2012 Lancia Flavia fuel cap

Vehicle Odometer Messages
When the appropriate conditions ex-
ist, the odometer will display the fol-
lowing messages:
LoW tirE. . . . . . Low Tire Pressure
HOTOIL . . Engine Oil Temperature
Exceeds Safe Threshold
gASCAP . . . . . . . . . Fuel Cap Fault
CHANgE OIL . Oil Change Required
noFUSE . . . . . IOD Fuse Is Missing
no buS . . . . Cluster Does Not Have
Communication With The CAN BUS.
NOTE:
Warnings such as ”Low Tire,”
“Door Ajar” and “Trunk Ajar” will
display in the EVIC. (Refer to
“Electronic Vehicle Information
Center (EVIC)” for specific mes-
sages).
LoW tirE
When the appropriate condition ex-
ists, the odometer display will toggle
between LoW and TirE for three
cycles. HOTOIL
When this message is displayed there
is a engine oil over-temperature con-
dition. When this condition occurs,
the “HOTOIL” message will be dis-
played in the odometer along with a
chime.
Refer to “If Your Engine Overheats”
in “What To Do In Emergencies”.
CHAngE OIL
Your vehicle is equipped with an en-
gine oil change indicator system. The
“CHAngE OIL” message will flash in
the instrument cluster odometer for
approximately 12 seconds after a
single chime has sounded to indicate
the next scheduled oil change inter-
val. The engine oil change indicator
system is duty cycle based, which
means the engine oil change interval
may fluctuate dependent upon your
personal driving style.
Unless reset, this message will con-
tinue to display each time you turn the
ignition switch to the “ON/RUN” po-
sition. To turn off the message tempo-
rarily, press and release the Trip
Odometer button on the instrumentcluster. To reset the oil change indica-
tor system (after performing the
scheduled maintenance) perform the
following procedure:
1. Turn the ignition switch to the
ON/RUN position (do not start the
engine).
2. Fully depress the accelerator
pedal slowly 3 times within 10 sec-
onds.
3. Turn the ignition switch to the
LOCK position.
NOTE:
If the indicator message illumi-
nates when you start the vehicle,
the oil change indicator system did
not reset. If necessary, repeat this
procedure. 4. For vehicles equipped with the
Electronic Vehicle Information
Center (EVIC), refer to “Electronic
Vehicle Information Center
(EVIC)”.
110

Certain conditions, such as a loose or
missing gas cap, poor fuel quality,
etc., may illuminate the light after
engine start. The vehicle should be
serviced if the light stays on through
several of your typical driving cycles.
In most situations, the vehicle will
drive normally and will not require
towing.CAUTION!
Prolonged driving with the MIL on
could cause damage to the engine
control system. It also could affect
fuel economy and drivability. If the
MIL is flashing, severe catalytic con-
verter damage and power loss will
soon occur. Immediate service is re-
quired.
WARNING!
A malfunctioning catalytic con-
verter, as referenced above, can
reach higher temperatures than in
normal operating conditions. This
can cause a fire if you drive slowly or
park over flammable substances
such as dry plants, wood, cardboard,
etc. This could result in death or
serious injury to the driver, occu-
pants or others.
27. Transmission Temperature
Warning Light This light indicates that the
transmission fluid tempera-
ture is running hot. This
may occur with severe us-
age, such as trailer towing. If this light
turns on, safely pull over and stop the
vehicle. Then, shift the transmission
into NEUTRAL and run the engine at
idle or faster until the light turns off.
CAUTION!
Continuous driving with the Trans-
mission Temperature Warning Light
illuminated will eventually cause se-
vere transmission damage or trans-
mission failure.WARNING!
If the Transmission Temperature
Warning Light is illuminated and
you continue operating the vehicle,
in some circumstances you could
cause the fluid to boil over, come in
contact with hot engine or exhaust
components and cause a fire.
28. High Beam Indicator This light indicates that the
headlights are on high beam.
Pull the turn signal lever to-
ward the steering wheel to switch the
headlights to low beam.
114

 METHANOL . . . . . . . . . . . . . . . . . . . . . . . . . . 159
 ETHANOL . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
 CLEAN AIR GASOLINE . . . . . . . . . . . . . . . . . 159
 MMT IN GASOLINE . . . . . . . . . . . . . . . . . . . . 159
 MATERIALS ADDED TO FUEL . . . . . . . . . . . 160
 ADDING FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . 160  FUEL FILLER CAP (GAS CAP) . . . . . . . . . . . . 160
 LOOSE FUEL FILLER CAP MESSAGE . . . . . . 161
 VEHICLE LOADING . . . . . . . . . . . . . . . . . . . . . 161  VEHICLE CERTIFICATION LABEL . . . . . . . . 161
 GROSS VEHICLE WEIGHT RATING(GVWR) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
 GROSS AXLE WEIGHT RATING (GAWR) . . . . 162
 OVERLOADING . . . . . . . . . . . . . . . . . . . . . . . 162
 LOADING . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
 TRAILER TOWING . . . . . . . . . . . . . . . . . . . . . . 162
 RECREATIONAL TOWING (BEHIND MOTORHOME, ETC) . . . . . . . . . . . . . . . . . . . . . 163
 TOWING THIS VEHICLE BEHIND ANOTHER VEHICLE . . . . . . . . . . . . . . . . . . . 163
 RECREATIONAL TOWING – ALL MODELS . . 163
133

MATERIALS ADDED TO
FUEL
Besides using unleaded gasoline with
the proper octane rating, gasolines
that contain detergents, corrosion and
stability additives are recommended.
Using gasolines that have these addi-
tives will help improve fuel economy,
reduce emissions, and maintain ve-
hicle performance.
Indiscriminate use of fuel system
cleaning agents should be avoided.
Many of these materials intended for
gum and varnish removal may con-
tain active solvents or similar ingredi-
ents. These can harm fuel system gas-
ket and diaphragm materials.WARNING!
Carbon monoxide (CO) in exhaust
gases is deadly. Follow the precau-
tions below to prevent carbon mon-
oxide poisoning:(Continued)
WARNING!(Continued)
 Do not inhale exhaust gases. They
contain carbon monoxide, a color-
less and odorless gas, which can
kill. Never run the engine in a
closed area, such as a garage, and
never sit in a parked vehicle with
the engine running for an ex-
tended period. If the vehicle is
stopped in an open area with the
engine running for more than a
short period, adjust the ventila-
tion system to force fresh, outside
air into the vehicle.
Guard against carbon monoxide
with proper maintenance. Have the
exhaust system inspected every
time the vehicle is raised. Have any
abnormal conditions repaired
promptly. Until repaired, drive
with all side windows fully open.
ADDING FUEL
FUEL FILLER CAP (GAS
CAP)
The gas cap is behind the fuel filler
door, on the left rear quarter panel of
the vehicle. If the gas cap is lost or damaged, be sure the replacement cap
is for use with this vehicle.
After removing the gas cap, place the
gas cap tether cable over a hook on
the inside of the fuel door. This keeps
the gas cap suspended away from and
protects the
vehicle's surface.
Fuel Filler DoorTether Cable
160

NOTE:
If the gas cap is lost or damaged, be
sure the replacement cap is for use
with this vehicle.CAUTION!
 Damage to the fuel system oremission control system could r e-
sult from using an improper fuel
tank filler tube cap (gas cap).
 A poorly fitting gas cap may cause
the “Malfunction Indicator Light
(MIL)” to turn on.
 To avoid fuel spillage and overfill-
ing, do not “top off” the fuel tank
after filling. When the fuel nozzle
“clicks” or shuts off, the fuel tank
is full.WARNING!
 Never have any smoking materi-als lit in or near the vehicle when
the gas cap is removed or the tank
is being filled.
(Continued)
WARNING!(Continued)
 A fire may result if gasoline is
pumped into a portable container
that is inside of a vehicle. You
could be burned. Always place gas
containers on the ground while
filling.
NOTE:
 Tighten the gas cap until you hear a “clicking” sound. This is
an indication that the gas cap is
tightened properly. The MIL in
the instrument cluster may turn
on if the gas cap is not secured
properly. Make sure that the gas
cap is tightened each time the
vehicle is refueled.
 When the fuel nozzle “clicks” or shuts off, the fuel tank is full.
LOOSE FUEL FILLER CAP
MESSAGE
If the vehicle diagnostic system deter-
mines that the fuel filler cap is loose,
improperly installed, or damaged, a
“CHECK GAS CAP” message will be
displayed in the EVIC (Electronic Ve-
hicle Information Center). Refer to “Electronic Vehicle Information Cen-
ter” in “Understanding Your Instru-
ment Panel” for further information.
Tighten the fuel filler cap properly
and press the odometer reset button to
turn the message off. If the problem
continues, the message will appear
the next time the vehicle is started.
Refer to “Onboard Diagnostic Sys-
tem” in “Maintaining Your Vehicle”
for further information.
NOTE:
If the gas cap is lost or damaged, be
sure the replacement cap is for use
with this vehicle.
VEHICLE LOADING
VEHICLE CERTIFICATION
LABEL
Your vehicle has a certification label
attached to the rear of the
driver's
door.
The label contains the following infor -
mation:
 Name of manufacturer
 Month and year of manufacture
161

FLUID CAPACITIES
Metric
Fuel (Approximate)
All 64 Liters
Engine Oil with Filter
2.4L Engine 4.4 Liters
Cooling System*
2.4L Engine 7.3 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
FLUIDS, LUBRICANTS, AND GENUINE PARTS
ENGINE
Component Fluids and Lubricants Specs (Genuine Parts)
Engine Coolant* Contact a LANCIA Dealership.
Engine Oil** SAE 5W-20 grade totally synthetic lubricant that meets FIAT Classification
9.55535-CR1, API SN, ILSAC GF-5 (SELENIA K POWER, Contractual Tech-
nical Reference N° F102.F11)
Spark Plugs ZFR5F-11 (Gap 1.1 mm)
Fuel Selection 91 Octane or higher
* Do not top up or mix with fluids
with different specifications.
** In the event of an emergency in
which the original products are not
available, lubricants with at least IL-
SAC GF-5 performance are accept- able. In this case optimum engine per-
formance is not guaranteed and the
lubricants should be replaced with
recommended products as soon as
possible at a LANCIA Dealership.
The use of products with features
lower than ILSAC GF-5 could cause
engine damage not covered by the
warranty.
206

Capacities, Antifreeze
(Engine Coolant) . . . . . . . . . . . 16
Capacities, Fluid . . . . . . . . . . 206
Caps, FillerFuel . . . . . . . . . . . . . . . . . 160
Oil (Engine) . . . . . . . . . . . . 181
Power Steering . . . . . . . . . . 144
Radiator
(Coolant Pressure) . . . . . . . 192
Car Washes . . . . . . . . . . . . . . 196
Carbon Monoxide Warning . . . . 45
Cellular Phone . . . . . . . . . 65,123
Chains, Tire . . . . . . . . . . . . . 154
Checking Your Vehicle For
Safety . . . . . . . . . . . . . . . . . . . 45
Checks, Safety . . . . . . . . . . . . . 45
Child Restraint . . . . . 37,39,41,43
Child Restraint Tether
Anchors . . . . . . . . . . . . . . . 40,41
Cigar Lighter . . . . . . . . . . . . 100
Clean Air Gasoline . . . . . . . . . 159
Cleaning Wheels . . . . . . . . . . . . . . . 197
Windshield Wiper Blades . . . 188
Climate Control . . . . . . . . . . . 123
Clock . . . . . . . . . . . . . . . . . . 122
Coin Holder . . . . . . . . . . . . . 101
Compass . . . . . . . . . . . . . . . . 117
Compass Calibration . . . . . . . 118 Compass Variance . . . . . . . . . 118
Computer, Trip/Travel . . . . 16,117
Console, Floor . . . . . . . . . . . . 101
Convertible . . . . . . . . . . . . . . . 53
Convertible Top . . . . . . . . . . . . 53
Coolant Pressure Cap
(Radiator Cap) . . . . . . . . . . . 192
Cooling System . . . . . . . . . . . 190
Adding Coolant
(Antifreeze) . . . . . . . . . . . . 191
Coolant Capacity . . . . . . . . 206
Coolant Level . . . . . . . 190,192
Disposal of Used Coolant . . . 192
Drain, Flush, and Refill . . . . 191
Inspection . . . . . . . . . . . . . 192
Points to Remember . . . . . . 193
Pressure Cap . . . . . . . . . . . 192
Radiator Cap . . . . . . . . . . . 192
Selection of Coolant
(Antifreeze) . . . . . . . . . 191,206
Corrosion Protection . . . . . . . 196
Crankcase Ventilation Module . . 16
Cruise Light . . . . . . . . . . . . . 111
Cupholders . . . . . . . . . . . 100,198
Customer Programmable
Features . . . . . . . . . . . . . . . . 121
Data Recorder, Event . . . . . . . . 36
Deck Lid, Emergency Release . . 21 Deck Lid, Power Release . . . . . 20
Defroster, Rear Window . . . . . 102
Defroster, Windshield . . . . 46,126
Delay (Intermittent) Wipers . . . 95
Diagnostic System, Onboard . . 182
Diesel Fuel . . . . . . . . . . . . . . 206
Dimmer Switch, Headlight . . . . 93
Dipsticks
Automatic Transmission . . . 195
Oil (Engine) . . . . . . . . . . . . 183
Power Steering . . . . . . . . . . 144
Disabled Vehicle Towing . . . . . 176
Disposal Antifreeze
(Engine Coolant) . . . . . . . . 192
Engine Oil . . . . . . . . . . . . . 184
Door Locks . . . . . . . . . . . . . . . 18
Door Locks, Automatic . . . . . . 18
Driver's Seat Back Tilt . . . . . . . 88
Driving On Slippery Surfaces . . . . . 142
Through Flowing, Rising, or
Shallow Standing Water . . . 142
Electric Rear Window
Defrost . . . . . . . . . . . . . . . . . 102
Electric Remote Mirrors . . . . . . 64
Electrical Power Outlets . . . . . . 98
217

Electronic Speed Control
(Cruise Control) . . . . . . . . . . . 97
Electronic Stability Control
(ESC) . . . . . . . . . . . . . . . . . . 149
Electronic Vehicle Information
Center (EVIC) . . . . . . . . . . . . 115
Emergency Deck Lid Release . . 21
Emergency Trunk Release . . . . 21
Emergency, In Case ofJump Starting . . . . . . . . . . 172
Towing . . . . . . . . . . . . . . . 176
Engine . . . . . . . . . . . . . . . . . 181 Air Cleaner . . . . . . . . . . . . 184
Break-In Recommendations . . 44
Checking Oil Level . . . . . . . 183
Coolant (Antifreeze) . . . 190,206
Cooling . . . . . . . . . . . . . . . 190
Exhaust Gas Caution . . . . . . 45
Fails to Start . . . . . . . . . . . 134
Flooded, Starting . . . . . . . . 134
Fuel Requirements . . . . 158,206
Jump Starting . . . . . . . . . . 172
Oil . . . . . . . . . . . . . . . 183,206
Oil Change
Interval . . . . . . . . 110,117,183
Oil Filler Cap . . . . . . . . . . . 181
Oil Filter . . . . . . . . . . . . . . 184
Oil Filter Disposal . . . . . . . 184
Oil Selection . . . . . . . . . . . 206 Oil Synthetic . . . . . . . . . . . 184
Overheating . . . . . . . . . . . . 166
Starting . . . . . . . . . . . . . . . 134
Temperature Gauge . . . . . . 107
Enhanced Accident Response
Feature . . . . . . . . . . . . . . . . . . 34
Entry System, Illuminated . . . . 16
Ethanol . . . . . . . . . . . . . . . . 159
Event Data Recorder . . . . . . . . 36
Exhaust Gas Caution . . . . . . . . 45
Exhaust System . . . . . . . . 45,189
Exterior Lights . . . . . . . . . . . . 47
Filler Location Fuel . . . . . 107,160
Filters Air Cleaner . . . . . . . . . . . . 184
Air Conditioning . . . . . 128,186
Automatic Transmission . . . 195
Engine Oil . . . . . . . . . . 184,206
Engine Oil Disposal . . . . . . 184
Flash-To-Pass . . . . . . . . . . . . . 93
Flashers . . . . . . . . . . . . . . . . 166 Hazard Warning . . . . . . . . . 166
Turn Signal . . . . . . . 47,93,205
Flooded Engine Starting . . . . . 134
Floor Console . . . . . . . . . . . . 101
Fluid Capacities . . . . . . . . . . . 206
Fluid Leaks . . . . . . . . . . . . . . 47 Fluid Level Checks
Automatic Transmission . . . 195
Brake . . . . . . . . . . . . . 194,207
Cooling System . . . . . . . . . 190
Engine Oil . . . . . . . . . . . . . 183
Power Steering . . . . . . 144,207
Fluid, Brake . . . . . . . . . . . . . 207
Fluids . . . . . . . . . . . . . . . . . . 206
Fluids, Lubricants and
Genuine Parts . . . . . . . . . . . . 206
Fog Light Service . . . . . . . . . . 204
Fog Lights . . . . . . . 91,92,112,204
Freeing A Stuck Vehicle . . . . . 174
Fuel . . . . . . . . . . . . . . . . . . . 158 Additives . . . . . . . . . . . . . . 160
Diesel . . . . . . . . . . . . . . . . 206
Ethanol . . . . . . . . . . . . . . . 159
Filler Cap (Gas Cap) . . 107,160
Filler Door (Gas Cap) . . 107,160
Gasoline . . . . . . . . . . . . . . 158
Gauge . . . . . . . . . . . . . . . . 107
Light . . . . . . . . . . . . . . . . . 107
Octane Rating . . . . . . . 158,206
Requirements . . . . . . . 158,206
Specifications . . . . . . . . . . . 206
Tank Capacity . . . . . . . . . . 206
Fuel System Caution . . . . . . . 161
Fuses . . . . . . . . . . . . . . . . . . 200
218