2010 OPEL COMBO engine oil

177
Opel Service, maintenance
Diesel fuel filter On the event of engine oil change, have
fuel filter checked for possible water
residue by a workshop.
Illumination of A indicates water in the
fuel filter 3.
Have fuel filter checked at shorter intervals
if the vehicle is subjected to extreme
operating conditions such as high humidity
(primarily in coastal areas), extremely high
or low outside temperatures and
substantially varying daytime and
night-time temperatures.
Coolant The coolant provides anti-freeze
protection down to approx. -28 C. .
Picture no: 11676s.tif
Antifreeze and corrosion protection
Have the concentration of the radiator
contents tested by a workshop before
winter starts. The amount of antifreeze
must provide protection down to approx.
-28 C. A lower antifreeze concentration
will reduce the amount of protection from
frost and corrosion. Add antifreeze if
necessary.
If coolant loss is topped up with water,
have concentration checked and add
antifreeze if necessary. Caution
Only use approved anti-freeze.
Coolant additives for additional
corrosion protection and sealing small
leaks can cause operation problems. No
liability is accepted for damage caused
by using coolant additives.
9 Warning
Antifreeze is a danger to health; it must
therefore be kept in the original
container and out of the reach of
children.

181
Opel Service, maintenance
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage.
zWash and wax the vehicle 3161.
zHave the wax in the engine
compartment and underbody checked.
zClean and preserve rubber seals.
zChange engine oil.
zCheck anti-freeze and corrosion
protection 3177.
zCheck the coolant level; top up
anti-freeze if necessary 3178.
zDrain the windscreen washer system.
zIncrease tyre pressure to the value
specified for full load 3121, 3191. zPark the vehicle in dry and
well-ventilated place. With manual
transmission select first or reverse gear;
with manual transmission automated 3
move the selector lever to the centre
position before switching the ignition off.
Use chocks or the like to prevent the
vehicle from rolling.
zDo not apply hand brake.
zDisconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
zCheck tyre pressure 3121, 3191.
zTop up the windscreen washer system
3180.
zCheck engine oil level 3175.
zCheck coolant level 3178.
zFit the number plate if necessary.

184 Technical dataEngine data Sales designation
Engine identifier code1.4 TWINPORT
Z 14 XEPCNG
Z 16 YNG1.3 CDTI
Z 13 DTJ1.7 CDTI
Z 17 DTH
Number of cylinders 4 4 4 4
Piston displacement [cm
3 ] 1364 1598 1248 1686
Brake horse power [kW/bhp]
at rpm 66
560069
620055
400074
4400
Torque [Nm]
at rpm 125
4000133
4200170
1750 to 2500240
2300
Fuel type
1)
1)Standard high-quality fuels, unleaded DIN EN 228, diesel DIN EN 590. Any commercially available natural gas containing methane can be used for
natural gas operation.
Petrol Natural gas/petrol Diesel Diesel
Octane requirement [RON]
2)
recommended
possible
possible
Cetane requirement [CN]
2)
2)Standard high-quality fuels: R = Regular, P = Premium, PP = Premium Plus, D = Diesel. Value printed in bold: recommended fuel.
95 (P)
3)
98 (PP)
3)
91 (R)
3)4)
–
3)Knock control system automatically adjusts ignition timing according to type of fuel used (octane number). 4)Slight reduction in engine output and torque if 91 RON is used.
95 (P)
3)
98 (PP)
3)
–
––
–
–
49 (D)
5)
5)A lower value is possible with winter diesel fuels.
–
–
–
49 (D)
5)
Max. permissible engine speed,
continuous operation approx. [rpm ]. 6200 6400 5020 to 5180 5000 to 5200
Oil consumption [l/1000 km] 0.6 0.6 0.6 0.6

195 Technical data
CapacitiesEngine oil
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Incl. filter [l] 3.5 3.5 5.0
Between MIN and MAX [l] 1.0 1.0 1.0
Fuel tank
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Petrol/diesel, nominal capacity [l] 52 52 52
Engine oil
EngineZ 16 YNG
Incl. filter [l]3.5
Between MIN and MAX [l]1.0
Fuel tank
EngineZ 16 YNG
Natural gas, nominal capacity [kg]
petrol, nominal capacity [l]17.5
1)
14
1)17.5 kg (average fill limit), corresponding to a tank volume of 108 l. Fill weight in kg is dependent on outside temperature, filling pressure and type of
tank system.

199
Index
CCapacities .............................................. 195
Car Pass .................................................... 20
Caravan/trailer towing .................. 106, 125
Care ........................................................ 160
Catalytic converter ............... 114, 118, 129
Central locking system ...................... 23, 24
Centre console lighting ........................... 88
Changeover inhibitor ............................. 114
Changing the remote control battery .... 24
Changing tyre/wheel type ..................... 121
Changing wheels ................................... 137
Child restraint system .............................. 53
Child safety locks ..................................... 27
Cigarette lighter ....................................... 61
Clock ......................................................... 72
Clutch operation ............................ 105, 107
CO
2 emissions ........................................ 186
Coin holder ............................................... 65
Cold start ................................................ 107
Contrast .................................................... 81
Control indicator
ABS (Anti-lock Braking System) ........ 119
Airbag ................................................... 59
Engine electronics .............................. 116
Exhaust ............................................... 115
Immobiliser ........................................... 21
Control indicators .............................. 12, 66
Belt tensioners ...................................... 50
EPS (Electric Power Steering) .............. 70
Coolant ................................................... 177Coolant level .......................................... 178
Coolant temperature display ................. 73
Coolant thermometer .............................. 73
Correcting time ........................................ 80
Coupling socket load ............................ 126
Courtesy lamp ......................................... 88
Courtesy lamps
Bulb replacement ...................... 158, 159
DDashboard, see Instrument panel ........... 9
Data .................................................. 20, 182
Date .......................................................... 77
Daytime running lights ............................ 84
Decommissioning .................................. 181
Demisting and defrosting
Windows ............................................... 96
With the air conditioning system ........ 98
Diesel fuel filter ...................................... 177
Diesel fuel system .................................. 128
Diesel particle filter ............37, 68, 107, 116
Dimensions ............................................. 196
Dipped beam ............................................. 7
Bulb replacement ...................... 151, 155
Display .............................................. 76, 100
Display instruments ................................. 71
Display mode ........................................... 82
Door locks ........................................ 20, 162
Driving abroad .............................. 110, 164
Headlamps ........................................... 89
Driving hints ........................................... 106
EEasytronic ................................................ 15
Driving programmes ......................... 102
Fault ................................................... 104
Interruption of power supply ............ 105
Kickdown ............................................ 103
Selector lever ....................................... 15
Winter programme ............................ 103
Economical driving ................................ 108
Electric power steering .................... 70, 106
Towing ................................................ 131
Electric windows ...................................... 36
Electrical system .................... 145, 180, 195
Electronic components .......................... 180
Electronic immobiliser ............................. 21
Ellipsoidal headlamp system ................ 155
Engine code ........................................... 184
Engine control indicator ....................... 116
Engine oil ....................................... 172, 175
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Engine oil consumption ........ 106, 175, 184
Engine oil level ....................................... 175
Engine speed ......................................... 107
Engine wash ................................... 162, 163
Environmental protection ..................... 160
EPS .................................................... 70, 106
Exhaust control indicator ..................... 115
Exhaust gases ........................................ 116
Exhaust system ...................................... 106
Exterior mirrors ........................ 5, 34, 35, 37

200 IndexFFan ............................................................ 94
Fault .......................................................... 37
Filling station
Capacities ........................................... 195
Engine oil level ................................... 175
Fuel ............................................. 110, 184
Opening the bonnet .......................... 128
Tyre pressure ...................................... 191
Vehicle data ............................... 182, 183
Windscreen washer system ............... 180
First-aid kit ............................................. 133
Flat tyre .................................................. 142
Fog lamps ................................................ 86
Bulb replacement ............................... 156
Fog tail lamp ............................................ 86
Bulb replacement ............................... 157
Foot brake ...................................... 118, 120
Front passenger airbag .......................... 56
Fuel ................................................. 110, 184
Fuel consumption ......... 108, 110, 185, 186
Fuel filter ................................................. 177
Fuel gauge ......................................... 73, 74
Fuel level ................................................... 73
Fuel selection button ............................. 113
Fuel system, diesel ................................. 128
Fuse remover ......................................... 145
Fuses ....................................................... 145
GGas type
H gas .......................................... 110, 188
L gas ................................................... 110
Gears ................................................ 15, 105
Generator, see Alternator ....................... 69
Genuine Opel Parts and Accessories ... 174
Glasses compartment ............................. 63
Glove compartment ................................ 63
Graphical information display ............... 76
Gross vehicle weight .............................. 189
Gross vehicle weight rating .................. 189HHalogen headlamp system .................. 151
Hand brake ................................ 16, 17, 120
Hazard warning lamps ........................... 86
Head restraints .................................. 40, 41
Headlamp flash ....................................... 85
Headlamp range adjustment ................. 87
Headlamp switch ................................ 6, 84
Headlamp washer system ........ 13, 83, 180
Headlamps ................................................ 6
Daytime running lights ........................ 84
Driving abroad ..................................... 89
Fog lamps ............................................ 86
Reversing lamps .................................. 85
Warning device .................................... 82
Headlights
Changing bulbs ......................... 151, 155
Heated exterior mirrors ............... 14, 35, 37Heated front seats .................................. 40
Heated rear window ......................... 14, 37
Heating .............................................. 92, 95
Seats ..................................................... 40
With the air conditioning system ....... 92
Height adjustment
Seat belts ............................................. 52
Steering wheel ........................................6
High pressure jet cleaner ...................... 163
Horn .......................................................... 13
IIdentification plate ........................ 182, 183
Idling ...................................................... 105
Ignition logic ............................................ 82
Ignition switch .......................................... 16
Ignition system .............................. 174, 180
Immobiliser .............................................. 21
Information display ................................. 76
Infotainment system ......................... 76, 90
Instrument illumination ........................... 87
Bulb replacement .............................. 159
Instrument panel ........................................9
Instruments .............................. 9, 66, 71, 72
Interior mirror ....................................... 6, 35
Interruption of power supply
Easytronic ........................................... 105
Electric windows .................................. 37JJack ................................................ 136, 139
Jump leads ............................................. 129

201
Index
KKey
Extending ............................................. 20
Ignition lock .......................................... 16
Locking doors ...........................20, 23, 24
Remove ................................................. 17
Starting ........................................... 16, 21
Starting the engine .............................. 16
Keys ...................................................... 2, 20LLanguage selection ................................. 80
Lashing eyes ............................................ 44
Leaf doors ...................................... 3, 22, 29
Light switch ................................................ 6
Lighting ................................................ 6, 84
Driving abroad ..................................... 89
Load compartment
Loading ................................................ 47
Load compartment grille ........................ 46
Loading ............................................ 47, 126
Loading the vehicle ................................. 47
Locking doors ..............................20, 23, 24
Locking from the inside ..................... 22, 25
Locking the doors .......................... 2, 22, 24
Locks ....................................................... 162
Lubricants .............................................. 175Luggage compartment .......................... 28
Bulb replacement .............................. 158
Cover .................................................... 44
Extension .............................................. 42
Lashing eyes ........................................ 44
Lighting ................................................ 88
Loading ................................ 47, 126, 189
Locking ................................................. 28
Luggage compartment cover ................ 44
MMain beam ........................................... 7, 85
Bulb replacement .............................. 152
Control indicator .................................. 68
Maintenance
Air conditioning system ....................... 99
Antifreeze protection ........................ 177
Brake fluid .......................................... 179
Brakes ................................................. 178
Catalytic converter ............................ 118
Engine oil ............................................ 175
Fuel consumption .............................. 109
Tyre pressure ...................................... 121
Tyres ........................................... 122, 123
Manual transmission ............................. 105
Manual transmission, see Transmission 15
Mirrors ............................................ 6, 34, 35
Misted windows ................................. 96, 98
Mobile telephone ..................................... 91
Muffler, see Exhaust system ................. 116
NNatural gas .............................. 74, 110, 113
Number plate lamps
Bulb replacement .............................. 158
Number plate lighting .......................... 158OOctane numbers .................................... 184
Odometer ................................................. 71
Oil ........................................................... 172
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Oil consumption ............................ 175, 184
Oil level ................................................... 175
Oil pressure .............................................. 67
Opel Service ........................................... 164
Operating temperature ........................ 107
Outside temperature gauge .................. 76
Overrun .......................................... 107, 109