2012 Citroen DS4 diesel

Running out of fuel
(Diesel)
On vehicle fitted with HDi engines, the fuelsystem must be primed if you run out of fuel; refer to the engine compar tment view on the "Diesel engine" page.


1.6 litre HDi engine
)
Fill the fuel tank with at least five litres of
diesel. )
Open the bonnet.)
If necessary, unclip the styling cover for
access to the priming pump. ) Squeeze and release the priming pump
repeatedly until resistance is felt (there may
be resistance at the first press). ) Operate the star ter until the engine starts(if the engine does not star t at the first
attempt, wait around 15 seconds before
trying again). ) If the engine does not star t after a few
attempts, operate the priming pump again
then start the engine. ) Clip the styling cover back in place. )
Close the bonnet.


If the tank on your vehicle is fitted witha misfuel prevention device, refer to the section "Access - § Misfuel prevention(Diesel)".
2 litre HDi engin e
)Fill the fuel tank with at least five litres of
Diesel.)Open the bonnet. )If necessary, unclip the style cover for access to the priming pump. )Slacken the bleed screw.)Squeeze and release the priming pump repeatedly until fuel appears in the
transparent pipe.
)Tighten the bleed screw. )Operate the star ter until the engine star ts (if the engine fails to star t at the first attempt, wait around 15 seconds before
trying again).)If the engine fails to star t after severalattempts, operate the priming pump again,
then the starter. )Put the style cover back in position andclip it in place, ensuring that it has clippedcorrectly.)Close the bonnet.

If the engine does not star t first time, don't keep trying. Star t the procedureagain from the beginning.

Diesel engines
The various caps and covers allow access for
checking the levels of the various fluids, for replacing cer tain components and for primingthe fuel system.
1.
Power steering reservoir.2.
Screenwash and headlamp wash reservoir.3.
Coolant reser voir. 4.
Brake fluid reservoir.5.
Battery/Fuses.
6.Fusebox.7. Air filter.8.Engine oil dipstick. 9.
Engine oil filler cap.10.Priming pump *
. 11.
Bleed screw *
.
*
Accordin
g to engine.

239Checks
Additive level (Diesel with
particle emissions filter
)
To p p i ng up
The reser voir must be topped up without delay
by a CITROËN dealer or a qualified workshop.

Used products

Avoid prolonged contact of used oil or fluids with the skin.
Most of these fluids are harmful tohealth or indeed very corrosive.

Do not discard used oil or fluids into sewers or onto the ground.
Take used oil to a CITROËN dealer or a qualified workshop (France) or to anauthorised waste disposal site.
)Open the bonnet and secure it withthe stay. )Open the screenwash reservoir filler cap. )Take and pinch the level gauge to block its breather. )Remove the gauge completely from
the reservoir to read the level in the
transparent section. )Top up if necessary. )Refit the filler cap to the reser voir and close the bonnet.

Specifi cation of the fl uid

To ensure optimum cleaning and to avoid
freezing, the fluid should never be topped up or
replaced by plain water. Accordin
g to your version of instrument panel,
the additive reser voir low level is indicated by:
-fixed illumination of the particle emissions filter warning lamp, accompanied by an audible signal anda message that the particle emissionsfilter additive level is too low,
or

- fix
ed illumination of the servicewarning lamp, accompanied by
an au
dible signal and a message
that the par ticle emissions filter additive level is too low.

241Checks
Par ticle emission filter (Diesel)
On a new vehicle, the first operations of regeneration of the par ticle emissions filter may be accompanied by the smell of "burning", w hic h is per fec t ly normal.Following prolonged operation of the vehicle at very low speed or at idle,you may, in exceptional circumstances,notice the emission of water vapour at the exhaust on acceleration. This doesnot affect the behaviour of the vehicleor the environment.
Manual gearbox

The gearbox does not require anymaintenance (no oil change).
Refer to the ser vicing booklet for the
details of the level checking interval for this component.
According to your version of instrument panel, the start of
saturation of the par ticle emissions filter is indicated by:
6-speed electronic gearbox
s
ystem
The gearbox does not require anymaintenance (no oil change).
Refer to the ser vicing booklet for
details of the checking inter val for
this component.
-
temporary illumination of theservice warning lamp, accompanied
b
y an audible signal and a message
that there is a risk of blockage of thepar ticle emissions filter.
-fixed illumination of the particle
emissions filter warning lamp,accompanied by an audible signaland a message that there is a risk of blockage of the particle emissions filter,
or

As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lamp goes off.
If the warning lamp stays on, refer to the
"Additive level" section.
Automatic gearbox
The gearbox does not require anymaintenance (no oil change).
Refer to the ser vicing booklet for
details of the level checking intervalfor this component.

MODELS:ENGINES AND GEARBOXES
Model codes: NX...9HP09HR89HR8/S9HR8/PSRHH8
DIESEL ENGINESHDi 90 PEF HDi 110 PEF HDi 160 PEF

Cubic capacity (cc)
1 560 1 560 1 997
Bore x stroke
(mm)75 x 88.3

75 x 88.3 85 x 88

Max power: EU standard
(kW) 68
82120

Max power engine speed (rpm) 4 0003 600

4 000

Max torque: EU standard
(Nm)
230 270 340
Max torque en
gine speed (rpm) 1 750

1 750

2 000

F
uel
Diesel DieselDiesel
Catal
ytic conver ter yes
yesYes

Particle emissions
filter (PEF) yes
yesYes

GEARBO
X Manual
( 5-speed)
Manual(6-speed)Electronic gearbox system(6-speed)Manual
(6-speed)

OIL CAPACITIES
(in litres)
En
gine (with filter replacement) 3.75 3.753.75
-
.../S
:e-HDi model fitted with Stop & Star t.

Technical data
WEIGHTS AND TOWED LOADS (in kg)
Diesel enginesHDi 90 PEFHDi 110 PEFe-HDi 110 PEFHDi 160 PEF
GearboxManualManualManualElectronic gearbox systemManual
Model codes:NX...9HP09HR89HR8/S9HR8/PSRHH8


- Unladen wei
ght 1 205 1 2901 295 1 3001 320



- Kerb weight 1 280 1 365
1 370 1 375
1 395


-
Gross vehicle weight (GVW)

1 765

1 805

1 8101 815
1 880



-
Gross train weight (GTW)
on a 12 % gradient
2 865
3 105
3 110
3 115
3 180



- Braked trailer
(within GTW limit) on 12 % gradient
1 100
1 300
1 300
1 300 1 300


- Braked trailer
*
(with load transfer with the
GTW limit)
1 3501 550
1 550
1 550
1 550



-
Unbraked trailer 640
680
680680695



- Recommended nose weight 75 75 75 75 75

*

The wei
ght of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount. Warning:
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
The
GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.

385
Visual search
Technical data - Maintenance


Running out of Diesel fuel 234

Checking levels 237-239


- oil

- brake fluid

- coolant

- power steering fluid

- screenwash/headlamp wash fluid
-
additive (Diesel with particle emissions filter)



Changing bulbs 258 -265


- front

- rear


Petrol en
gines 286-287
Diesel engines 288-289
Dimensions 290
Identification markings 291

Bonnet 2
33
Petrol underbonnet 235
Diesel underbonnet 236
Checking components 240 -242
- battery- air filter/passenger compartment filter
- oil filter
- particle emissions filter (Diesel)
- brake pads/discs

Batter
y 271-273
Energy economy mode 274
En
gine compar tment
fuses 266, 269 -270

387
Alphabetical index
Date (setting).........................................339,372Daytime running lamps.................125, 259, 261Deactivating the passenger airbag...............186Defrosting ..................................................87,95Diesel additive level ......................................239Dimensions...................................................290Dipped beam ................................. 124, 259, 260Dipstick....................................................54,237Directional lighting................................131,132Direction indicators.......127,174, 259,260, 263Doors.............................................................112Doors emergency control .............................113Door trays......................................................144
Driving positions (memorising) .......................92Dynamic emergency braking................194, 198
EBA (Emergency braking assistance)..........................................178,179Eco-driving.....................................................34Eco-driving (advice)........................................34Economical driving .........................................34Economy mode .............................................274Electric window controls ...............................115Electronic brake force distribution(EBFD)........................................................ 178Electronic engine immobiliser...............r103, 106Electronic stability control (ESC)..................179Emergency boot release...............................114
Emergency braking system..........................179Emergency call.....................................175,296Emergency warning lamps....................174,175eMyWay..................................................68, 297Energy economy mode.................................274Engine, Diesel.......................119,234, 236, 288Engine, petrol ................................118,235, 286Engine compartment.............................235,236Engine compartment fusebox.......................265Engine oil level indicator...................r54, 57, 237Engines.................................................286, 288Environment............................................34,106Equipment settings.............................40,64, 68ESC/ASR .......................................................179ESP ...............................................................179
D
E
F
Filling with fuel ........................................117-119Fitting a wheel ...............................................254Fitting roof bars .............................................276Fittings, boot................................................. 155Flashing indicators.................127,174, 260,261Foglamps, rear..............................r126,263, 265Front foglamps......................126, 132,259,262Front seats..........................................88,89, 92Fuel...................................................34,118, 119Fuel consumption............................................34Fuel filler flap..........................................117, 119Fuel gauge ....................................................117
Fuel tank.................................................117, 119Fusebox, dashboard.....................................265Fuses.............................................................265
G
G.P.S.............................................................306Gearbox, automatic..............................209, 241Gearbox, electronic.......................205, 214, 241Gearbox, manual..................203, 204, 214, 241Gear efficiency indicator...............................r204Gear lever........................................................34
Gear lever, automatic gearbox .....................209Gear lever, electronic gearbox system .........205Gear lever, manual gearbox.........................203Glove box......................................................145Guidance...............................................304,311Guide-me-home............................................128
H
Halogen headlamps......................................259Hands-free kit........................................320, 363Hazard warning lamps ...........................174, 175Headlamp adjustment ...................................130Headlamps, directional.................130,131, 259Headlamp wash............................................135Head restraints, front......................................90