2012 Lancia Thema towing

CAUTION!(Continued)
 Do not push or tow this vehicle
with another vehicle as damage to
the bumper fascia and transmis-
sion may result.
 If the vehicle being towed requires
steering. the ignition switch must
be in the ON/RUN position, not
the LOCK or ACC positions.
The manufacturer does not recom-
mend that you tow this vehicle on a
tow dolly. Vehicle damage may occur.
The manufacturer recommends tow-
ing your vehicle with all four wheels
OFF the ground using a flatbed.
If flatbed equipment is not available,
and the transmission is operable, the
vehicle may be flat towed (with all
four wheels on the ground) under the
following conditions:
 The shift lever must be in NEU- TRAL.  The distance to be traveled must
not exceed 24 km for 5-speed
transmission, or 48 km for 8-speed
transmission.
 The towing speed must not exceed 48 km/h.
If the transmission is not operable, or
the vehicle must be towed faster than
48 km/h or farther than 24 km for
5-speed transmission, or 48 km for
8-speed transmission, tow with the
rear wheels OFF the ground (on a
flatbed, or with the rear wheels raised
using a wheel lift and the transmission
in NEUTRAL).
CAUTION!
Failure to follow these towing meth-
ods can cause severe transmission
damage. Such damage is not covered
by the New Vehicle Limited War-
ranty. Without The Ignition Key
Special care must be taken when the
vehicle is towed with the ignition in
the OFF position. The only approved
method of towing without the ignition
key is with a flatbed truck. Proper
towing equipment is necessary to pre-
vent damage to the vehicle.
252

ONBOARD DIAGNOSTIC
SYSTEM — OBD II
Your vehicle is equipped with a so-
phisticated onboard diagnostic sys-
tem called OBD II. This system moni-
tors the performance of the emissions,
engine, and automatic transmission
control systems. When these systems
are operating properly, your vehicle
will provide excellent performance
and fuel economy, as well as engine
emissions well within current govern-
ment regulations.
If any of these systems require service,
the OBD II system will turn on the
“Malfunction Indicator Light (MIL).”
It will also store diagnostic codes and
other information to assist your ser-
vice technician in making repairs. Al-
though your vehicle will usually be
drivable and not need towing, see
your authorized dealer for service as
soon as possible.
CAUTION!
 Prolonged driving with the MILon could cause further damage to
the emissions control system. It
could also affect fuel economy
and driveability. The vehicle must
be serviced before any emissions
tests can be performed.
 If the MIL is flashing while the
engine is running, severe catalytic
converter damage and power loss
will soon occur. Immediate service
is required.
REPLACEMENT PARTS
Use of genuine parts for normal/
scheduled maintenance and repairs is
highly recommended to ensure the de-
signed performance.
Damage or failures caused by the use
of parts which are not quality-
equivalent to genuine parts for main-
tenance and repairs will not be cov-
ered by the manufacturer’s warranty. MAINTENANCE
PROCEDURES
The pages that follow contain the
re-
quired maintenance services deter-
mined by the engineers who designed
your vehicle.
Besides those maintenance items
specified in the fixed maintenance
schedule, there are other components
which may require servicing or re-
placement in the future.
CAUTION!
 Failure to properly maintain your vehicle or perform repairs and
service when necessary could re-
sult in more costly repairs, dam-
age to other components or nega-
tively impact vehicle
performance. Immediately have
potential malfunctions examined
by an authorized dealership or
qualified repair center.
(Continued)
257

NOTE:
Intentional tampering with emis-
sions control systems can result in
civil penalties being assessed
against you.WARNING!
A hot exhaust system can start a fire
if you park over materials that can
burn. Such materials might be grass
or leaves coming into contact with
your exhaust system. Do not park or
operate your vehicle in areas where
your exhaust system can contact
anything that can burn.
In unusual situations involving
grossly malfunctioning engine opera-
tion, a scorching odor may indicate
severe and abnormal catalyst over-
heating. If this should occur, safely
bring the vehicle to a complete stop,
shut the engine OFF, and allow the
vehicle to cool. Thereafter, obtain ser-
vice, including a tune-up to manufac-
tur er's specifications immediately.
To minimize the possibility of catalyst
damage:  Do not shut off the engine or inter
-
rupt the ignition when the trans-
mission is in gear and the vehicle is
in motion.
 Do not try to start the engine by pushing or towing the vehicle.
 Do not idle the engine with any spark plug wires disconnected or
removed, such as when diagnostic
testing, or for prolonged periods
during very rough idling or mal-
functioning operating conditions.
COOLING SYSTEM
WARNING!
 When working near the radiator cooling fan, disconnect the fan
motor lead or turn the ignition
switch to the LOCK position . The
fan is temperature controlled and
can start at any time the ignition
switch is in the ON position.
(Continued)
WARNING!(Continued)
 You or others can be badly burned
by hot engine coolant (antifreeze)
or steam from your radiator. If
you see or hear steam coming
from under the hood, do not open
the hood until the radiator has
had time to cool. Never try to open
a cooling system pressure cap
when the radiator is hot.CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we do
recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
Coolant Checks
Check engine coolant (antifreeze)
protection every 12 months (before
the onset of freezing weather, where
applicable). If the engine coolant (an-
tifreeze) is dirty or rusty in appear-
ance, the system should be drained,
265

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Replace spark plugs. 
Replace air filter cartridge.    
Change engine oil and replace oil filter. Every 12.000 km or 12 months whichever comes first
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 000 km
or 48 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);  operation of windshield washer/
wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
292

(*) Change the automatic transmis-
sion fluid and filter(s) at 100 000 km
or 60 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
(**) The actual oil and oil filter re-
placement interval depends on the car
usage conditions and is indicated by a
warning light or message on the in-
strument panel, or in any case every
12 months.
Periodic Checks
Every1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner filter.
295

Through Flowing, Rising, or
Shallow Standing Water . . . 204
Driving to Achieve Maximum
Fuel Economy . . . . . . . . . . . . 165
Electric Rear Window
Defrost . . . . . . . . . . . . . . . . . 145
Electric Remote Mirrors . . . . . . 64
Electrical Power Outlets . . . . . 140
Electronic Brake Control
System . . . . . . . . . . . . . . . . . 209
Anti-Lock Brake System . . . 209
Brake Assist System . . . . . . 209
Traction Control System . . . 209
Electronic Power Distribution
Center (Fuses) . . . . . . . . . . . . 274
Electronic Speed Control
(Cruise Control) . . . . . . . 115,117
Electronic Stability Control
(ESC) . . . . . . . . . . . . . . . . . . 210
Electronic Vehicle Information
Center (EVIC) . . . . . . . . 134,159
Emergency Deck Lid Release . . 25
Emergency Trunk Release . . . . 25
Emergency, In Case of Freeing Vehicle When
Stuck . . . . . . . . . . . . . . . . 248
Hazard Warning Flasher . . . 240
Jump Starting . . . . . . . . . . 246 Overheating . . . . . . . . . . . . 240
Towing . . . . . . . . . . . . . . . 251
Engine Air Cleaner . . . . . . . . . . . . 259
Break-In Recommendations . . 50
Compartment . . . . . . . 255,256
Compartment
Identification . . . . . . . . 255,256
Coolant (Antifreeze) . . . 265,284
Cooling . . . . . . . . . . . . . . . 265
Exhaust Gas Caution . . . . . . 51
Fails to Start . . . . . . . . . . . 192
Flooded, Starting . . . . . . . . 192
Fuel Requirements . . . . . . . 223
Jump Starting . . . . . . . . . . 246
Oil . . . . . . . . . . . . 258,283,284
Oil Change Interval . . . 164,258
Oil Disposal . . . . . . . . . . . . 259
Oil Filter . . . . . . . . . . . . . . 259
Oil Selection . . . . . 258,259,283
Oil Synthetic . . . . . . . . . . . 259
Overheating . . . . . . . . . . . . 240
Starting . . . . . . . . . . . . . . . 191
Temperature Gauge . . . . . . 159
Enhanced Accident Response
Feature . . . . . . . . . . . . . . . . . . 39
Entry System, Illuminated . . . . 16
Ethanol . . . . . . . . . . . . . . . . 224
Event Data Recorder . . . . . . . . 41 Exhaust Gas Caution . . . . . 51,264
Exhaust System . . . . . . . . 51,264
Exterior Folding Mirrors . . . . . . 63
Exterior Lighting . . . . . . . . . . 104
Exterior Lights . . . . . . . . . . . . 53
Filler Location Fuel . . . . . . . . 156
Filters
Air Cleaner . . . . . . . . . . . . 259
Air Conditioning . . . . . 185,261
Engine Oil . . . . . . . . . . 259,284
Flash-To-Pass . . . . . . . . . . . . 108
Flashers Hazard Warning . . . . . . . . . 240
Turn Signal . . . . . . . 53,107,154
Flooded Engine Starting . . . . . 192
Floor Console . . . . . . . . . . . . 143
Fluid Capacities . . . . . . . . . . . 283
Fluid Leaks . . . . . . . . . . . . . . 53
Fluid Level Checks Automatic Transmission . . . 270
Brake . . . . . . . . . . . . . . . . 269
Cooling System . . . . . . . . . 265
Engine Oil . . . . . . . . . . . . . 258
Fluid, Brake . . . . . . . . . . . . . 285
Fluids . . . . . . . . . . . . . . . . . . 284
Fluids, Lubricants and
Genuine Parts . . . . . . . . . . . . 284
Fog Lights . . . . . . . . . . . . . . 154
300

Door Locks . . . . . . . . . . . . . 19
Mirrors . . . . . . . . . . . . . . . . 64
Outlet (Auxiliary Electrical
Outlet) . . . . . . . . . . . . . . . 140
Seats . . . . . . . . . . . . . . . . . . 96
Steering . . . . . . . . . . . . . . . 206
Sunroof . . . . . . . . . . . . 136,138
Tilt/Telescoping Steering
Column . . . . . . . . . . . . . . . 113
Windows . . . . . . . . . . . . . . . 22
Power Steering Fluid . . . . . . . 285
Pregnant Women and Seat
Belts . . . . . . . . . . . . . . . . . . . . 33
Pretensioners Seat Belts . . . . . . . . . . . . . . 30
Programming Transmitters
(Remote Keyless Entry) . . . . . . 16
Radial Ply Tires . . . . . . . . . . . 215
Radiator Cap (Coolant
Pressure Cap) . . . . . . . . . . . . 267
Radio (Sound Systems) . . . . . 177
Radio Operation . . . . . . . . . . 180
Radio Remote Controls . . . . . . 179
Rain Sensitive Wiper System . . 111
Rear Camera . . . . . . . . . . . . . 134
Rear Cupholder . . . . . . . . . . . 142
Rear Fog Lights . . . . . . . . . . . 107
Rear Park Sense System . . . . . 129 Rear Seat, Folding . . . . . . . . . 101
Rear Window Defroster . . . . . 145
Rear Window Features . . . . . . 145
Recorder, Event Data . . . . . . . . 41
Recreational Towing . . . . . . . . 237
Refrigerant . . . . . . . . . . . . . . 261
Reminder, Lights On . . . . . . . 107
Reminder, Seat Belt . . . . . . . . . 32
Remote Keyless Entry (RKE) . . 16
Remote Sound System (Radio)
Controls . . . . . . . . . . . . . . . . 179
Remote Trunk Release . . . . . . . 24
Replacement Bulbs . . . . . . . . 280
Replacement Keys . . . . . . . . . . 14
Replacement Parts . . . . . . . . . 257
Replacement Tires . . . . . . . . . 217
Resetting Oil Change
Indicator . . . . . . . . . . . . 154,164
Restraint, Head . . . . . . . . . . . . 99
Restraints, Child . . . . . . . . . . . 42
Restraints, Occupant . . . . . . . . 25
Rocking Vehicle When Stuck . . 248
Rotation, Tires . . . . . . . . . . . . 219
Safety Checks Inside Vehicle . . . 51
Safety Checks Outside Vehicle . . 53
Safety Tips . . . . . . . . . . . . . . . 50
Safety, Exhaust Gas . . . . . . . . . 51
Schedule, Maintenance . . 290,293Seat Belt Maintenance . . . . . . 274
Seat Belt Reminder . . . . . . . . . 32
Seat Belts . . . . . . . . . . . 25,26,51
Adjustable Upper Shoulder
Anchorage . . . . . . . . . . . . . . 28
And Pregnant Women . . . . . . 33
Child Restraint . . . . . . 42,45,49
Front Seat . . . . . . . . . . . . 26,27
Inspection . . . . . . . . . . . . . . 51
Operating Instructions . . . . . 27
Pretensioners . . . . . . . . . . . . 30
Rear Seat . . . . . . . . . . . . . . . 26
Untwisting Procedure . . . . . . 29
Seats . . . . . . . . . . . . . . . . . . . 96 Adjustment . . . . . . . . . . . . . 96
Easy Entry . . . . . . . . . . . . 103
Head Restraints . . . . . . . . . . 99
Height Adjustment . . . . . . . . 96
Memory . . . . . . . . . . . . . . . 101
Power . . . . . . . . . . . . . . . . . 96
Rear Folding . . . . . . . . . . . 101
Seatback Release . . . . . . . . 101
Tilting . . . . . . . . . . . . . . . . . 96
Selection of Coolant
(Antifreeze) . . . . . . . . . . 266,284
Selection of Oil . . . . . . . . . . . 259
Sentry Key (Immobilizer) . . . . . 13
Sentry Key Programming . . . . . 14
Sentry Key Replacement . . . . . . 14
304

Service Engine Soon Light
(Malfunction Indicator) . . . . . 156
Setting the Clock . . . . . . . . . . 178
Shift Lever Override . . . . . . . 249
Shifting . . . . . . . . . . . . . . . . 195Automatic Transmission . . . 195
Shoulder Belt Upper
Anchorage . . . . . . . . . . . . . . . 28
Shoulder Belts . . . . . . . . . . . . . 26
Side Airbag . . . . . . . . . . . . . . . 39
Side View Mirror Adjustment . . 63
Signals, Turn . . . . . . . 53,107,154
Slippery Surfaces, Driving On . 204
SmartBeams . . . . . . . . . . . . . 106
Snow Chains (Tire Chains) . . . 218
Sound System Kicker . . . . . . . . . . . . . . . . 178
Sound Systems . . . . . . . . . . . 177
Sound Systems (Radio) . . . . . 177
Spare Tire . . . . . . . . . . . . . . . 216
Spark Plugs . . . . . . . . . . . . . 284
Specifications Fuel (Gasoline) . . . . . . 223,284
Oil . . . . . . . . . . . . . . . 259,284
Speed Control
(Cruise Control) . . . . . . . 115,117
Speedometer . . . . . . . . . . . . . 156
Starting . . . . . . . . . . . . . . . . 191 Automatic Transmission . . . 191 Cold Weather . . . . . . . . . . . 192
Engine Fails to Start . . . . . . 192
Starting and Operating . . . . . . 191
Starting Procedures . . . . . . . . 191
Steering Column Controls . . . . . . . . 107
Column Lock . . . . . . . . . . . 112
Power . . . . . . . . . . . . . . . . 206
Tilt Column . . . . . . . . . 112,113
Wheel, Heated . . . . . . . . . . 114
Wheel, Tilt . . . . . . . . . 112,113
Steering Wheel Audio
Controls . . . . . . . . . . . . . . . . 179
Steering Wheel Mounted Sound
System Controls . . . . . . . . . . . 179
Storage . . . . . . . . . . . . . 143,279
Storage, Vehicle . . . . . . . 185,279
Storing Your Vehicle . . . . . . . . 279
Stuck, Freeing . . . . . . . . . . . . 248
Sun Roof . . . . . . . . . . . . 136,138
Sunglasses Storage . . . . . . . . . 135
Supplemental Restraint System
- Airbag . . . . . . . . . . . . . . . . . 33
Sway Control, Trailer . . . . . . . 229
Synthetic Engine Oil . . . . . . . 259
System, Navigation
(Uconnect™ gps) . . . . . . . . . . 177
Tachometer . . . . . . . . . . . . . . 154 Telescoping Steering
Column . . . . . . . . . . . . . 112,113
Temperature Control,
Automatic (ATC) . . . . . . . . . . 184
Temperature Gauge, Engine
Coolant . . . . . . . . . . . . . 159,240
Tether Anchor, Child Restraint
. . 46
Tilt Steering Column . . . . 112,113
Time Delay, Headlight . . . . . . 105
Tires . . . . . . . . . . . . . . . . 53,214 Aging (Life of Tires) . . . . . . 217
Air Pressure . . . . . . . . . . . . 214
Chains . . . . . . . . . . . . . . . . 218
Compact Spare . . . . . . . . . . 216
General Information . . . . . . 214
High Speed . . . . . . . . . . . . 215
Inflation Pressures . . . . . . . 214
Life of Tires . . . . . . . . . . . . 217
Pressure Monitor System
(TPMS) . . . . . . . . . . . . . . . 219
Pressure Warning Light . . . . 155
Radial . . . . . . . . . . . . . . . . 215
Replacement . . . . . . . . . . . 217
Rotation . . . . . . . . . . . . . . 219
Safety . . . . . . . . . . . . . . . . 214
Spinning . . . . . . . . . . . . . . 216
Trailer Towing . . . . . . . . . . 232
Tread Wear Indicators . . . . . 217
305