2011 TOYOTA CAMRY HYBRID fuel

JOBNAME:280573-2011-cah-toyw PAGE:5SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
THE NEW WORLD OF
ANTI-THEFT TECHNOLOGY
ThisToyota vehicle maybeequipped with
an electronic “immobilizer” anti-theft
system. Whenthekey isinserted intothe
ignition switchittransmits anelectronic
code toan immobilizer computer.The
engine willonly start ifthe code inthe key
matches thecode inthe immobilizer. Ifthe
code doesnotmatch, theimmobilizer
disables theignition andfuelsystems.
While anexact physical copyofthe key
will open thedoor andallow retrieval of
items locked inthe vehicle, itwon’t start
the vehicle unlessthekey has thesame
code asthe immobilizer.
SECURITY
For security purposes, accesstokey
codes andservice procedures for
electronically registeringreplacement keys
is restricted. OnlyaToyota dealeror
certain bonded/registered independent
locksmiths cangenerate replacement keys.
TheImmobilizer Key
WARRANTY
Introduction5

JOBNAME:280573-2011-cah-toyw PAGE:13SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
WHAT ISCOVERED AND
HOW LONG
Basic Warranty
Thiswarranty coversrepairs and
adjustments neededtocorrect defects in
materials orworkmanship ofany part
supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 36months or
36,000 miles,whichever occursfirst,with
the exception ofwheel alignment and
wheel balancing, whicharecovered for
12 months or20,000 miles,whichever
occurs first.
Hybrid System Warranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofthe components listed
here andsupplied byToyota, subjectto
the exceptions indicatedunder“What Is
Not Covered” onpages 14-15.
•Battery controlmodule (battery
voltage sensor)
• Hybrid battery
• Hybrid control module (power
management controlmodule)
• Inverter withconverter
Coverage isfor 96months or
100,000 miles,whichever occursfirst.
Powertrain Warranty
Thiswarranty coversrepairs needed to
correct defects inmaterials or
workmanship ofany component listed
below andinthe next column and
supplied byToyota, subjecttothe
exceptions indicatedunder“What IsNot
Covered” onpages 14-15.
Coverage isfor 60months or
60,000 miles,whichever occursfirst.
Engine
Cylinder blockandhead andallinternal
parts, timing gearsandgaskets, timing
chain/belt andcover, valvecovers, oilpan,
oil pump, engine mounts, enginecontrol
computer, waterpump, fuelpump, seals
and gaskets.
Transaxle/Motor/Generator
Case andallinternal parts,transaxle
mounts, sealsandgaskets.
Front-Wheel-Drive System
Final drive housing andallinternal parts,
axle shafts, driveshafts, constant velocity
joints, fronthubandbearings, sealsand
gaskets.
New Vehicle Limited Warranty
WARRANTY
YourWarranties inDetail13

JOBNAME:280573-2011-cah-toyw PAGE:18SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
WHAT ISNOT COVERED
These warranty obligations donot apply to
failures ornoncompliance causedby:
•The useofreplacement partsnot
certified inaccordance with
aftermarket partscertification
regulations.
• The useofreplacement partsnot
equivalent inquality ordesign to
original equipment parts.
Provisionsunderthe“What IsNot
Covered” sectionofthe New Vehicle
Limited Warranty alsoapply tothis
warranty.
WARRANTY PARTSLIST
Air/Fuel Metering System
•Air/fuel ratiofeedback controlsystem
• Electronic fuelinjection system
components
– Airflow sensor
– Engine control module (8/80)
– Throttle body
– Other components
AirInduction System
•Intake manifold andintake airsurge
tank
Catalyst System
•Catalytic converter andprotector
(8/80)
• Constricted fuelfiller neck
• Exhaust manifold
• Exhaust pipe(manifold tocatalyst
and/or catalyst tocatalyst)
Evaporative ControlSystem
•Charcoal canister
• Diaphragm valve
• Fuel filler cap
• Fuel tank
8/80 =Covered foreight years or80,000 miles,whichever occursfirst.
Federal Emission ControlWarranty
WARRANTY
18YourWarranties inDetail

JOBNAME:280573-2011-cah-toyw PAGE:23SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
Vehicles equipped withaCalifornia
Certified Emission ControlSystem that
are sold, registered andoperated in
California orany state thatadopts
California emissionwarrantyprovisions
are covered bythis warranty. Currently,
Connecticut, Maine,Maryland,
Massachusetts, NewJersey, New
Mexico, NewYork, Oregon,
Pennsylvania, RhodeIsland, Vermont
and Washington arethe other states to
which thiswarranty applies.Vehicles
covered bythis warranty arealso
covered bythe Federal Emission
Control Warranty (seepage 17).
YOUR WARRANTY RIGHTS
AND OBLIGATIONS
TheCalifornia AirResources Board(CARB)
and Toyota arepleased toexplain the
emission controlsystem warranty foryour
2011 vehicle. InCalifornia, newmotor
vehicles mustbedesigned, builtand
equipped tomeet thestate’s stringent
anti-smog standards. CARBregulations
require thatToyota mustwarrant the
emission controlsystem onyour vehicle
for the time periods indicated onthe next
page, provided therehasbeen noabuse,
neglect orimproper maintenance ofyour
vehicle.
Your emission controlsystem mayinclude
parts suchasthe fuel injection system,
ignition system, catalytic converter and
engine computer. Alsoincluded maybe
hoses, belts,connectors andother
emissions-related assemblies.
Where awarrantable conditionexists,
Toyota willrepair yourvehicle atno cost
to you, including diagnosis, partsand
labor.
California EmissionControlWarranty
WARRANTY
YourWarranties inDetail23

JOBNAME:280573-2011-cah-toyw PAGE:25SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
Parts List:Long-Term Emission
Defect Warranty (Pennsylvania
and Washington Vehicles
Only* )
Theparts listed herearecovered forseven
years or70,000 miles,whichever occurs
first.
Air/Fuel Metering System
•Engine control computer (engine
control module)
• Throttle body
AirInduction System
•Intake manifold andintake airsurge
tank
Catalyst System
•Exhaust frontpipe(including catalytic
converter)
• Exhaust manifold (including manifold
converter)
Evaporative ControlSystem
•Charcoal canister
• Fuel tank
Hybrid System
•Battery controlmodule (battery
voltage sensor)†
• Hybrid battery†
• Hybrid control module (power
management controlmodule)†
• Inverter withconverter†
• Transaxle (including motorand
generator)
OWNER’S WARRANTY
RESPONSIBILITIES
You areresponsible forperformance of
the required maintenance indicatedinthe
Owner’s Manualandthisbooklet. Toyota
recommends thatyouretain allreceipts
covering maintenance onyour vehicle, but
Toyota cannot denywarranty coverage
solely forthe lack ofreceipts oryour
failure toensure theperformance ofall
scheduled maintenance.
You areresponsible forpresenting your
vehicle toaToyota dealership assoon as
a problem exists.Thewarranty repairs
should becompleted inareasonable
amount oftime, nottoexceed 30days.
You should alsobeaware thatToyota may
deny youwarranty coverage ifyour vehicle
or apart hasfailed duetoabuse, neglect,
improper maintenance orunapproved
modifications.
If you have anyquestions regardingyour
warranty rightsandresponsibilities, you
should contact theToyota Customer
Experience Centerat(800) 331-4331 or
the California AirResources Board,Mobile
Source Control Division, at9528 Telstar
Avenue, P.O.Box8001, ElMonte, CA
91734-8001.
* Applies toPennsylvania andWashington vehiclesequipped withaCalifornia CertifiedEmission Control
Warranty.
† Covered undertheHybrid System Warranty foreight years or100,000 miles,whichever occursfirst.
California EmissionControlWarranty
WARRANTY
YourWarranties inDetail25

JOBNAME:280573-2011-cah-toyw PAGE:41SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
30,000 milesor36 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsReplace cabinairfilterReplace engineairfilterReplace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive shaftboots
__ Engine/Inverter coolant4
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Tighten nutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
ATE:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayafterengine oilreplacement.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
Maintenance Log
MAINTENANCE
MaintenanceLog41

JOBNAME:280573-2011-cah-toyw PAGE:45SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
60,000 milesor72 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsReplace cabinairfilterReplace engineairfilterReplace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive belts4
__Drive shaftboots
__ Engine valveclearance5
__Engine/Inverter coolant6
__Exhaust pipesandmountings
__ Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Tighten nutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
ATE:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayafterengine oilreplacement.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Initial inspection at60,000 miles/72 months.Inspectevery15,000 miles/18 monthsthereafter.5Checkfortappet noiseandengine vibration andadjust ifnecessary.6Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
Maintenance Log
MAINTENANCE
MaintenanceLog45

JOBNAME:280573-2011-cah-toyw PAGE:49SESS: 11OUTPUT: MonDec2117:22:48 2009
/tweddle/toyota/sched-maint/280573-en-cah/wg
90,000 milesor108 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsReplace cabinairfilterReplace engineairfilterReplace engineoiland oilfilter1
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
3
__ Drive belts
__ Drive shaftboots
__ Engine/Inverter coolant
4
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Tighten nutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
ATE:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayafterengine oilreplacement.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Inspectthickness measurement anddisc runout.4Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
Maintenance Log
MAINTENANCE
MaintenanceLog49