2012 HONDA PILOT ECO mode

Remove the dipstick (yellow loop)
f rom the transmission, and wipe it
with a clean cloth.Insert the dipstick all the way into
the transmission securely as
shown in the illustration.
Remove the dipstick and check
the f luid level. It should be
between the upper and lower
marks.
Check the f luid level with the engine
at normal operating temperature.
Park the vehicle on level ground.
Start the engine, let it run until the
radiator f an comes on, then shut
of f the engine. For accurate
results, wait about 60 seconds (but
no longer than 90 seconds) bef ore
doing step 2.
The transmission should be drained
and ref illed with new f luid when this
service is shown on the inf ormation
display or multi-inf ormation display
(depending on the model). 1.
2.3. 4.
Automatic Transmission Fluid
582
DIPSTICKDIPSTICK
UPPER MARK
LOWER MARK
Main MenuTable of Contents

If your seat belts get dirty, use a sof t
brush with a mixture of mild soap
and warm water to clean them. Do
not use bleach, dye, or cleaning
solvents. Let the belts air-dry bef ore
you use the vehicle.
This f ilter removes the dust and
pollenthatisbroughtinfromthe
outside through the heating and
cooling system/climate control
system.
Dirt build-up in the loops of the seat
belt anchors can cause the belts to
retract slowly. Wipe the insides of
the loops with a clean cloth
dampened in mild soap and warm
water or isopropyl alcohol.
Have your dealer replace the filter
when this service is indicated by a
maintenance message on the
inf ormation display or multi-
inf ormation display (depending on
the model). It should be replaced
every 15,000 miles (24,000 km) if you
drive primarily in urban areas that
have high concentrations of soot in
the air, or if the flow from the
heating and cooling system/climate
control system becomes less than
usual. Cleaning the Seat Belts
Dust and Pollen Filter
Dust and Pollen Filter, Cleaning the Seat Belts
Maint enance
593
LOOP
Main MenuTable of Contents

µµ
ÎÎ Î ÎÎ
Î Î ÎÎ
Î
ÎÎ
ÎÎ Î Î
ÎÎ
Î Î
Specif ications
642 Seating Capacities
Air Conditioning
Dimensions
Weights
Capacities
191.4 in (4,861 mm)
78.5 in (1,995 mm)
70.9 in (1,802 mm)
Total
Front
Second
Third 3
3
2
8
Refrigerant type
Charge quantity
Lubricant type ND-OIL8
21.2 22.9 oz (600 650 g)HFC-134a (R-134a)
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
8,466 lbs (3,840 kg)
Length
Width
Height
Wheelbase
Track
67.5 in (1,715 mm)
67.7 in (1,720 mm)
109.3 in (2,775 mm)
72.7 in (1,846 mm)
9,579 lbs (4,345 kg)
Gross vehicle weight rating
Gross combined weight
rating (GCWR) See the tire information label
attached to the driver’s doorjamb.
Excluding the oil remaining in the engine
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 0.196 US gal (0.74
)
1.98 US gal (7.5
)
2.48 US gal (9.4)
4.5 US qt (4.3
)
4.2 US qt (4.0
)
5.3 US qt (5.0
)
6.9 US qt (6.5
)
4.2 US qt (4.0)
0.48 US qt (0.45
)
0.45 US qt (0.43)
3.01 US qt (2.85
)
Fuel tank
Engine
coolant
Engine oil Automatic
transmission
fluid Rear
differential
fluid (4WD)
Transfer
assembly
fluid (4WD)
Windshield
washer
reservoir
2.79 US qt (2.64)
8.6 US qt (8.1)
3.6 US qt (3.4)
8.6 US qt (8.1)
3.6 US qt (3.4
)
3.3 US qt (3.1)
8.0 US qt (7.6
)
21.00 US gal (79.5
)
Front Rear
U.S. vehicles
Canadian
vehicles
1 : 2 : Except U.S. LX models
U.S. LX models
2WD models
1:
2: 3: 4WDmodels
1: 2: 3:4:ChangeTotal
Change
Including
filter
Without
filter
Total
Change Total
Change Total
ChangeTotal
Change Total
2WD
4WD Approx.
Without automatic transmission fluid cooler
With automatic transmission fluid cooler
1
12
23 1 2
44
3 3
Main MenuTable of Contents

T he publications shown below can be purchased f rom Helm
Incorporated. You can order by phone or online:Call Helm Inc. at 1-800-782-4356 (credit card orders only)
Go online at
If you are interested in other years or models, contact Helm Inc.
at 1-800-782-4356.Covers maintenance and recommended procedures f or
repair to engine and chassis components. It is written
f or the journeyman mechanic, but it is simple enough
f or most mechanically inclined owners to understand.
Complements the Service Manual by providing in-depth
troubleshooting inf ormation f or each electrical circuit
in your vehicle.
Describes the procedures involved in the replacement
of damaged body parts.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
Purchasing Factory Authorized Manuals (U.S. only)
Authorized Manuals
661
Publication
Form Number 61SZA03
61SZA03EL
61SZA30
31SZA630 31SZA830
31SZAM30 31SZAQ30
HON Form Description
2012 Honda Pilot Service Manual 2012 Honda Pilot
Electrical Troubleshooting Manual
2012 Honda Pilot Body Repair Manual
2012 Honda Pilot Owner’s Manual
2012 Honda Pilot
Navigation System Owner’s Manual
2012 Honda Pilot Honda Service History
2012 Honda Pilot Technology Reference Guide
Order Form for Previous Years
Indicate Year and Model Desired
www.helminc.com
Main MenuTable of Contents

4WD models only4WD models only
Service Inf ormat ion Summary
Gasoline: Brake Fluid:
Tire Pressure (measured cold):
Rear Differential Fluid:
Automatic Transmission Fluid:
Recommended Engine Oil:
Fuel Tank Capacity: Transfer Assembly Fluid:
Power Steering Fluid: Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Unleaded gasoline, pump octane
number of 87 or higher.
4.5 US qt (4.3
)
Oil change capacity (including
filter):
Premium fuel is recommended
when towing in certain conditions
(see page ).
21.00 US gal (79.5
)
Honda ATF DW-1 (automatic
transmission fluid) (see page ).
API Premium grade 0W-20
detergent oil (see page ).
33 psi (230 kPa , 2.3 kgf/cm
)
Rear: 31 psi (210 kPa , 2.1 kgf/cm
)
Front:
60 psi (420 kPa , 4.2 kgf/cm
)
Compact Spare Tire: 35 psi (240 kPa , 2.4 kgf/cm
)
Front/Rear:
Honda VTM-4 Differential Fluid.
SAE 90 or SAE 80W-90 viscosity
hypoid gear oil, API service
classified GL4 or GL5 only.
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
U.S. LX models:
Except U.S. LX models:
549
576
583 584
585
Main Menu