2010 FIAT LINEA RHD fuel filter

75
AT THE FILLING
STATION
PETROL ENGINES
Use only unleaded petrol.
The petrol octane rating (RON) must not
be lower then 91.
IMPORTANT An inefficient catalyst leads
to harmful exhaust emissions,
thus con-
tributing to air pollution.
IMPORTANT Never use leaded petrol,
even in small amount or in an emergency,
as this would damage the catalyst beyond
repair.DIESEL ENGINES
For better performance use only normal
diesel (avoid premium diesel / with addi-
tives) conforming with cetane number 51
minimum for diesel version. If the outside
temperature is very low, the diesel thick
ens due to the formation of paraffin clots
and could clog the diesel fuel filter.
In order to avoid these problems, differ-
ent types of diesel are distributed
ac-
cording to the season: summer type, win-
ter type and arctic type (cold, mountain
areas).If you accidentally introduc-
e ot he r type s of fue l in the
tank, do not start the engine
and empty the tank. If the engine has
run also for a very short time, you will
need to have the entire fuel feed sys-
tem emptied in addition to the tank.
SAFETY
DEVICES CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
LINEA Owner HAND BOOK RHD.pdf 75LINEA Owner HAND BOOK RHD.pdf 758/21/09 2:16:10 PM8/21/09 2:16:10 PM

GENERAL WARNINGS ..................................................... 102
LOW BRAKE FLUID ............................................................ 102
HANDBRAKE ON................................................................ 102
AIR BAG FAILURE ................................................................ 103
HOT
ENGINE COOLANT ........................................................... 103
LOW BATTERY CHARGE ................................................. 104
LOW ENGINE OIL PRESSURE .......................................... 104
INCOMPLETE DOOR LOCKING.................................... 105
SEAT BELTS NOT FASTENED .......................................... 105
EBD SYSTEM FAILURE ........................................................ 105
INJECTION SYSTEM FAILURE
(DIESEL VERSIONS) ............................................................ 106
EOBD SYSTEM FAILURE (PETROL VERSIONS) ......... 106
FRONT PASSENGER AIRBAG DEACTIVATED ........... 107
ABS SYSTEM FAILURE ......................................................... 107
FUEL RESERVE ....................................................................... 107
GLOW PLUG WARMING ................................................ 108
GLOW PLUG WARMING FAILURE ............................... 108
WATER IN DIESEL FUEL FILTER ..................................... 108FIAT CODE PROTECTION
SYSTEM FAILURE .................................................................. 108
EXTERNAL LIGHTS FAILURE........................................... 109
REAR FOG LIGHTS.............................................................. 109
GENERIC FAILURE INDICATION ................................. 109
SIDELIGHTS AND LOW BEAMS ..................................... 110
FOLLOW ME HOME ........................................................... 110
FRONT FOG LIGHTS ........................................................ 110
LEFT-HAND DIRECTION INDICATOR ........................ 110
RIGHT-HAND DIRECTION INDICATOR .................... 110
MAIN BEAM HEADLIGHTS............................................... 110
WW W
A A
R R
N N
I I
N N
G G
L L
I I
G G
H H
T T
S S
A A
N N
D D
M M
E E
S S
S S
A A
G G
E E
S S
101
CORRECT USE
OF THE CAR
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 101LINEA Owner HAND BOOK RHD.pdf 1018/21/09 2:16:14 PM8/21/09 2:16:14 PM

108
GLOW PLUG
WA R M I N G
(Multijet versions - amber)
GLOW PLUG
WARMING FAILURE
(Multijet versions - amber)
Glow plug warming
The warning light will go on when the key
is turned to MAR. It will go out as soon
as the glow plugs have
reached a prede-
termined temperature. Start the engine as
soon as the warning light goes out.
IMPORTANT With hot ambient temper-
ature, warning light stays on for very short
time.
Glow plug warming failure
The warning light will blink in the event
of a failure to the glow plug heating sys-
tem. Go to a Fiat Dealership as soon
as possible.
On certain
versions the dedicated message
is displayed.
WATER IN DIESEL
FUEL FILTER
(Multijet versions - amber)
Turning the ignition key to MARthe
warning light turns on, but it should go off
after few seconds.
The warning light turns on when there is
water in the diesel fuel filter.
On certain
versions the dedicated message
is displayed.
The presence of water in the
feeding circuit may cause se-
vere damage to the injection
system and irregular engine
operation. If warning light lights up
(on some versions with the message on
the display), go to a Fiat Dealership
as soon as possi bl e to hav e the
system bled. Water may have been intro-
duced in the tank if this appears imme-
diate ly afte r refu ellin g: in this case ,
stop the engine immediately and cont-
act a Fiat Dealership.
CAR PROTECTION
SYSTEM FAILURE -
FIAT CODE (amber)
Turning the key to MARthe warning light
shall flash only once and then go off.
If with the ignition key at MAR, the warn-
ing light stays on, this indicates a possible
failure (see “Fiat Code system” in section
“Dashboard and controls”).
IMPORTANT Warning lights and
will come on at the same time to indicate
a Fiat CODE system failure.
If with the engine running the warning light
flashes, this means that the car is not
protected by the engine inhibitor device
(see “Fiat Code system” in section “Dash-
board and controls”).
Contact Fiat Dealership to have all the
key stored.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 108LINEA Owner HAND BOOK RHD.pdf 1088/21/09 2:16:15 PM8/21/09 2:16:15 PM

GENERIC FAILURE
INDICATION
(amber)
The warning light turns on in the follow-
ing circumstances.
Engine oil pressure sensor failure
The warning light turns on when failure is
detected in Engine oil pressure sensor Go
to a Fiat Dealership to have the fault
fixed as soon as possible.
External light fault
(where provided)
See description of warning light .
Fuel cut-off switch tripped
The warning light comes on when the fu-
el cut-off switch trips.
The display will show the dedicated mes-
sage.EXTERNAL LIGHT
FAILURE (amber)
The warning light will come on
(some versions only) when a fault
to one of the following lights is detected:
– side/taillights
– brake lights
– rear fog lights
– direction indicators
– number plate lights.
The fault may be caused by: one or more
burnt lamps, a blow protection fuse or in-
terruption of the electrical connection.
On certain versions warning light
comes on instead.
On certain versions the dedicated message
is displayed.
REAR FOG LIGHTS
(amber)
The warning light comes on
when the rear fog lights are turned on.
Speed limit exceeded
(where provided)
The display will show the dedicated mes-
sage when the car exceeds the set speed
limit (see “Multifunctional Display” in sec-
tion “Dashboard and controls”).
Diesel filter failure
(where provided)
The warning light will come on when a
diesel filter system failure is detected. The
display will show the dedicated message
(where provided).
109
CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 109LINEA Owner HAND BOOK RHD.pdf 1098/21/09 2:16:16 PM8/21/09 2:16:16 PM

20 40 60 80 100 120 140 160 180
SERVICE SCHEDULE PETROL VERSIONS
Service coupons shall be performed every 20,000 kms or every 12 months whichever occur first
Thousands of kilometres
Check tyre conditions/wear and adjust pressure if
necessary
Check operation of lighting system (headlamps,
direction indicators, hazard warning lights, luggage
compartment light, passenger compartment lights,
instrument panel warning lights, etc.)
Check operation of windscreen wash/wipe
Check front disc brake pad condition and wear
Check rear drum brake linings condition and wear
Visually inspect conditions and integrity: exterior
bodywork, underbody protection(**), pipes and hoses
(exhaust - fuel - brakes), rubber parts (boots,
sleeves, bushes, etc.), Oil leakage and Coolant leakage, evaporation control system
Check cleanness of locks, bonnet and boot and
lever cleanness and lubrication
Visually inspect condition of the auxiliary drive belt/s
and accessory drive belt
Replace auxiliary drive belt/s and accessory drive
belt
Check handbrake lever travel and adjust if necessary
Replace fuel filter
Replace air filter cartridge ( )
139
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 139LINEA Owner HAND BOOK RHD.pdf 1398/21/09 2:16:22 PM8/21/09 2:16:22 PM

SERVICE SCHEDULE DIESEL VERSIONS
Service coupons shall be performed every 15,000 kms
Thousands of kilometres
Check tyre conditions/wear and adjust pressure if
necessary
Check operation of lighting system (headlamps,
direction indicators, hazard warning lights, luggage
compartment light, passenger compartment lights,
instrument panel warning lights, etc.)
Check operation of windscreen wash/wipe
Check front disc brake pad condition and wear,
replace if required
Check rear drum brake linings condition and wear,
replace if required
Visually inspect conditions and integrity: exterior
bodywork, underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts (boot, sleeves,
bushes, etc.), Oil leakage and Coolant leakage
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Visually inspect condition of the auxiliary drive belt/s
and accessory drive belt, replace if required
Replace drive belt/s and accessory drive auxiliary
belt
Check handbrake lever travel and adjust if necessary
Replace fuel filter15 30 45 60 75 90 105 120 135 150 165 180Inspection
at 3000 kms
141
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 141LINEA Owner HAND BOOK RHD.pdf 1418/21/09 2:16:22 PM8/21/09 2:16:22 PM

DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
trailer or caravan towing;
dusty roads;
short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
frequently idling engines or long dis-
tance low speed driving (e.g . taxis or
door-to-door deliveries) or in case of
a long term inactivity;
in cities;
perform the following inspections and
shown on the Service Schedule:

check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
visually inspect the accessory drive belt
conditions;
check pollen filter
check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
 engine coolant fluid level; Engine Oil level, every 3,000 km and
brake - clutch fluid level and type;
power steering fluid level;


tyre pressure and conditions;
operation of lights (headlights, direction
indicators, hazard lights, etc.);
143
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
. If the vehicle is
replacements more frequently than
check front disk brake pad conditions
and wear; frequently than required; replace engine oil and oil filter more
frequently
than required on the service replace spark plugs more
schedules, in particular contact a Fiat
Dealership if a reduction in the
vehicle engine performance is noted;used frequently in dusty or heavily
polluted environments it is
advisable to replace the filtering
elementts more frequently, in
particular it should be replaced if a
reduction of the amount of air
admitted to the passenger
compartment is noted; top up if required;
LINEA Owner HAND BOOK RHD.pdf 143LINEA Owner HAND BOOK RHD.pdf 1438/21/09 2:16:22 PM8/21/09 2:16:22 PM

Specified fuels and
genuine lubricants
Unleaded petrol with RON 91
minimum
minimum Diesel with cetane number 51
Mixture of 40% PARAFLU UP
& 60% demineralized water
Synthetic base SAE 5W40 grade
Synthetic base SAE 5W40 grade engine oil
engine oil
ZC 75/FF
GI/E F7
TO P 4
Mixture of 10% of fluid SC35 &
90% of distilled water1.3 Multijet
–
–
45
5 ÷ 7
7.6
–
–
3.2
1.82.2
1.03
2.01.4 16v
45
5 ÷ 7
–
–
7.6
2.7
3.3
3.0 –
–
2.2
1.8
1.03
0.4 without ABS 0.4 without ABS
0.5 with ABS 0.5 with ABS
2.0
CAPACITIES
Fuel tank:
including a reserve of:
Fuel tank: including a reserve of:
Cooling system
engine:
Engine sump:
Engine sump and filter:
Engine sump:
Engine sump and filter:
Gearbox/
differential casing: kg
Power steering:
Hydraulic brake circuit:
Windscreen washer
reservoir:
(*) Do not top up with oil having specifications different from the oil present in the car.
172
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
DASHBOARD
SAFETY
litres litres litres
litres
litres litres litres litres litres litres
litres
litres
kg
LINEA Owner HAND BOOK RHD.pdf 172LINEA Owner HAND BOOK RHD.pdf 1728/21/09 2:16:37 PM8/21/09 2:16:37 PM