2012 Alfa Romeo MiTo servicing

40GETTING TO KNOW YOUR CAR
Ser vice (Scheduled ser vicing)
This function allows you to view information on car servicing de-
pending on kilometres travelled or daily intervals.
With the Service function it is also possible to view the interval
(in kilometres or miles) before the next engine oil change is due.
This information can be consulted as follows:
– briefly press MENU ESC: the display shows service requirements
in km or mi according to the previous setting (see paragraph “Dis-
tance unit of measurement”);
– briefly press the MENU ESC button to go back to the menu screen
or hold the button down to go back to the standard screen.IMPORTANT The “Planned Maintenance Programme” requires the
vehicle to be serviced every 30,000 km (for petrol versions), or
every 35,000 km (for diesel versions). This message is displayed
automatically when the key is turned to MAR, from 2,000 km
(or equivalent value in miles) from the mileage when the next ser-
vice is due and is re-displayed every 200 km (or equivalent value
in miles). The indications will appear more frequently when there
are less than 200 km left. The indication will appear in kilome-
tres or miles according to the unit of measurement settings. When
the next scheduled service operation is approaching, the message
“Service” will appear on the display followed by the number of
kilometres or miles left, when the key is turned to MAR. Go to an
Alfa Romeo Authorised Service where the “Scheduled Service” op-
erations will be performed and the message will be reset.

158STARTING UP AND DRIVING
SAVING FUEL
Here are some suggestions which may help you to save fuel and
lower the amount of toxic emissions released into the atmosphere.
GENERAL CONSIDERATIONS
Car maintenance
Have checks and adjustments carried out in accordance with the
“Scheduled servicing plan”.
Tyres
Check tyre pressure regularly, at least once every four weeks: ex-
cessively low pressure will increase fuel consumption because rolling
resistance will be higher.
Unnecessar y loads
Do not travel with an overloaded boot. The weight of the car and
its ride setting greatly affect fuel consumption and stability.
Press the clutch pedal fully to change gears cor-
rectly. For this reason, there must be no obstacles
on the floor under the pedals: ensure that any rub-
ber mats are correctly positioned, and do not interfere
with the pedals
Do not drive with your hand resting on the gear
lever, because this pressure, even if light, can wear
out the gearbox internal components over time.
IMPORTANT Reverse may only be engaged when the car is at a
standstill. With the engine on, wait at least 3 seconds with the
clutch pressed down before engaging reverse gear to prevent it
from scraping.

CARE AND MAINTENANCE201
5
Scheduled maintenance ...................................................................... 202
Scheduled servicing plan ..................................................................... 203
Periodic checks.................................................................................. 207
Demanding use of the car .................................................................... 207
Checking fluid levels ........................................................................... 208
Air filter/pollen filter/diesel filter .......................................................... 217
Battery.............................................................................................. 217
Wheels and tyres............................................................................... 219
Windscreen/rearscreen wipers ............................................................. 220
Bodywork.......................................................................................... 223
Interiors............................................................................................. 225

CARE AND MAINTENANCE203
5
SCHEDULED SERVICING PLAN
PETROL VERSIONS
Thousands of kilometres
Check tyre condition/wear and adjust pressure if required
Check lighting system operation (headlights, direction indicators, hazard lights, passenger
compartment lights, boot lights, instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads and
brake pad wear indication
Check rear disc brake pad condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses (exhaust - fuel - brakes),
rubber parts (gaiters, sleeves, bushes, etc.)
Check cleanliness of locks, bonnet and boot, and
cleanliness and lubrication of linkages
Check and top up, if required, fluid levels
(engine coolant, brake/hydraulic clutch fluid, windscreen washer fluid, battery fluid, etc)
Check the handbrake lever travel and adjust it, if necessary
Check timing belt condition
Visually inspect condition of auxiliary drive belt/s
Check tension and adjust auxiliary drive belt (versions with heater system)30 60 90 120 150 180
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●
●●
●●

CARE AND MAINTENANCE207
5
PERIODIC CHECKS
Every 1,000 km or before long journeys, check and top up the fol-
lowing if necessary:
❍engine coolant level, brake fluid and windscreen washer fluid
❍tyre pressure and condition;
❍operation of lights (headlights, direction indicators, hazard
lights, etc.);
❍operation of the windscreen wiper/washer system, position
and wear of windscreen/rearscreen wiper blades;
Every 3,000 km check the following and top-up, if necessary: en-
gine oil level.
We recommend the use of PETRONAS LUBRICANTS products, de-
signed and produced specifically for Alfa Romeo cars (see “Con-
sumables” table in chapter 6).
DEMANDING USE OF THE CAR
If you use the vehicle mainly under one of the following conditions:
❍trailer or caravan towing;
❍dusty roads;
❍repeated short distances (less than 7-8 km) and with exter-
nal temperatures below zero;
❍frequently idling the engine, travelling long distances at low
speeds or long term inactivity;
❍in cities;
perform the following inspections more frequently than shown on
the Scheduled Servicing Plan:
❍check front disc brake pad condition and wear;
❍check cleanliness of bonnet and boot locks, and cleanliness and
lubrication of linkages;
❍visually inspect the condition of: engine, gearbox, transmission,
pipes and hoses (exhaust – fuel supply - brakes) rubber ele-
ments (gaiters – hoses - bushes etc.);

246TECHNICAL DATA
Synthetic-based oil, grade SAE 5W-40 ACEA C3.
FIAT 9.55535-S2 Classification
Synthetic-based oil, grade SAE 5W-30
FIAT 9.55535-S1 Classification
For diesel engines, in emergency cases where genuine products are not available, lubricants with min. performance ACEA C2 are acceptable.
If this is the case, the best engine performance is not guaranteed. We recommend replacing the lubricant as soon as possible at an Alfa Romeo
Authorised Service.
The use of products with characteristics that are not up to ACEA C3 (for petrol engines) and ACEA C2 (for diesel engines) standard could cause
engine damage not covered by the warranty.
For petrol versions with Multi Air system, the use of lubricants with features below ACEA C3 and SAE grade other than 5W-40 could cause damage
to the engine, not covered by the warranty.
SELENIA StAR P.E.
Contractual Technical
Reference N
°F603.D08
SELENIA WR P.E.
Contractual Technical
Reference N
°F510.D07
According to
Scheduled
Servicing Plan
According to
Scheduled
Servicing Plan
FLUIDS AND LUBRICANTS
RECOMMENDED PRODUCTS AND SPECIFICATIONS
Use Fluid qualitative specifications and lubricants Fluids and lubricants Interval
for correct vehicle operation original replacement
Lubricants for
petrol engines
Lubricants for
diesel engines

INDEX255
7
Lane Change” function ................ 77
Load limiters............................... 135
Luggage compartment
– closing ................................. 100
– extending the luggage
compartment ........................ 101
– opening ................................ 99
Main beam headlights
– activation............................. 77
– bulb replacement ................... 180
Maintenance
– demanding use of the car ........ 207
– periodic checks...................... 207
– scheduled maintenance ........... 202
– scheduled servicing plan .......... 203
Menu ........................................ 32
Menu options ............................. 32
MSR (system)............................ 110
Multifunctional display .................. 26
Navigation system (wiring) ......... 121
Number plate lights
– bulb replacement ................... 183
Oddment compartment ............... 89
Oil engine .................................. 214
S.B.R. system ............................ 133
Safe lock (device) ....................... 51
Safety ....................................... 131
Saving fuel................................. 158
Seat belts
– pretensioners........................ 135
– S.B.R. system ....................... 133
– seat belt maintenance ............ 137
– using the seat belts ................ 132
Seats
– adjustment ....................... 56-57
– cleaning ............................... 225
– Easy Entry ............................ 58
– seat warming ........................ 58
Sensors
– automatic headlights ..............76
– rain ..................................... 80
– parking ................................ 123
Service Plan ............................... 203
– regular checks....................... 207
Setting off and driving .................. 153
Side bags ................................... 149
Sidelights/daytime lights
– activation............................. 76
– bulb replacement ...............180-182
Snow chains ............................... 162Paint ........................................ 223
Parking ...................................... 156
– handbrake ............................ 156
Performance ............................... 241
Power windows ........................... 96
Pretensioners.............................. 135
Protecting the environment ........... 130
Puddle lights
– bulb replacement ................... 187
Radio transmitters and
cellular phones.......................... 123
Radio wiring system ..................... 121
Rear fog lights
– activation . ............................ 87
– bulb replacement ................... 183
Rear screen wiper
– activation............................. 79
– brushes ................................ 220
– sprays .................................. 221
Rear view mirrors ........................ 61
Reconfigurable
multifunctional display ................ 27
Reversing light
– bulb replacement ................... 183
Roof rack/ski rack ....................... 104