2010 FIAT LINEA RHD engine oil

74
TRANSCEIVERS
AND MOBILE PHONES
Radio transceiver equipment (e.g.: e-tacs
mobile phones, HAM radio systems and
the like) shall not be used inside the car
unless a separate aerial is mounted on the
roof.
IMPORTANT The use of similar devices
inside the passenger compartment (with-
out separated aerial) produces radio-fre-
quency electromagnetic fields which,
am-
plified by the resonance effects inside the
passenger compartment,
may cause elec-
trical systems equipping the car to mal-
function. This could compromise safety in
addition to constituting a potential hazard
for the passengers.
In addition, transmission and reception of
these devices may be affected by the
shielding effect of the car body.
As concerns EC-approved mobile phones
(GSM, GPRS, UMTS),
strictly comply with
the instructions for use provided by the
mobile phone’s manufacturer.
ACCESSORIES
PURCHASED BY THE
OWNER
If after buying the car, you decide to install
electrical accessories that require a per-
manent electric supply (alarm, satellite an-
titheft system, etc.) or accessories that in
any case burden the electric supply,
con-
tact Fiat Dealership,
whose qualified
perso nnel, beside s sugge sting the most suitable devices belonging to Linea access-
ories Fiat, will also evaluate the overall elect-
ric absorption,
checking whether the car’s
electric system is able to withstand the
load required, or whether it needs to be
integrated with a more powerful battery.
Be very careful when fitting
non-standard additional
spoilers , light alloy wheels or wheel
cups: they could reduce brake
venti-
lation and consequently brake effi-
ciency in the case of repeated, violent
braking or on long downhill roads.
Make sure that nothing obstructs the
pedal stroke (mats, etc.)
WARNING
ELECTRICAL/ELECTRONIC
DEVICE INSTALLATION
Electrical and electronic devices installed
after buying the car by after-market ser-
vice must carry the following label:
auth-
orises the installation of transceiving dev-
ices provided that they are installed accord-
ing to rules of good engineering practice
respecting the manufacturer’s indications
by a specialised centre.
IMPORTANT Traffic police may not allow
the car on the road in the event of
as-
sembly of devices which imply modifica-
tions to the features of the car. This may
also cause lapse of warranty in relation to
faults caused by the change or either di-
rectly or indirectly related to it.
shall
not be liable for damage caused by the
installation of accessories either not sup-
plied or recommended by
and/or installed
in compliance with the provided instruc-
tions.
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
Fiat Group Automobiles South Africa (Pty) Ltd
Fiat Group Automobiles South Africa (Pty) Ltd
Automobiles South Africa (Pty) Ltd
Fiat Group
LINEA Owner HAND BOOK RHD.pdf 74LINEA Owner HAND BOOK RHD.pdf 748/21/09 2:16:10 PM8/21/09 2:16:10 PM

Electric devices
Use electric devices only for the amount
of time needed. Rear heated window, ad-
ditional headlights, windscreen wipers and
heater fan need a considerable amount of
energy, therefore increasing the require-
ment of current increases fuel consump-
tion (up to +25% in the urban cycle).
Climate control
The climate control system requires high-
er fue l consumptio n (up to +20% in av-
erage): use the air vents when the exter-
nal temperature allows to.
Spoilers
The use of non-c erti fied aerodynamic
item s may advers ely affe ct air drag and
consumption levels.DRIVING STYLE
Starting
Do not warm the engine up with the car
standing: the engine warms up very slow-
ly in these condition s, increasing con-
sumption and emissions. It is advisable to
start off immediately and slowly keeping
the engine speed down: the engine will
warm up much faster this way.
Unnecessary actions
Avoid revving up when starting at traffic
lights or before stopping the engine. The
latter action, like doubling the clutch, is un-
necessary and causes increase of con-
sumption and pollution.
Gear selection
Use a higher gear as soon as traffic and
road conditions allow. Using a low gear
for faster acceleration will increase con-
sumption.
In the same way improper use of a high
gear increases consumption, emissions an
engine wear.CONTAINING
RUNNING COSTS
Here are some suggestions which may
help you to keep the running costs of your
car down and lower the amount of toxic
emissions released into the atmosphere.
GENERAL CONSIDERATIONS
Car maintenance
Have checks and adjustments carried out
in accordance with the “Service schedule”.
Ty r e s
Check tyre pressure regularly at least
once ever y four weeks: excessively low
pressure will increase consumption be-
cause rolling resistance will be higher.
Unnecessary loads
Do not travel with too much luggage
stowed in the boot. The weight of the car
(especially when driving in town) and its
trim greatly affects consumption and sta-
bility.
98
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
MESSAGES
DASHBOARD
SAFETY
LIGHTS AND
IN AN
CAR
TECHNICAL
WARNING
LINEA Owner HAND BOOK RHD.pdf 98LINEA Owner HAND BOOK RHD.pdf 988/21/09 2:16:14 PM8/21/09 2:16:14 PM

GENERAL WARNINGS ..................................................... 102
LOW BRAKE FLUID ............................................................ 102
HANDBRAKE ON................................................................ 102
AIR BAG FAILURE ................................................................ 103
HOT
ENGINE COOLANT ........................................................... 103
LOW BATTERY CHARGE ................................................. 104
LOW ENGINE OIL PRESSURE .......................................... 104
INCOMPLETE DOOR LOCKING.................................... 105
SEAT BELTS NOT FASTENED .......................................... 105
EBD SYSTEM FAILURE ........................................................ 105
INJECTION SYSTEM FAILURE
(DIESEL VERSIONS) ............................................................ 106
EOBD SYSTEM FAILURE (PETROL VERSIONS) ......... 106
FRONT PASSENGER AIRBAG DEACTIVATED ........... 107
ABS SYSTEM FAILURE ......................................................... 107
FUEL RESERVE ....................................................................... 107
GLOW PLUG WARMING ................................................ 108
GLOW PLUG WARMING FAILURE ............................... 108
WATER IN DIESEL FUEL FILTER ..................................... 108FIAT CODE PROTECTION
SYSTEM FAILURE .................................................................. 108
EXTERNAL LIGHTS FAILURE........................................... 109
REAR FOG LIGHTS.............................................................. 109
GENERIC FAILURE INDICATION ................................. 109
SIDELIGHTS AND LOW BEAMS ..................................... 110
FOLLOW ME HOME ........................................................... 110
FRONT FOG LIGHTS ........................................................ 110
LEFT-HAND DIRECTION INDICATOR ........................ 110
RIGHT-HAND DIRECTION INDICATOR .................... 110
MAIN BEAM HEADLIGHTS............................................... 110
WW W
A A
R R
N N
I I
N N
G G
L L
I I
G G
H H
T T
S S
A A
N N
D D
M M
E E
S S
S S
A A
G G
E E
S S
101
CORRECT USE
OF THE CAR
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 101LINEA Owner HAND BOOK RHD.pdf 1018/21/09 2:16:14 PM8/21/09 2:16:14 PM

LOW ENGINE OIL
PRESSURE (red)
Turning the ignition key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started.
On certain versions the dedicated message
is displayed.
If the warning light
turns on when the car is trav-
elling (on cer tain versions together
with the message on the display) stop
the engine immediately and contact
a Fiat Dealership.
WARNING
In the case of demanding use (e.g.
towing traile rs uphill or car at full
load): slow down and stop the car if
the warning light stays on. Stand for
2 or 3 minutes with the engine running
and slightly accelerated to promote a
better circulation of coolant.
Then
stop the engine. Check correct liquid
level as described above.
IMPORTANT Under severe use of the
car, keep the engine on and slightly accel-
erated for few minutes before switching it
off.
On certain versions the dedicated message
is displayed.LOW BATTERY
CHARGE (red)
Turning the igni tion key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started (with the engine running at idle
speed a brief delay in going out is allowed).
Go to a Fiat Dealership immediately
if the warning light stays on either ste-
ady or blinking.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
104
LINEA Owner HAND BOOK RHD.pdf 104LINEA Owner HAND BOOK RHD.pdf 1048/21/09 2:16:15 PM8/21/09 2:16:15 PM

GENERIC FAILURE
INDICATION
(amber)
The warning light turns on in the follow-
ing circumstances.
Engine oil pressure sensor failure
The warning light turns on when failure is
detected in Engine oil pressure sensor Go
to a Fiat Dealership to have the fault
fixed as soon as possible.
External light fault
(where provided)
See description of warning light .
Fuel cut-off switch tripped
The warning light comes on when the fu-
el cut-off switch trips.
The display will show the dedicated mes-
sage.EXTERNAL LIGHT
FAILURE (amber)
The warning light will come on
(some versions only) when a fault
to one of the following lights is detected:
– side/taillights
– brake lights
– rear fog lights
– direction indicators
– number plate lights.
The fault may be caused by: one or more
burnt lamps, a blow protection fuse or in-
terruption of the electrical connection.
On certain versions warning light
comes on instead.
On certain versions the dedicated message
is displayed.
REAR FOG LIGHTS
(amber)
The warning light comes on
when the rear fog lights are turned on.
Speed limit exceeded
(where provided)
The display will show the dedicated mes-
sage when the car exceeds the set speed
limit (see “Multifunctional Display” in sec-
tion “Dashboard and controls”).
Diesel filter failure
(where provided)
The warning light will come on when a
diesel filter system failure is detected. The
display will show the dedicated message
(where provided).
109
CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 109LINEA Owner HAND BOOK RHD.pdf 1098/21/09 2:16:16 PM8/21/09 2:16:16 PM

7.5
7.5
7.5
15
20
20
7.5
7.5
7.5
20
10
30
7.5
20 F12
F13
F31
F32
F33
F34
F35
F36
F37
F38
F39
F40
F42
F43
FUSE TABLE
Fuse box on dashboard
LOADS FUSE AMPERES
Right dipped beam headlight
Left dipped beam headlight, headlight corrector
INT/A for relay coils (T08, T17) in engine compartment fuse box and body
computer node
Subwoofer
Power windows control unit (left rear window motor)
Power windows control unit (right rear window motor)
+15 reversing lights, brake lights control, air mass meter, glow plug pre-heating
unit, water in diesel fuel sensor, tachometer generator, level sensor 2
Power window unit (+30 for electronics)
+15 instrument panel, NA brake lights control
Body computer node
Radio node
Heated rear window
+15 brake system node
Windscreen wiper control (two-way pump)
131
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 131LINEA Owner HAND BOOK RHD.pdf 1318/21/09 2:16:21 PM8/21/09 2:16:21 PM

15
15/20
20
–
50
15 F21
F22
F23
F24
F00
F30
LOADSFUSE AMPERES
Fuel pump
Engine control system primary loads (injectors, ignition coils)
Windscreen wiper motor
Spare
Glow plug pre-heating unit
Fog lights
134
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 134LINEA Owner HAND BOOK RHD.pdf 1348/21/09 2:16:21 PM8/21/09 2:16:21 PM

Thousands of kilometres
Replace spark plugs
Check and Top up fluid levels (engine coolant, brake
fluid, screen washer, battery, and power steering oil,
etc, if requried) ( )
Check condition of toothed driving belt
Check operation of engine management systems
(using diagnostic socket) Replace toothed timing drive belt (*)
Change brake / clutch fluid (every 60000 kms or
24 months, whichever is earlier) Change engine oil and replace oil filter
(every 20,000 kms or 12 months, whichever is earlier)
Change pollen filter
(*) Regardless of the km covered, the timing belt shall be replaced every 3 years for particularly demanding use
(cold climates, driving in the city, idling for a long time) or in any case every 5 years
(**) Paint and or body damages must promply be rectified to prevent possible deterioration of paint and ( ) Regardless of the km covered, Air filter should be replaced earlier if operating in dusty condition
140
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
20 40 60 80 100 120 140 160 180
Check transmission oil level
( ) Change power steering oil every 24 months
formation of rust
LINEA Owner HAND BOOK RHD.pdf 140LINEA Owner HAND BOOK RHD.pdf 1408/21/09 2:16:22 PM8/21/09 2:16:22 PM