2012 Peugeot 508 RXH gearbox

126
i
i
i
i
Driving

Engagement of reverse gear is accompanied by an audible signal.
If you leave the vehicle, place the gear
lever in position Nand then you muststop the hybrid system by switching off the ignition (Ready
lamp off).
If the gear lever is not in position Nonstarting, N
flashes in the instrument panel, accompanied by an audible signal and a message in the instrument panel screen.Foot on brake
flashes on theinstrument panel, accompanied by anaudible signal and a message in theinstrument panel screen, if the brakepedal is not pressed on starting.


For optimum acceleration, for example
when overtaking another vehicle, press the accelerator pedal firmly past the point of resistance.
Displays in the instrument panel
N Neutral R Reverse1, 2, 3, 4, 5, 6
Gears in manual mode A This comes on when automated mode is
selected. It goes off on changing to manual mode.
)Place your foot on the brakewhen a message appears in the
instrument panel screen.



Moving off
)
Select position N . )
Press the brake pedal down fully.)
Star t the hybrid system.
N
appears in the instrument panelscreen.
)
Select a gear (position M
or A) or reverse A(position R
).R)
Release the parking brake unless it is
programmed to automatic mode. ) Ta k e your foot off the brake pedal, thenaccelerate.
Aand 1
or Rappear in the instrument panel screen.


Automatic mode
)After star ting the vehicle, select position Afor enter automatic mode.
A
appears in the instrument panel screen.
The
gearbox is then operating in auto-active mode, without any action on the par t of thedriver. It continuously selects the most suitable gear, depending on the:


- st
yle of driving,

- profile of the road.


When the engine is idling with thebrakes off, if position R, Aor M
is selected, the vehicle will move off
on its own without any action on theaccelerator.

4
127
i
!
Driving
Manual gear changing
)
When the vehicle has moved off, select
position M to change to manual mode. )
Operate the +or -steering mounted control paddles.


At very low speed, if reverse gear is requested, this will only be taken intoaccount when the vehicle is immobilised(foot on the brake). A warning lamp appears in the instrument panel screen.

On sharp acceleration in manual mode,the gearbox will not change up unless the driver acts on the gear lever or thesteering mounted paddles.
Never select neutral N
while the vehicleis moving. Only engage reverse gear Rwhen thevehicle is immobilised with the brake pedal pressed. A
disappears and the
gears engaged
appear successively in the instrument
panel screen.
The
gear change commands are only carried
out if the engine speed permits. The internal combustion engine is still running. It is not necessary to release the accelerator
during gear changes.
When brakin
g or slowing down, the gearbox changes down automatically to permitacceleration in the correct gear. This selective
gear change mode enables you
to over take, for example, while still remaining in automatic mode.)Operate the + or -
steering mounted controlpaddle.
The gearbox engages the gear requested if the engine speed permits. A
is still displayed in theinstrument panel.
After a few moments without any action on
the controls, the gearbox resumes automaticcontrol of the gears.

Manual mode

128
!
!
!
Driving
You must press the brake pedal when star ting the engine.
Whatever the circumstances, you must manually apply the parking brake when parking, unless the parking brake isprogrammed in automatic mode.

When immobilising the vehicle, with the hybrid system active, you must place the gear lever in neutral N.Before carrying out any work in the engine compar tment, check that the gear lever is in neutral N
and that the
parking brake is applied.



Stopping the vehicle
With the ignition on, theflashing of this warning lamp, accompanied by an audiblesignal and a message in the instrument panelscreen, indicates a malfunction of the gearbox.
Have it checked by a PEUGEOT dealer or a qualified workshop. Be
fore switching off the engine, you can
choose to:


- move to position N
to engage neutral,

- leave the gear engaged; in this case, it will
not be possible to move the vehicle.
In both cases,
you should apply the parkingbrake to immobilise the vehicle.


Operating fault
This function facilitates manoeuvring of the
vehicle at low speed (when parking, in traffic jams, …).
With the hybrid system active and the parking
brake released, if position A, M
or R
is selected, the vehicle moves as soon as you
take your foot off the brake pedal (even without any action on the accelerator).
Creep function (moving
without the accelerator
)

Never leave children unsuper vised in the vehicle with the hybrid system active. For
your safety, this function will only be activated if you press the brake pedal when engaging for ward drive or reverse.
This function is deactivated if the driver's door
is opened. To reactivate it, close the door and
then press the brake or accelerator pedal.

8
203
!
i
Practical information

The batteries contain harmful substancessuch as sulphuric acid and lead. Theymust be disposed of in accordancewith regulations and must not, in any circumstances, be discarded with household waste.
Take used remote control batteries andvehicle batteries to a special collection point.


Do not reverse the polarity and use only a 12 V charger.
Do not disconnect the terminals whilethe engine is running. Do not charge the batteries withoutdisconnecting the terminals first. Do not push the vehicle to star t the engine if it is fitted with the 6 -speed electronic gearbox system or an automatic gearbox.


It is advisable to disconnect the 12 Vbattery if the vehicle is to be left unused for more than one month.
Before disconnecting the battery
Wait 2 minutes after switching off the ignition
before disconnecting the 12 V battery.Close the windows and the doors before disconnecting the battery.
Following reconnection of thebattery
Following reconnection of the 12 V battery,
switch on the ignition and wait 1 minute before
starting to permit initialisation of the electronic
systems. However, if problems remain following
this operation, contact a PEUGEOT dealer or a qualified workshop.
Referring to the corresponding section, you
must yourself reinitialise:
- the remote control key,
- the panoramic sunroof blind,
- the GPS satellite navigation system.









Load reduction mode

System which manages the use of cer tainfunctions according to the level of charge
remaining in the battery.
When the vehicle is being driven, the load
reduction function temporarily deactivates certain functions, such as the air conditioning,
the heated rear screen...
The deactivated functions are reactivatedautomatically as soon as conditions permit.

222
i
Checks





6-speed electronic gear
control gearbox
The gearbox does not require any maintenance (no oil change).
Refer to the servicing booklet for
details of the checking interval for
this component.
Brake wear depends on the style
of driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It may be necessary to have the condition of the brakes checked, evenbetween vehicle services.
Unless there is a leak in the circuit, a drop in
th
e brake fluid level indicates that the brakepads are worn.
Brake pads
Particle emission filter (Diesel)
The star t of saturation of the par ticle
filter is indicated by the temporary
illumination of this warning lamp
accompanied by a message in the
multi-function screen.
As soon as the traffic conditions permit,regenerate the filter by driving at a speed of at least 40 mph (60 km/h) until the warning lamp goes off.If the warning lamp stays on, thisindicates a low additive level.
On a new vehicle, the first par ticle filter regeneration operations may beaccompanied by a "burning" smell,which is perfectly normal.Following prolonged operation of thevehicle at very low speed or at idle,you may, in exceptional circumstances, notice the emission of water vapour atthe exhaust on acceleration. This does not affect the behaviour of the vehicle or the environment.

The 100 % electric mode is not
available during regeneration of thepar ticle emissions filter.

10
225
Technical data
ENGINE AND GEARBOX
Diesel engine2.0 litre HDi 163 hp
Gearbox

Electronic gear control (6-speed)
Model codes
8URHC8/P

Cubic capacity (cc)

1 997
Bore x stroke
(mm)
85 x 88

Max power: EU standard
(kW) 10 0
120

Max power engine speed (rpm) 3 750
Max torque: EU standard
(Nm)
340

Max torque engine speed (rpm)
2 000

F
uel Diesel

Catalytic converter

yes

Particle emission filter
yes
OIL CAPACITIES (in litres)

Engine (with filter replacement) 5

226
Technical data
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.
* The kerb wei
ght is equal to the unladen weight + driver (75 kg).
**
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
WEIGHTS AND TOWED LOADS (in kg)
Diesel engines2.0 litre HDi 163 hp
Gearboxes

Electronic gear control
(6-speed)

Model codes8URHC8/P


- Unladen wei
ght1 770



- Kerb weight *

1 845


- Gross vehicle wei
ght (GV W)
2 325



- Gross train wei
ght (GT W)
on a 12% gradient 3 125


- Braked trailer
(within GTW limit) on a 10% or 12% gradient 800



- Braked trailer
**
(with load transfer with the GTW limit)
1 100


- Unbraked trailer
750



- Recommended nose weight
75

288
Alphabetical index
Filling with fuel..........................................83,85Fitting a wheel...............................................186Fitting roof bars.............................................211Fittings, boot...................................................98Flashing indicators ................................ 145, 167Flat bed lorry or trailer............................r44, 208Foglamps, rear..............................................r143Folding the rear seats.....................................90Front foglamps..............................................143Front seats ................................................86,87Fuel............................................................37,85Fuel consumption......................................37,39Fuel consumption figures...............................39Fuel filler cap...................................................83Fuel filler flap...................................................83Fuel gauge ......................................................83Fuel tank..........................................................83Fusebox, dashboard.....................................197Fuses .............................................................197
G.P.S.............................................................242Gearbox, electronic gear control..........125,222Gear lever........................................................37Gear lever,electronic gear control gearbox..................125Ground clearance...................................31, 227Guidance...............................................240,248Guide-me-home ............................................146
Identification plates.......................................228Ignition.............................................................27Ignition on........................................................27Indicator lamps, status..............................48, 53Indicators, direction......................................167Inflating accessories (using the kit).............................................. 179Inflating tyres..................................................37Instrument panel.............................................45Instrument panels...........................................46Instrument panel screen.................................46Instruments and controls................................12
Intelligent Traction Control............................170Interior fittings .................................................95Interior mood lighting....................................156ISOFIX child seats .................................163-165ISOFIX mountings.........................................163
Jack...............................................................185JBL (audio system).........................................9, 231
F
GI
J
Electronic engine immobiliser...................r27, 73Emergency boot release .................................81Emergency call.....................................168, 230Emergency warning lamps ...................101, 167Energy economy mode .................................204Engine, Diesel.................85, 216, 217,225,226Engine compartment...............................43, 217Engine compar tment fusebox.......................197Engine oil level indicator.........................r61,218Engines .................................................224-226Environment..........................................5, 37,72
Halogen headlamps ..............................190,192Hands-free kit................................................257Hazard warning lamps ..........................101,167Head-up display............................130, 133,135Headlamp adjustment ...................................149Headlamps, directional .........................150,190Headlamp wash ............................................152Headlamp wash reser voir.............................r219Head restraints, front......................................88Head restraints, rear.......................................r90Heated seats...................................................88Heating...............................17, 37,106,114, 117Height and reach adjustment,steering wheel..............................................94High load retaining net..................................102High voltage ................40-42, 99,174,202, 215High voltage cable..........................................41Hill start assist...............................................129History.......................................................39,63Hybrid .....................................4,22, 29,33, 201Hybrid flow ............................................4,22, 33Hybrid selector................................................r29Hybrid system ...............................4,22, 23, 237
H
Keeping children safe...........157,164,165, 175Key..........................................65, 66, 68, 71, 73Key, electronic...............................28, 65-68, 71Keyless Entry and Star ting................65, 66, 73Key not recognised .........................................28Key with remote control ..................................27
K