2012 CHRYSLER 300 fuel cap

Clearing A Flooded Engine (Using ENGINE
START/STOP Button)
If the engine fails to start after you have followed the
“Normal Starting” or “Extreme Cold Weatherproce-
dures, it may be flooded. To clear any excess fuel, press
and hold the brake pedal, push the accelerator pedal all
the way to the floor and hold it, then press and release the
ENGINE START/STOP button once. The starter motor
will engage automatically, run for 10 seconds, and then
disengage. Once this occurs, release the accelerator pedal
and the brake pedal, wait 10 to 15 seconds, then repeat
the “Normal Starting” procedure.
After Starting
The idle speed is controlled automatically and it will
decrease as the engine warms up.
ENGINE BLOCK HEATER — IF EQUIPPED
The engine block heater warms the engine, and permits
quicker starts in cold weather. Connect the cord to a
standard 110-115 Volt AC electrical outlet with a
grounded, three-wire extension cord.
The engine block heater cord is routed under the hood on
the driver side of the vehicle. It has a removable cap that
is located on the driver side of the Integrated Power
Module.
The engine block heater must be plugged in at least one
hour to have an adequate warming effect on the engine.
WARNING!
Remember to disconnect the engine block heater
cord before driving. Damage to the 110-115 Volt
electrical cord could cause electrocution.
352 STARTING AND OPERATING

ADDING FUEL
1. Press the fuel filler door release switch (located in the
driver’s door map pocket).2. Open the fuel filler door.
3. There is no fuel filler cap. A flapper door inside the
pipe seals the system.
Fuel Filler Door Release Switch
Fuel Filler Door
428 STARTING AND OPERATING

Engine Oil Viscosity (SAE Grade) – 3.6L Engine
SAE 5W-30 engine oil is recommended for all operating
temperatures.
The engine oil filler cap also shows the recommended engine
oil viscosity for your engine. For information on engine oil
filler cap location, refer to “Engine Compartment” in “Main-
taining Your Vehicle” for further information.
Lubricants that do not have both, the engine oil certifi-
cation mark and the correct SAE viscosity grade number
should not be used.
Engine Oil Viscosity (SAE Grade) – 5.7L Engine
SAE 5W-20 engine oil is recommended for all operating
temperatures. This engine oil improves low temperature
starting and vehicle fuel economy.
The engine oil filler cap also shows the recommended engine
oil viscosity for your engine. For information on engine oil
filler cap location, refer to “Engine Compartment” in “Main-
taining Your Vehicle” for further information.
NOTE:Vehicles equipped with a 5.7L engine must use
SAE 5W-20 oil. Failure to do so may result in improper
operation of the Multi-Displacement System (MDS). Re-
fer to “Multi-Displacement System” in “Starting and
Operating” for further information.
Lubricants that do not have both, the engine oil certifi-
cation mark and the correct SAE viscosity grade number
should not be used.
Synthetic Engine Oils
You may use synthetic engine oils provided the recom-
mended oil quality requirements are met, and the recom-
mended maintenance intervals for oil and filter changes
are followed.
Materials Added To Engine Oil
Do not add any supplemental materials, other than leak
detection dyes, to the engine oil. Engine oil is an engi-
neered product and its performance may be impaired by
supplemental additives.
7
MAINTAINING YOUR VEHICLE 481

FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)
All Engines 19 Gallons 72 Liters
Engine Oil with Filter
3.6 Liter Engine (SAE 5W-30, API Certified) 6 Quarts 5.6 Liters
5.7 Liter Engine (SAE 5W-20, API Certified) 7 Quarts 6.6 Liters
Cooling System *
3.6 Liter Engine without All Wheel Drive (MOPARAntifreeze/
Coolant 5 Year/100,000 Mile Formula or equivalent)11.1 Quarts 10.5 Liters
3.6 Liter Engine with All Wheel Drive (MOPARAntifreeze/Coolant
5 Year/100,000 Mile Formula or equivalent)11.4 Quarts 10.8 Liters
5.7 Liter Engine without Severe Duty II Cooling System (MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula or equivalent)14.7 Quarts 13.9 Liters
5.7 Liter Engine with Severe Duty II Cooling System (MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula or equivalent)15.1 Quarts 14.3 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
7
MAINTAINING YOUR VEHICLE 521

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
Component Fluid, Lubricant, or Genuine Part
Engine Coolant MOPARAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT
(Hybrid Organic Additive Technology) or equivalent.
Engine Oil – 3.6L Engine Use API Certified SAE 5W-30 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to the engine oil fill cap for
correct SAE grade.
Engine Oil – 5.7L Engine Use API Certified SAE 5W-20 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to the engine oil fill cap for
correct SAE grade.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs – 3.6L Engine RER8ZWYCB4 (Gap 0.043 in [1.1 mm])
Spark Plugs – 5.7L Engine LZFR5C–11 (Gap 0.043 in [1.1 mm])
Fuel Selection – 3.6L Engine 87 Octane
Fuel Selection – 5.7L Engine 87 Octane Acceptable – 89 Octane Recommended
522 MAINTAINING YOUR VEHICLE

Conserving Fuel........................ 294
Console, Floor.......................... 262
Console, Overhead....................... 237
Contract, Service........................ 545
Coolant Pressure Cap (Radiator Cap).......... 495
Cooling System......................... 492
Adding Coolant (Antifreeze)............. 494
Coolant Capacity..................... 521
Coolant Level....................492,496
Disposal of Used Coolant............... 495
Drain, Flush, and Refill................ 493
Inspection.......................... 496
Points to Remember.................. 496
Pressure Cap........................ 495
Radiator Cap....................... 495
Selection of Coolant (Antifreeze)....493,521,522
Corrosion Protection..................... 502
Cruise Control (Speed Control).............. 199
Cupholders.........................259,507Customer Assistance..................... 543
Data Recorder, Event...................... 70
Daytime Brightness, Interior Lights........... 186
Daytime Running Lights................... 179
Dealer Service.......................... 477
Deck Lid, Emergency Release................ 43
Deck Lid, Power Release................... 41
Defroster, Rear Window................... 267
Defroster, Windshield...................84,338
Delay (Intermittent) Wipers................. 187
Diagnostic System, Onboard................ 475
Dimmer Switch, Headlight................. 181
Dipsticks
Oil (Engine)........................ 479
Disabled Vehicle Towing................... 467
Disposal
Antifreeze (Engine Coolant)............. 495
Engine Oil......................... 482
10
INDEX 555

Compartment Identification............. 473
Coolant (Antifreeze)................492,522
Cooling........................... 492
Exhaust Gas Caution................83,424
Fails to Start........................ 351
Flooded, Starting..................... 351
Fuel Requirements.................... 420
Jump Starting....................... 458
Multi-Displacement................... 374
Oil .........................479,521,522
Oil Change Interval................293,480
Oil Filler Cap....................... 481
Oil Filter........................... 482
Oil Filter Disposal.................... 482
Oil Selection.....................480,521
Oil Synthetic........................ 481
Overheating........................ 448
Starting........................... 348
Temperature Gauge................... 284Engine Oil Viscosity...................... 481
Enhanced Accident Response Feature.......... 66
Entry System, Illuminated.................. 21
Ethanol............................... 421
Event Data Recorder...................... 70
Exhaust Gas Caution...................83,424
Exhaust System.......................83,489
Exterior Folding Mirrors................... 95
Exterior Lighting........................ 175
Exterior Lights.......................... 86
Filler Location Fuel...................... 280
Filters
Air Cleaner......................... 482
Air Conditioning..................342,486
Engine Oil.......................482,522
Engine Oil Disposal................... 482
Flash-To-Pass........................... 181
10
INDEX 557

Flashers
Hazard Warning..................... 448
Turn Signal....................86,181,276
Flat Tire Changing....................... 449
Flexible Fuel Vehicles
Cruising Range...................... 427
Engine Oil......................... 426
Fuel Requirements.................424,425
Maintenance........................ 427
Replacement Parts.................... 427
Starting........................... 427
Flooded Engine Starting................... 351
Floor Console.......................... 262
Fluid Capacities......................... 521
Fluid Leaks............................. 86
Fluid Level Checks
Automatic Transmission................ 500
Brake............................. 498
Cooling System...................... 492Engine Oil......................... 479
Transfer Case....................... 501
Fluid, Brake........................... 523
Fluids................................ 522
Fluids, Lubricants and Genuine Parts.......... 522
Fog Lights..........................179,276
Folding Rear Seat........................ 168
Forward Collision Warning..............222,289
Freeing A Stuck Vehicle................... 462
Fuel................................. 420
Additives.......................... 423
Clean Air.......................... 421
Conserving......................... 294
Ethanol........................... 421
Filler Door (Gas Cap).................. 280
Gasoline........................... 420
Gauge............................ 280
Light............................. 289
Materials Added..................... 423
558 INDEX