2010 FIAT LINEA RHD window

7.5
7.5
7.5
15
20
20
7.5
7.5
7.5
20
10
30
7.5
20 F12
F13
F31
F32
F33
F34
F35
F36
F37
F38
F39
F40
F42
F43
FUSE TABLE
Fuse box on dashboard
LOADS FUSE AMPERES
Right dipped beam headlight
Left dipped beam headlight, headlight corrector
INT/A for relay coils (T08, T17) in engine compartment fuse box and body
computer node
Subwoofer
Power windows control unit (left rear window motor)
Power windows control unit (right rear window motor)
+15 reversing lights, brake lights control, air mass meter, glow plug pre-heating
unit, water in diesel fuel sensor, tachometer generator, level sensor 2
Power window unit (+30 for electronics)
+15 instrument panel, NA brake lights control
Body computer node
Radio node
Heated rear window
+15 brake system node
Windscreen wiper control (two-way pump)
131
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 131LINEA Owner HAND BOOK RHD.pdf 1318/21/09 2:16:21 PM8/21/09 2:16:21 PM

LOADS FUSE AMPERES
Cigar lighter or socket
Boot lock actuator
Power window unit (driver’s side front window motor)
Power window unit (passenger’s side front window motor)
+15 control lighting: radio on steering wheel, control panel; power mirrors,
power window unit, alarm setup
+15 airbag node
+15 radio setup, Blu&Me setup
Power window unit, driver’s seat adjustment motor
Body computer and instrument panel node F44
F45
F47
F48
F49
F50
F51
F52
F5315
10
20
20
7.5
7.5
7.5
15
7.5
132
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 132LINEA Owner HAND BOOK RHD.pdf 1328/21/09 2:16:21 PM8/21/09 2:16:21 PM

WINDSCREEN WIPER
BLADES
Period ically clean the rub ber part with
suitable products.
Replace the blades if the rubber edge is
deformed or worn. In all cas es, it is ad-
visable to replace them approximately
once a year.
A few simple precautions can reduce the
possibility of damage to the blades:
make sure that the rubber part is not
stuck to the windscreen at sub-zero
temperatures. Use an antifreeze prod-
uct to release it if required.
remove the snow from the window:
this will avoid overstressing the elec-
trical motor in addition to protecting
the blades;
do not operate the windscreen wipers
on dry glass.
Driving with worn wiper
blades is a serious hazard,
because visibility is reduced in bad
weather.
WARNING
RUBBER HOSES
Carefully follow the information contained
in the “Service schedule” in this section
for maintenance of brake system and fuel
feed rubber hoses.
Ozone, high temperatures and prolonged
lack of fluid in the system may cause hard-
ening and cracking of the hoses, with pos-
sible leaks. Careful inspections are there-
fore necessary.Excessively low pressure will
cause overheating of the
tyre and may cause severe tyre dam-
age.
WARNING
Do not exchange the tyres
from the left to the right of
the car and vice versa.
WARNING
Do not repaint alloy wheel
rims at temperatures higher
than 150°C. The mechanical features
of the wheels could be compromised.
WARNING
153
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 153LINEA Owner HAND BOOK RHD.pdf 1538/21/09 2:16:35 PM8/21/09 2:16:35 PM

Replacing the windscreen wiper
blades fig. 10
How to remove the blade:
raise the windscreen wiper arm Afrom
the windscreen;
turn blade B90° around pin C, locat-
ed at the end of the wiper arm;
press the blade locking tabs;
remove the blade from pin C.
fig. 10F0R0236m
SPRAY NOZZLES
Windscreen washer fig. 11
If there is no jet of fluid, firstly check that
there is fluid in the reservoir: see “Check-
ing fluid levels” in this section).
Then check that the nozzle holes are not
clogged, if necessary using a needle.
The windscreen jets are directed by ad-
justing the angle of the nozzles.
Fluid jets shall be directed at about
1/3height from the window upper edge.
fig. 11F0R0143m
How to insert the blade:
insert the blade fastening tabs in the
hole on the end of the arm;
refit the arm with the blade on the
windscreen.
154
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 154LINEA Owner HAND BOOK RHD.pdf 1548/21/09 2:16:35 PM8/21/09 2:16:35 PM

Normal maintenance of paintwork consists
in washing the car: the frequency depends
on the conditions and environment where
the car is used. For example, it is advisable
to wash the car more often in areas with
a high environmental pollution or on roads
sprinkled with salt.
To correctly wash the car:
remove the aerial from the roof to pre-
vent damage to it if the car is washed in
an automatic system;
wash the body using a low pressure jet
of water;
wipe a sponge with a slightly soapy so-
lution over the bodywork, frequently
rinsing with the sponge;
rinse well with water and dry with a jet
of air or a chamois leather.
Dry the parts less in sight particularly care-
ful ly, such as the door fram es and the
headlight frames, where water may stag-
nate more easily. It is a good idea to leave
the car in the open for a while after wash-
ing it to give time for the water to evap-
orate.Do not wash the car after it has been
parked in the sun or when the engine is
bonnet is hot: this could take the shine off
the paint.
Exterior plastic parts must be cleaned in
the same way as the rest of the car.
Where possible, do not park under trees;
the resinous substance many species re-
lease give the paint a dull appearance and
increase the possibility of triggering rust
processes.
IMPORTANT Bir d droppings must be
washed off immediately and thoroughly as
the acid they contain is partic ularly ag-
gressive.
Detergents cause water pollu-
tion. The car should be washed
in areas equipped for collect-
ing and purifying the liquid
used in the washing process.
Windows
Use specific window cleaner products.
Use also clean cloths to avoid scratching
the glass or damaging the transparency.
IMPORTANT The inside of the rear win-
dow should be wiped gently with a cloth
in the direction of the filaments to avoid
damaging the heating device.
Engine compartment
Wash the engine compartment carefully
after the end of the winter. Be careful not
to direct the jet of water onto electronic
control units. Adequately protect the up-
per air vents to prevent damage to the
windscreen wiper motor. Have this op-
eration performed at a specialised work-
shop.
IMPORTANT Perform this operation on
a cold engine and with the key at STOP.
After the washing operation, make sure
that the various protections (e.g. rubber
caps and guards) have not removed or
damaged.
Front headlights
IMPORTANT Never use aromatic sub-
stances (e.g.: petrol) or ketenes (e.g.: ace-
tone) for cleaning front headlight plastic
lens.
156
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 156LINEA Owner HAND BOOK RHD.pdf 1568/21/09 2:16:36 PM8/21/09 2:16:36 PM

GENUINE LEATHER STEERING
WHEEL/GEAR LEVER KNOB
These components must be cleaned with
mild soap and water only.
Never use spirit and/or alcohol based
products.
Before using off-the-shelves products de-
signed for cleaning car interiors, make sure
that they do not contain spirit and/or al-
cohol based substances before using them.
If window cleaner accidentally drips onto
the steering wheel or gear lever knob,
wipe away immediately and then wash the
concerned area with mild soap and water. IMPORTANT Be carefully when arranging
a steering wheel lock device, where applic-
able, to prevent damaging the leather up-
holstery by rubbing. INTERIOR PLASTIC PARTS
It is advisable to clean interior parts with a
moist cloth and a solution of water and mild
soap. Use specific products for cleaning plas-
tic, without solvents and specifically de-
signed to prevent damage to the appearance
and colour of the treated parts to remove
grease and tough stains.
IMPORTANT Never use spirit or petro-
leum to clean the instrument panel.
158
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 158LINEA Owner HAND BOOK RHD.pdf 1588/21/09 2:16:36 PM8/21/09 2:16:36 PM

Lubricants and
greases for trans-
missionSAE 80W EP oil exceeding API Gl4 and MIL-L-2105
specifications.
‘ATF DEXRON II D LEV’ oil
Molybdenum disulphide, lithium-soap based grease,
water resistant N.L.G.I. consistency =2
o Synthetic fluid, NHTSA n 116, DOT 4, ISO 4925,
SAE J 1703
Protective inhibited monoethylene glycol based
antifreeze compound, CUNA NC 956-16
Alcohol, water and surfactants mixture CUNA
NC 956-II
ZC 75/FF
GI/E F7
MRM 2
TUTELA TOP 4
PARAFLU UP
SC 35Manual transmissions
and differentials
Hydraulic power
steering
CV joints
Hydraulic Brake and
hydraulic clutch
commands
Use percentage:
Mixture of 40% PARAFLU-
UP & 60% demineralized
water
Use percentage:
10% of fluid SC 35
and 90% distilled
water Hydraulic
brake/clutch fluids
Radiator antifreeze
Windscreen
window washer
fluid Use Fluid and lubricant specificationsGenuine fluids and Applications
for correct car operation lubricants
174
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
DASHBOARD
SAFETY
LINEA Owner HAND BOOK RHD.pdf 174LINEA Owner HAND BOOK RHD.pdf 1748/21/09 2:16:37 PM8/21/09 2:16:37 PM

176
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Dimensions ........................................ 169
Dipped beam headlights
- control ........................................... 51
- bulb replacement ........................ 122
Direction indicators
- control ........................................... 52
- front bulb replacement ..............
122
- rear bulb replacement ............... 123
- side bulb replacement ................
123
Doors .................................................. 64
Engine
- identification code ...................... 161
- marking ..........................................
160
- technical data ............................... 162
Engine compartment
- washing ..........................................
156
Engine coolant ...................................
147
Engine coolant temperature gauge .. 15
Engine oil
- consumption ................................ 146
- level check .................................... 146
- specifications ................................
173
EOBD system .................................... 72
External lights .................................... 51
Fiat CODE system .......................... 6
Flashing the headlights ..................... 51
Fluid levels ..........................................
146
Fluids and lubricants ........................ 173
Follow me home (device) ............... 52
Front ceiling lights
- bulb replacement ........................ 126
- control ........................................... 54
Front fog lights
- bulb replacement ........................ 123
- control button ............................. 57
Fuel
- level gauge .................................... 15
Fuel cut-off switch ............................ 59
Fuel filler cap ..................................... 76
Fuel level gauge ................................. 15
Fuses (replacement) ........................ 128
Gearbox
- using manual gearbox .................
97
Glass holder - can holder ............... 62
Glove box/oddment compartment .. 60
Handbrake ........................................ 96
Hazard lights ...................................... 57
Head restraints
- front ............................................... 33
- rear .................................................
34
Headlights
- beam adjustment ......................... 70
Heated rear window ....................... 42
Heating and ventilation ................... 37
Identification data ............................ 160
Ignition device ................................... 12
In an emergency ............................... 111
Instrument panel .............................. 13
Instruments ....................................... 14
Interior fittings .................................. 60
Interiors ............................................. 157
Jack ..................................................... 114
jacking the car ...................................
116
LINEA Owner HAND BOOK RHD.pdf 176LINEA Owner HAND BOOK RHD.pdf 1768/21/09 2:16:38 PM8/21/09 2:16:38 PM