2010 DODGE CARAVAN spare wheel

CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated in Step 5.
6. Place the wrench on the jack screw and turn to the
right until the jack head is properly engaged in the
described location. Do not raise the vehicle until you are
sure the jack is securely engaged.
7. Raise the vehicle by turning the jack screw to the right,
using the swivel wrench. Raise the vehicle only until the
tire just clears the surface and enough clearance is
obtained to install the spare tire. Minimum tire lift
provides maximum stability.
WARNING!
Raising the vehicle higher than necessary can make
the vehicle less stable. It could slip off the jack and
hurt someone near it. Raise the vehicle only enough
to remove the tire.
8. Remove the wheel lug nuts, for vehicles with wheel
covers, remove the cover from the wheel by hand. Do not
pry the wheel cover off. Then pull the wheel off the hub.
9. Install the compact spare tire. Lightly tighten the lug
nuts. To avoid the risk of forcing the vehicle off the jack,
do not tighten the lug nuts fully until the vehicle has been
lowered.
NOTE:
•Do not install the wheel cover on the compact spare.
•Do not use a hammer or force to install the wheel
covers.
6
WHAT TO DO IN EMERGENCIES 417
ProCarManuals.com

10. Lower the vehicle by turning the jack screw to the
left.
11. Finish tightening the lug nuts. Push down on the
wrench while tightening for increased leverage. Alternate
lug nuts until each nut has been tightened twice. The
correct wheel nut tightness is 95 ft lbs (130 N·m). If in
doubt about the correct tightness, have them checked
with a torque wrench by your authorized dealer or at a
service station.
12. Lower the jack to its fully-closed position.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the ve-
hicle. Always stow the jack parts and the spare tire in
the places provided. Have the deflated (flat) tire
repaired or replaced immediately.13. Place the deflated (flat) tire and compact spare tire
cover assembly. in the rear cargo area.
Do not stow the
deflated tire in the spare tire location. Have the full-
sized tire repaired or replaced, as soon as possible.
14. Stow the cable and wheel spacer before driving the
vehicle. Reassemble the winch handle extensions to form
a “T” and fit the winch “T” handle over the drive nut.
Rotate the nut to the right until the winch mechanism
clicks at least three times.
15. Stow the jack, jack handle and winch handle tools.
16. Check the compact spare tire pressure as soon as
possible. Correct the tire pressure, as required.
418 WHAT TO DO IN EMERGENCIES
ProCarManuals.com

Wheel Nuts
All wheel nuts should be tightened occasionally, to
eliminate the possibility of wheel studs being sheared or
the bolt holes in the wheels becoming elongated. This is
especially important during the first few hundred miles
of operation, and after each time a tire is changed, to
allow the wheel nuts to become properly set. All nuts
should first be firmly seated against the wheel. The nuts
should then be tightened to recommended torque.
Tighten the nuts to final torque in increments. Progress
around the bolt circle, tightening the nut opposite to the
nut just previously tightened until final torque is
achieved. Recommended torque is 95 ft lbs (130 N·m).
Secure The Spare Tire
1. Assemble the winch handle extensions to form a “T”
and fit the winch “T” handle over the drive nut. Rotate
the nut to the left until the winch mechanism stopsturning freely. This will allow enough slack in the cable to
allow you to pull the wheel spacer out from under the
vehicle.
WARNING!
A loose compact spare tire/cover assembly, thrown
forward in a collision or hard stop could endanger
the occupants of the vehicle. Always stow the com-
pact spare tire with the cover assembly in the place
provided.
CAUTION!
The winch mechanism is designed for use with the
winch “T” handle only. Use of an air wrench or other
power tools is not recommended and can damage the
winch.
6
WHAT TO DO IN EMERGENCIES 419
ProCarManuals.com

2. Assemble the winch handle extensions to form the
spare tire hook, and pull the wheel spacer from under the
vehicle.
3. Turn the compact spare tire so that the valve stem is
down, and place the tire into the spare tire/cover assem-
bly. Slide the wheel spacer through the center of the
wheel and spare tire/cover assembly, so that the two
retainer tabs snap out and engage the spare tire cover on
the opposite side.
CAUTION!
The compact spare tire/cover assembly must be used
when the compact spare tire is stored. Failure to use
this cover could drastically reduce the life of the
compact spare tire.
WARNING!
Verify that both retainer tabs of the wheel spacer
have been properly extended through the center of
the wheel and spare tire/cover assembly. Failure to
properly engage both retainer tabs could result in
loss of the spare tire and cover assembly, which will
cause vehicle damage and may cause loss of vehicle
control.
4. Using the winch “T” handle, rotate the drive nut to the
right until the compact spare tire/cover assembly is
drawn into place against the underside of the vehicle.
5. Continue to rotate the nut to the right until you hear
the winch mechanism click three times. It cannot be
overtightened. Check under the vehicle to ensure the
compact spare tire/cover assembly is positioned cor-
rectly against the underside of the vehicle.
420 WHAT TO DO IN EMERGENCIES
ProCarManuals.com

Caps, FillerFuel ............................... 381
Oil (Engine) .......................... 439
Power Steering ........................ 335
Radiator (Coolant Pressure) ............... 451
Car Washes ............................ 460
Carbon Monoxide Warning ..............100,377
Cargo Compartment Luggage Carrier ....................... 215
Cargo (Vehicle Loading) ................... 208
Caution, Exhaust Gas ................... 51,377
Cellular Phone ....................... 122,297
Center High Mounted Stop Light ............ 476
Changing A Flat Tire ..................... 407
Chart, Tire Sizing ........................ 347
Check Engine Light
(Malfunction Indicator Light) .............234,434
Checking Your Vehicle For Safety ............ 100
Checks, Safety .......................... 100 Child Restraint
...................... 86,88,89
Child Restraint Tether Anchors ............... 92
Child Safety Locks ........................ 46
Child Seat .............................. 91
Clean Air Gasoline ....................... 373
Cleaning Wheels ............................. 461
Climate Control ......................... 297
Clock ........................ 258,260,263,272
Coat Hook ............................ 207
Coin Holder ........................... 208
Cold Weather Operation ................... 322
Compact Disc (CD) Maintenance ............. 296
Compact Spare Tire ...................... 358
Compass ........................ 241,244,250
Compass Calibration .................. 244,250
Compass Variance .................... 243,251
Computer, Trip/Travel .................... 248
512 INDEX
ProCarManuals.com

Remote.............................. 27
Starting and Operating .................... 321
Starting Procedures ...................... 321
Steering Power .............................. 335
Tilt Column .......................... 165
Steering Wheel Mounted Sound
System Controls ......................... 295
Storage ............................ 201,472
Storage Bin ............................ 201
Storage, Vehicle ...................... 315,472
Storing Your Vehicle ...................... 472
Stow \bn Go (Fold in Floor) Seats ............. 132
Sun Roof .............................. 192
Sunglasses Storage ....................... 184
Sunroof Maintenance ..................... 195
Supplemental Restraint System - Airbag ........ 67
Synthetic Engine Oil ...................... 439
System, Remote Starting .................... 27 Tachometer
............................ 230
Temperature Control, Automatic (ATC) ........ 306
Temperature Gauge, Engine Coolant .......227,407
Tether Anchor, Child Restraint ............... 92
Tilt Steering Column ..................... 165
Tire and Loading Information Placard ......... 351
Tire Identification Number (TIN) ............. 349
Tire Markings .......................... 345
Tire Safety Information .................... 345
Tires ........................... 104,355,507
Aging (Life of Tires) .................... 361
Air Pressure .......................... 355
Changing ............................ 407
Compact Spare ........................ 358
Flat Changing ........................ 418
General Information .................... 355
High Speed .......................... 357
Inflation Pressures ..................... 356
Jacking ........................... 407,410
10
INDEX 525
ProCarManuals.com