260DO−IT−YOURSELF MAINTENANCE: Introduction
If you perform maintenance by yourself,
be sure to follow the correct procedure
given in this Section.
You should be aware that improper or in-
complete servicing may result in operating
problems.
This Section gives instructions only for
those items that are relatively easy for an
owner to perform. As explained in Section
6, there are still a number of items that
must be done by a qualified technician
with special tools.
Utmost care should be taken when work-
ing on your vehicle to prevent accidental
injury. Here are a few precautions that
you should be especially careful to ob-
serve:
CAUTION
DWhen the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
DRight after driving, the engine
compartment—the engine, radiator,
exhaust manifold, and spark plug
boots, etc. —will be hot. So be
careful not to touch them. Oil,
fluids and spark plugs may also be
hot.
DIf the engine is hot, do not remove
the radiator cap or coolant reser-
voir cap or loosen the drain plugs,
to prevent burning yourself.
DDo not leave anything that may
burn easily, such as paper or rags,
in the engine compartment.
DDo not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
DBe extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
DDo not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
DBe sure that the engine is off if you
work near the electric cooling fan
or radiator grille. With the engine
on, the electric cooling fan will au-
tomatically start to run if the en-
gine coolant temperature is high
and/or the air conditioning is on.
DUse eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
DUsed engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
DDo not leave used oil within the
reach of children.
DDispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
DTake care when filling the brake
fluid reservoir because brake fluid
can harm your hands or eyes. If
fluid gets on your hands or in your
eyes, flush the affected area with
clean water immediately. If you still
feel uncomfortable with your hands
or eyes, go to the doctor.
AYGO WE 99E37E1102.18
Do−it−yourself service
precautions
DO−IT−YOURSELF MAINTENANCE: Introduction261
NOTICE
zRemember that battery and ignition
cables carry high currents or volt-
ages. Be careful not to accidentally
cause a short circuit.
zAdd only “Toyota Super Long Life
Coolant” or similar high quality eth-
ylene glycol based non−silicate,
non−amine, non−nitrite, and non−bo-
rate coolant with long−life hybrid
organic acid technology to fill the
radiator. “Toyota Super Long Life
Coolant” is a mixture of 50% cool-
ant and 50% deionized water.
zIf you spill some of the coolant, be
sure to wash it off with water to
prevent it from damaging any parts
or paint.
zDo not allow dirt or anything else
to fall through the spark plug holes.
zDo not pry the outer electrode of a
spark plug against the center elec-
trode.
zUse only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
zIf you spill brake fluid, be sure to
wash it off with water to prevent it
from damaging any parts or paint.
zDo not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
zBe careful not to scratch the glass
surfaces with the wiper frames.
zWhen closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.
Positioning a floor jack
MS71009a
Do not jack up
Do not jack upDo not jack up
Do not jack up
Front of
vehicle
When jacking up your vehicle with the
floor jack, position the jack correctly as
shown in the illustrations.
Jack position
................
Front—Front suspension member
Rear—Transport hook
Support position and Cantilever−type
jack position
.................
CAUTION
When jacking, be sure to observe the
following to help reduce the possibil-
ity of personal injury:
DWhen using a floor jack, follow the
instructions of the manual provided
with the jack.
DDo not put any part of your body
under the vehicle supported by the
floor jack. Always use floor jack
and/or automotive jack stand on a
solid, flat, level surface. Personal
injury may occur.
DDo not start or run the engine while
your vehicle is supported by the
floor jack.
AYGO WE 99E37E1102.18
