Page 463 of 2057
3. If an obvious cause for an observed or reported
concern is found, correct the cause (if possible)
before proceeding to the next step.
4. If the cause is not visually evident, verify the symptom and refer to the diagnostic tab within
the Ford approved diagnostic tool. G1055084en
2008.50 Kuga 8/2011 419-10-13
Multifunction Electronic Modules
419-10-13
DIAGNOSIS AND TESTINGTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 464 of 2057
Generic Electronic Module (GEM)
General Equipment
Ford Diagnostic Equipment
Removal
CAUTIONS: Modules must not be swapped between
vehicles.
Compare the number of relays and fuses
in the defective GEM and the new GEM.
Transfer from the defective GEM any relays
and fuses which are not in the new GEM.
In doing so, pay attention that fuses with
the correct Ampere rating are used, by
referring to the wiring diagrams.
When installing a new GEM on vehicles
with a diesel engine, make sure that a fuel
pump fuse (F111) with 5A is used.
When installing a new GEM on vehicles
with a petrol engine, make sure that a fuel
pump fuse (F111) with 15A is used.
NOTE: GEM is integrated into the central junction
box (CJB) and cannot be removed individually.
1. NOTE: This step is only necessary when
installing a new component.
Upload the GEM configuration information using
the Programmable Modules Installation Routine.
General Equipment: Ford Diagnostic Equipment
2. Refer to: Battery Disconnect and Connect
(414-01 Battery, Mounting and Cables,
General Procedures).
3. 4.
5.
Installation
1.
To install, reverse the removal procedure.
2. NOTE: This step is only necessary when
installing a new component.
Download the GEM configuration information
to the newly installed GEM using the
programmable modules installation routine.
3. NOTE: This step is only necessary when
installing a new component.
Program all keys using the Key Programming
Routine.
General Equipment: Ford Diagnostic Equipment G1065605en
2008.50 Kuga 8/2011 419-10-14
Multifunction Electronic Modules
419-10-14
REMOVAL AND INSTALLATIONTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUALE51159 122E102019 E102020
Page 465 of 2057
/ L J K W L Q J & R Q W U R O 0 R G X O H / & 0
* H Q H U D O ( T X L S P H Q W ) R U G ' L D J Q R V W L F ( T X L S P H Q W
5 H P R Y D O
5 H I H U W R ) O R R U & R Q V R O H ( [ W H Q V L R Q 9 H K L F O H V
: L W K & H Q W H U $ U P U H V W , Q V W U X P H Q W
3 D Q H O D Q G & R Q V R O H 5 H P R Y D O D Q G , Q V W D O O D W L R Q
(
(
, Q V W D O O D W L R Q
7 R L Q V W D O O U H Y H U V H W K H U H P R Y D O S U R F H G X U H
1 2 7 ( 7 K L V V W H S L V R Q O \ Q H F H V V D U \ Z K H Q
L Q V W D O O L Q J D Q H Z F R P S R Q H Q W
, Q L W L D O L ] H W K H / & 0 X V L Q J W K H 3 U R J U D P P D E O H
0 R G X O H V , Q V W D O O D W L R Q 5 R X W L Q H
* H Q H U D O ( T X L S P H Q W ) R U G ' L D J Q R V W L F ( T X L S P H Q W
1 2 7 ( 7 K L V V W H S L V R Q O \ Q H F H V V D U \ Z K H Q
L Q V W D O O L Q J D Q H Z F R P S R Q H Q W
* H Q . X J D
0 X O W L I X Q F W L R Q ( O H F W U R Q L F 0 R G X O H V
5 ( 0 2 9 $ / $ 1 ' , 1 6 7 $ / / $ 7 , 2 1
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
TO MODEL INDEX
BACK TO CHAPTER INDEX
Page 466 of 2057
Calibrate the headlamp leveling system.
General Equipment: Ford Diagnostic Equipment
4. NOTE: This step is only necessary when
installing a new component.
Refer to: Headlamp Adjustment (417-01 Exterior
Lighting, General Procedures). G1076572en
2008.50 Kuga 8/2011 419-10-16
Multifunction Electronic Modules
419-10-16
REMOVAL AND INSTALLATIONTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 467 of 2057
* 5 2 8 3
% R G \ D Q G 3 D L Q W
6 ( & 7 , 2 1 7 , 7 / ( 3 $ * (
% R G \ D Q G 3 D L Q W ) U R Q W ( Q G % R G \ 3 D Q H O V
% R G \ & O R V X U H V
, Q W H U L R U 7 U L P D Q G 2 U Q D P H Q W D W L R Q
( [ W H U L R U 7 U L P D Q G 2 U Q D P H Q W D W L R Q
5 H D U 9 L H Z 0 L U U R U V
6 H D W L Q J
* O D V V ) U D P H V D Q G 0 H F K D Q L V P V
, Q V W U X P H Q W 3 D Q H O D Q G & R Q V R O H
+ D Q G O H V / R F N V / D W F K H V D Q G ( Q W U \ 6 \ V W H P V
: L S H U V D Q G : D V K H U V
% X P S H U V
6 D I H W \ % H O W 6 \ V W H P $
6 X S S O H P H Q W D O 5 H V W U D L Q W 6 \ V W H P %
% R G \ 5 H S D L U V * H Q H U D O , Q I R U P D W L R Q
% R G \ 5 H S D L U V 9 H K L F O H 6 S H F L I L F , Q I R U P D W L R Q D Q G 7 R O H U D Q F H & K H F N V
) U R Q W ( Q G 6 K H H W 0 H W D O 5 H S D L U V
5 R R I 6 K H H W 0 H W D O 5 H S D L U V
6 L G H 3 D Q H O 6 K H H W 0 H W D O 5 H S D L U V
5 H D U ( Q G 6 K H H W 0 H W D O 5 H S D L U V
3 D L Q W * H Q H U D O , Q I R U P D W L R Q
) U D P H D Q G 0 R X Q W L Q J 8 Q L % R G \ 6 X E I U D P H D Q G 0 R X Q W L Q J 6 \ V W H P
. X J D
TO MODEL INDEX
BACK TO MAIN INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 468 of 2057
6 ( & 7 , 2 1 ) U R Q W ( Q G % R G \ 3 D Q H O V
9 ( + , & / ( $ 3 3 / , & $ 7 , 2 1 . X J D
3 $ * (
& 2 1 7 ( 1 7 6
5 ( 0 2 9 $ / $ 1 ' , 1 6 7 $ / / $ 7 , 2 1
& R Z O 3 D Q H O * U L O O H
) H Q G H U 6 S O D V K 6 K L H O G
) U R Q W ( Q G % R G \ 3 D Q H O V
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 469 of 2057
& R Z O 3 D Q H O * U L O O H
* H Q H U D O ( T X L S P H Q W 7 Z R / H J 3 X O O H U
5 H P R Y D O
1 2 7 ( 5 H P R Y D O V W H S V L Q W K L V S U R F H G X U H P D \
F R Q W D L Q L Q V W D O O D W L R Q G H W D L O V
& $ 8 7 , 2 1 0 D N H V X U H W K D W W K H P R W R U L V L Q W K H S D U N S R V L W L R Q 5 H P R Y H W K H I R O O R Z L Q J L W H P V
* H Q H U D O ( T X L S P H Q W 7 Z R / H J 3 X O O H U 7 R U T X H
1 P
L I H T X L S S H G
[
(
[
[
, Q V W D O O D W L R Q
& $ 8 7 , 2 1 0 D N H V X U H W K D W W K H P R W R U L V L Q W K H S D U N S R V L W L R Q
7 R L Q V W D O O U H Y H U V H W K H U H P R Y D O S U R F H G X U H
5 H I H U W R : L S H U % O D G H $ Q J O H $ G M X V W P H Q W
: L S H U V D Q G : D V K H U V * H Q H U D O 3 U R F H G X U H V
* H Q . X J D
) U R Q W ( Q G % R G \ 3 D Q H O V
5 ( 0 2 9 $ / $ 1 ' , 1 6 7 $ / / $ 7 , 2 1
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
Page 470 of 2057
) H Q G H U 6 S O D V K 6 K L H O G
5 H P R Y D O
5 H I H U W R : K H H O D Q G 7 L U H : K H H O V D Q G
7 L U H V 5 H P R Y D O D Q G , Q V W D O O D W L R Q
, I H T X L S S H G
(
[
* H Q . X J D
) U R Q W ( Q G % R G \ 3 D Q H O V
5 ( 0 2 9 $ / $ 1 ' , 1 6 7 $ / / $ 7 , 2 1
TO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL
![FORD KUGA 2011 1.G Workshop Manual & R Z O 3 D Q H O * U L O O H
* H Q H U D O ( T X L S P H Q W 7 Z R / H J 3 X O O H U
5 H P R Y D O
1 2 7 ( 5 H P R Y D O V W H S V L Q W K L V S U R F H G X U H P D \
F R Q W D L Q](/manual-img/11/5478/w960_5478-468.png "FORD KUGA 2011 1.G Workshop Manual & R Z O 3 D Q H O * U L O O H
* H Q H U D O ( T X L S P H Q W 7 Z R / H J 3 X O O H U
5 H P R Y D O
1 2 7 ( 5 H P R Y D O V W H S V L Q W K L V S U R F H G X U H P D \
F R Q W D L Q")
