drawbar load on the ball joint of the towing bracket
must not exceed 75 kg.
In the interest of road safety, we recommend that you always tow approach-
ing the maximum drawbar load. The response of the trailer on the road will
be poor if the drawbar load is too small.
If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with a
wheelbase of less than 1 metre), a minimum of 4% of the actual trailer
weight is legally required for the drawbar load.
WARNING
● For safety reasons, do not exceed the 80 km/h (50 mph) limit. This is
also valid in countries where higher speeds are permitted.
● Never exceed the maximum trailer weights or the drawbar load. If the
permissible axle load or the permissible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.

Wheels
Tyre pressure, snow chains, wheel bolts
Tyre pressures
The sticker with the tyre pressure values can be found on the inside of the
fuel tank flap. The tyre pressure values given there are for cold tyres. The
slightly raised pressures of warm tyres must not be reduced. ⇒ 
Snow chains
Snow chains may be fitted only to the front wheels, and only for the follow-
ing tyres:
175/70R14
185/60R15Chains with links not exceeding 15 mm (including the chain
closure)
215/45R16Chains with links not exceeding 9 mm (including the chain
closure)
215/40R17Chains with links not exceeding 7 mm (including the chain
closure)
Wheel bolts
After the wheels have been changed, the tightening torque of the wheel
bolts should be checked as soon as possible with a torque wrench ⇒ 
.
The tightening torque for steel and alloy wheels is 120 Nm.
WARNING
● Check the tyre pressure at least once per month. Checking the tyre
pressure is very important. If the tyre pressure is too high or too low,
there is an increased danger of accidents, particularly at high speeds.
● If the tightening torque of the wheel bolts is too low, they could loos-
en while the vehicle is in motion. Risk of accident! If the tightening tor-
que is too high, the wheel bolts and threads can be damaged.
Note
We recommend that you ask your Technical Service for information about
appropriate wheel, tyre and snow chain size. 

251
Technical specifications
Technical specifications
Checking fluid levels
From time to time, the levels of the different fluids in the ve-
hicle must be checked. Never fill with incorrect fluids, other-
wise serious damage to the engine may be caused.
Fig. 174 Diagram for the
location of the various el-
ements
Fig. 175 For vehicles
with the battery in the
luggage compartment.
Coolant expansion tank
Engine oil level dipstick
Engine oil filler cap
Brake fluid reservoir
Vehicle battery
Windscreen washer fluid container
The checking and refilling of service fluids are carried out on the compo-
nents mentioned above. These operations are described in the ⇒ page 193.
Overview
You will find further explanations, instructions and restrictions on the tech-
nical specifications as of ⇒ page 247.
Note
The layout of parts may vary depending on the engine. 
1
23456
Safety FirstOperating InstructionsPractical TipsTechnical Specifications

Instrument panelService interval display . . . . . . . . . . . . . . . . 61
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Interior rear vision mirror . . . . . . . . . . . . . . . . . 109
Interval wipe, windscreen . . . . . . . . . . . . . . . . 106
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
J
Jump-starting . . . . . . . . . . . . . . . . . . . . . . . . . . 241
Jump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . 241
K
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
L Leather cleaning . . . . . . . . . . . . . . . . . . . . . . . . 181
Leaving Home function . . . . . . . . . . . . . . . . . . 101
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Load compartment in the luggage compart- ment
see Loading the luggage compartment . . . 16
Loading the luggage compartment . . . . . . . . . . 16
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
LPG . . . . . . . . . . . . . . . . . . . . . . . . . . 56, 142, 189
LPG system Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Filler neck adapter . . . . . . . . . . . . . . . . . . . 190
Level indicator . . . . . . . . . . . . . . . . . . . . . . . 56
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . 189 Luggage compartment . . . . . . . . . . . . . . . . . . . 125
see also Loading the luggage compartment . .16
Luggage compartment light . . . . . . . . . . . . . . 241
Luggage compartment light* . . . . . . . . . . . . . 105
M
Main beam . . . . . . . . . . . . . . . . . . . . . . . . . 97, 103
Main beam headlights control lamp . . . . . . . . . . . . . . . . . . . . . . . . . 73
Maintenance Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Maintenance and cleaning . . . . . . . . . . . . . . . 174
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . 146
Manual heating . . . . . . . . . . . . . . . . . . . . . . . . 128 controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Manual heating system Defrosting the windscreen . . . . . . . . . . . . . 128
Demisting the windscreen and side win-dows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
MFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Mirrors Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . 110
Interior rear vision mirror . . . . . . . . . . . . . . 109
vanity mirror . . . . . . . . . . . . . . . . . . . . . . . . 106
Mobile phone . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Multifunction display . . . . . . . . . . . . . . . . . . . . . 59
N
Number of seats . . . . . . . . . . . . . . . . . . . . . . . . . 18 O
Observations . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 192
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 199
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . 197
One-touch opening and closing Electric windows . . . . . . . . . . . . . . . . . . . . . . 93
Opening and locking . . . . . . . . . . . . . . . . . . . . . 90
Operation when a fault occurs panoramic/tilting sunroof . . . . . . . . . . . . . . 96
Outside temperature indicator . . . . . . . . . . 58, 60
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . 63, 66
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . 55
Warning lamps . . . . . . . . . . . . . . . . . . . . 63, 66
P
Paintwork Polishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Panoramic sunroof . . . . . . . . . . . . . . . . . . . . . . . 94
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Passenger see Correct sitting position . . . . . . . 10, 11, 12
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192 Driving abroad . . . . . . . . . . . . . . . . . . . . . . 171
273
Index

Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . 192
Physical principles of a frontal collision . . . . . . 20
Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Plastic parts cleaning . . . . . . . . . . . . . . . . . . . . 180
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Pollution filter . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Power sockets . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Products for vehicle maintenance . . . . . . . . . . 174
R Radio frequency remote control . . . . . . . . . . . . 85 Changing the battery . . . . . . . . . . . . . . . . . . 86
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Rear drink holder* . . . . . . . . . . . . . . . . . . . . . . 122
Rear fog light Control lamp . . . . . . . . . . . . . . . . . . . . . . 69, 97
Rear head restraints . . . . . . . . . . . . . . . . . . . . . . 14
Rear lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90 control lamp . . . . . . . . . . . . . . . . . . . . . . . . . 73
Emergency opening . . . . . . . . . . . . . . . . . . . 91
Rear seat folding down . . . . . . . . . . . . . . . . . . . . . . . . 117
Rear seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Rear shelf . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Rear view mirrors . . . . . . . . . . . . . . . . . . . . . . . 109
Rear window automatic wiper/washer . . . . . . 108
Rear window wiper . . . . . . . . . . . . . . . . . . . . . . 108
Recommended gear display . . . . . . . . . . . . . . . 58
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187 Remote control key
Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Synchronising . . . . . . . . . . . . . . . . . . . . . . . . 86
Removing and fitting the wheel . . . . . . . . . . . 221
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . 84
Replacement of parts . . . . . . . . . . . . . . . . . . . . 183
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Reverse gear Manual gearbox . . . . . . . . . . . . . . . . . . . . . 146
Roll-back function panoramic/tilting sunroof . . . . . . . . . . . . . . 96
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Roof aerial* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Roof rack* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Rubber seals . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
Running in Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 167
S Safe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Safe driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safe Security system . . . . . . . . . . . . . . . . . . . . . 80
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety equipment . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safety instructions Coolant temperature . . . . . . . . . . . . . . . . . . 74
Safety notes Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Deactivating front passenger airbag . . . . . . 40 Front airbags . . . . . . . . . . . . . . . . . . . . . . . . 36
Seat belt tensioners . . . . . . . . . . . . . . . . . . . 27
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . 38
Using child seats . . . . . . . . . . . . . . . . . . . . . 42
Using seat belts . . . . . . . . . . . . . . . . . . . . . . 22
Seals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
Seat adjustment . . . . . . . . . . . . . . . . . . . . 112, 115
Seat belt cleaning . . . . . . . . . . . . . . . . . . . . . . 182
Seat belt control lamp . . . . . . . . . . . . . . . . . . . . 18
Seat belt position Pregnant women . . . . . . . . . . . . . . . . . . . . . 25
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Seat belt protection . . . . . . . . . . . . . . . . . . . . . . 22
Seat belt release . . . . . . . . . . . . . . . . . . . . . . . . 26
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 24
control lamp . . . . . . . . . . . . . . . . . . . . . . . . . 18
Incorrectly fastened . . . . . . . . . . . . . . . . . . . 27
Not worn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . 22
Seat belt tensioner control lamp . . . . . . . . . . . . . . . . . . . . . . . . . 30
Seat heating . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Selective opening* . . . . . . . . . . . . . . . . . . . . . . . 81
Semiautomatic air conditioning controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Service interval display . . . . . . . . . . . . . . . . . . . 61
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . 38
Side lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
274Index