2011 TOYOTA AURIS brake

368 4-3. Do-it-yourself maintenance
UK_AURIS_HV_EE
NOTICE
If you remove the air cleaner filter
Driving with the air cleaner filter removed may cause excessive engine wear
due to dirt in the air. Also a backfire could cause a fire in the engine compart-
ment.
If the fluid level is low or high
It is normal for the brake fluid level to go down slightly as the brake pads
wear or when the fluid level in the accumulator is high.
If the reservoir needs frequent refilling, it may indicate a serious problem.

372 4-3. Do-it-yourself maintenance
UK_AURIS_HV_EE
CAUTION
When raising your vehicle
Make sure to observe the following to reduce the possibility of death or seri-
ous injury.
When using a floor jack, follow the instructions of the manual provided with
the jack.
Do not use the jack that was supplied with your vehicle.
Do not put any part of your body or get underneath the vehicle supported
only by the floor jack.
Always use floor jack and/or automotive jack stands on a solid, flat, level
surface.
Do not start the hybrid system while the vehicle is supported by the floor
jack.
Stop the vehicle on level, firm ground, firmly set the parking brake and
push the P position switch.
Make sure to set the floor jack properly at the jack point.
Raising the vehicle with an improperly positioned floor jack will damage
the vehicle and may cause the vehicle to fall off the floor jack.
Do not raise the vehicle while someone is in the vehicle.
When raising the vehicle, do not place any objects on top of or underneath
the floor jack.
Lift up the vehicle using a floor jack
such as the one shown in the illustra-
tion.

384 4-3. Do-it-yourself maintenance
UK_AURIS_HV_EE
Before recharging
When recharging, the 12-volt battery produces hydrogen gas which is flam-
mable and explosive. Therefore, before recharging:
If recharging with the 12-volt battery installed on the vehicle, be sure to
disconnect the ground cable.
Make sure the power switch on the charger is off when connecting and
disconnecting the charger cables to the 12-volt battery.
After recharging/reconnecting the 12-volt battery
Vehicles with a smart entry & start system: Unlocking the doors using the
entry function may not be possible immediately after reconnecting the
12-volt battery. If this happens, use the wireless remote control or the
mechanical key to lock/unlock the doors.
Start the hybrid system with the “POWER” switch in ACCESSORY mode.
The hybrid system may not start with the “POWER” switch turned off.
However, the hybrid system will operate normally from the second
attempt.
The “POWER” switch mode is recorded by the vehicle. If the 12-volt bat-
tery is reconnected, the vehicle will return the “POWER” switch mode to
the status it was in before the 12-volt battery was disconnected. Make
sure to turn the “POWER” switch off before disconnect the 12-volt bat-
tery. Take extra care when connecting the 12-volt battery if the “POWER”
switch mode prior to discharge is unknown.
When the 12-volt battery is reconnected, start the hybrid system, depress
the brake pedal, and confirm that it is possible to shift into each shift posi-
tion.
If the system will not start even after multiple attempts, contact any autho-
rized Toyota dealer or repairer, or another duly qualified and equipped pro-
fessional.

404 4-3. Do-it-yourself maintenance
UK_AURIS_HV_EE
Fuse layout and amperage ratings
Engine compartment
FuseAmpereCircuit
1 HTR 50 A Air conditioning system
2 RDI 30 A Electric cooling fan
3 CDS 30 A Electric cooling fan
4 DRL 7.5 A Daytime running lights
5 ENG W/P 30 A Cooling system
6ABS MAIN
NO.27.5 A Brake system
7 H-LP CLN 30 A Headlight cleaner
8 IGCT 30 A IGCT NO.2, IGCT NO.3, PCU
9 DC/DC-S 5 A Inverter and converter
10 P CON MAIN 7.5 A P position control system
11 AM2 7.5 A Hybrid system
12 ECU-B2 10 AAir conditioning system, smart
entry & start system, push button
start, power windows

405 4-3. Do-it-yourself maintenance
4
Maintenance and care
UK_AURIS_HV_EE
13 TURN & HAZ 10 A Turn signal lights
14 ETCS 10 AMultiport fuel injection system/
sequential multiport fuel injection
15ABS MAIN
NO.120 A Brake system
16 P/I 2 40 AHorn, left-hand headlight (low
beam), right-hand headlight (low
beam), back-up lights, navigation
system, auto anti-glare inside rear
view mirror, Toyota parking assist-
sensor
17 ABS MTR 1 30 A Brake system
18 ABS MTR 2 30 A Brake system
19 H-LP HI MAIN 20 A H-LP LH HI, H-LP RH HI
20 P CON MTR 30 A P position control system
21 P/I 1 60 A EFI MAIN, BATT FAN, IG2
22 EPS 60 A Electric power steering
23 PCU 10 A Hybrid system
24 IGCT NO.2 10 AHybrid system, P position control
system, hybrid battery
25 MIR HTR 10 AOutside rear view mirror defoggers,
outside rear view mirrors
26 RAD NO.1 15 A Audio system, navigation system
27 DOME 10 AInterior light, personal lights, vanity
lights, smart entry & start system,
luggage compartment light
28 ECU-B 10 AGauge and meters, vehicle stability
control system, main body ECU
29 H-LP LH HI 10 A Left-hand headlight (high beam)
30 H-LP RH HI 10 A Right-hand headlight (high beam)
FuseAmpereCircuit

407 4-3. Do-it-yourself maintenance
4
Maintenance and care
UK_AURIS_HV_EEInstrument panel
FuseAmpereCircuit
1TAIL 10 AFront position lights, tail lights,
license plate lights, rear fog light,
front fog lights, manual headlight
leveling dial
2 PANEL 7.5 AAudio system, navigation system,
cigarette lighter, glove box light,
Toyota parking assist-sensor,
switch illumination
3IGN 7.5 ASRS airbag system, multiport fuel
injection system/sequential multi-
port fuel injection, smart entry &
start system, push button start,
brake system, hybrid system
4 MET 7.5 A Gauge and meters
5 WASHER RR 10 A Rear windshield washer
6 WIP 25 A Windshield wipers, rain sensor
7 RR WIP 15 A Rear window wiper
8 WASHER FR 15 A Windshield washer
9 HTR-IG 10 A Air conditioning system

408 4-3. Do-it-yourself maintenance
UK_AURIS_HV_EE
10 GAUGE 10 AHorn, left-hand headlight (low
beam), right-hand headlight (low
beam), back-up lights, navigation
system, auto anti-glare inside rear
view mirror, Toyota parking assist-
sensor
11 ECU-IG NO.2 10 AAir conditioning system, turn signal
lights, auto anti-glare inside rear
view mirror, rear view monitor sys-
tem, moon roof, Toyota parking
assist-sensor, brake system
12 ECU-IG1 NO.1 10 AMain body ECU, electric cooling
fans, automatic headlight leveling
system, electric power steering,
rain-sensing windshield wipers,
headlight cleaner, vehicle stability
control system
13 DOOR RL 20 A Power windows
14 DOOR RR 20 A Power windows
15 D FR DOOR 20 A Power windows
16 S/ROOF 20 A Moon roof
17 P FR DOOR 20 A Power windows
18 STOP 10 AStop lights, high mounted stop
light, brake system, hybrid system
19 RR FOG 7.5 A Rear fog light
20 OBD 7.5 A On-board diagnosis system
21 FR FOG 15 A Front fog lights
22 DBL LOCK 25 AMultiport fuel injection system/
sequential multiport fuel injection
23 DOOR NO.1 25 A Power door lock
24 SEAT HTR FL 10 A Seat heater
25 SEAT HTR FR 10 A Seat heater
FuseAmpereCircuit

424 5-1. Essential information
UK_AURIS_HV_EE
Emergency towing
If a tow truck is not available in an emergency, your vehicle may be
temporarily towed using a cable or chain secured to the emergency
towing eyelet(s). This should only be attempted on hard, surfaced
roads for short distances at under 30 km/h (18 mph).
A driver must be in the vehicle to steer and operate the brakes. The
vehicle’s wheels, drive train, axles, steering and brakes must be in
good condition.
Towing eyelets
If emergency towing cannot be performed
The vehicle cannot be towed by another vehicle in the following situa-
tions because the front wheels may be locked by the parking lock.
Transport the vehicle with both front wheels or all 4 wheels lifted
using a flatbed or wheel-lift type truck.
• There is a malfunction in the smart entry & start system
• There is a malfunction in the push button start
• The P position control system is malfunctioning. (P. 437)
• The 12-volt battery is discharged.