2010 CHRYSLER PT CRUISER steering

MAINTENANCE PROCEDURES
The pages that follow contain therequiredmaintenance
services determined by the engineers who designed your
vehicle.
Besides those maintenance items specified in the fixed
maintenance schedule, there are other components which
may require servicing or replacement in the future.
CAUTION!
•Failure to properly maintain your vehicle or per-
form repairs and service when necessary could
result in more costly repairs, damage to other
components or negatively impact vehicle perfor-
mance. Immediately have potential malfunctions
examined by an authorized Chrysler Group LLC
dealership or qualified repair center.
(Continued)
CAUTION! (Continued)
•Your vehicle has been built with improved fluids
that protect the performance and durability of
your vehicle and also allow extended maintenance
intervals. Do not use chemical flushes in these
components as the chemicals can damage your
engine, transmission, power steering or air condi-
tioning. Such damage is not covered by the New
Vehicle Limited Warranty. If a flush is needed
because of component malfunction, use only the
specified fluid for the flushing procedure.
Engine Oil
Checking Oil Level
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop.
7
MAINTAINING YOUR VEHICLE 281

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission MOPARATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4 product.
Brake Master Cylinder MOPARDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPARPower Steering Fluid +4, MOPAR ATF+4Automatic Trans-
mission Fluid or equivalent licensed ATF+4 product.
318 MAINTAINING YOUR VEHICLE

Miles108,000 111,000 114,000 117,000 120,000
(Kilometers) (180 000) (185 000) (190 000) (195 000) (200 000)
Change engine oil and engine oil filter, if not re-
placed at three months. XXXXX
Rotate tires. XXX
Inspect the brake linings. X
Adjust parking brake on vehicles equipped with
four-wheel disc brakes. X
Replace the engine air cleaner filter.* X
Inspect the tie rod ends and boot seals. X
Replace the make-up air filter.* X
Replace the generator belt. X
Replace the power steering/air conditioning belt. X
Change automatic transmission fluid and filter.\b X
Flush and replace the engine coolant at
120 months, if not replaced at 102,000 miles
(200 000 km). X
Replace the spark plugs and ignition cables. X
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S330 MAINTENANCE SCHEDULES

Miles108,000 114,000 120,000 126,000 132,000 138,000
(Kilometers) (180 000) (190 000) (200 000) (210 000) (220 000) (230 000)
[Months] [108] [114] [120] [126] [132] [138]
Change engine oil and engine oil filter. X X XXXX
Rotate tires. X X XXXX
Adjust parking brake on vehicles equipped
with four-wheel disc brakes. X
Replace the air cleaner filter.* X
Replace the generator belt. X
Replace power steering/air conditioning belt. X
Flush and replace the engine coolant at
120 months, if not done at 102,000 miles
(200 000 kg). X
Replace the spark plugs and ignition cables. X
Replace the make-up air filter.* X
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S336 MAINTENANCE SCHEDULES

Special Additives...................... 301
Autostick ............................. 200
Back-Up Lights ......................... 315
Battery ............................... 286
Keyless Transmitter Replacement (RKE) ....... 25
Belts, Seat .............................. 75
Body Mechanism Lubrication ............... 288
B-Pillar Location ........................ 219
Brake, Parking .......................... 207
Brake System ........................ 209,298
Anti-Lock (ABS) ....................... 210
Fluid Check .......................... 298
Master Cylinder ....................... 298
Parking ............................. 207
Warning Light ........................ 150
Brakes ............................... 209
Brake/Transmission Interlock ............... 195
Break-In Recommendations, New Vehicle ........ 72Bulb Replacement
..................... 31 1,312
Bulbs, Light .......................... 77,311
Calibration, Compass ...............157,162,167
Capacities, Antifreeze (Engine Coolant) ........ 316
Capacities, Fluid ........................ 316
Caps, Filler Fuel ............................... 242
Oil (Engine) ....................... 277,284
Power Steering ........................ 206
Radiator (Coolant Pressure) ............... 295
Car Washes ............................ 303
Carbon Monoxide Warning ...............74,241
CD (Compact Disc) Player ................. 168
Cellular Phone .......................... 180
Center High Mounted Stop Light ............ 315
Chains, Tire ............................ 231
Changing A Flat Tire ..................... 262
Chart, Tire Sizing ........................ 215
10
INDEX 351

Customer Assistance..................... 341
Daytime Running Lights ................... 104
Dealer Service .......................... 280
Defroster, Rear Window ................... 135
Defroster, Windshield ................... 75,182
Delay (Intermittent) Wipers ................. 108
Diagnostic System, Onboard ................ 278
Dimmer Switch, Headlight ................. 103
Dipsticks Automatic Transaxle .................... 300
Power Steering ........................ 206
Disposal Antifreeze (Engine Coolant) ............... 296
Engine Oil ........................... 284
Door Locks ............................. 26
Door Locks, Automatic .................... 28
Door Opener, Garage ..................... 115 Driving
On Slippery Surfaces ................... 202
Through Flowing, Rising, or Shallow
Standing Water ........................ 203
Electric Remote Mirrors .................... 83
Electrical Power Outlets ................... 123
Electronic Speed Control (Cruise Control) ....... 112
Electronic Vehicle Information Center
(EVIC) ............................. 154,159
Emergency, In Case of Jacking ............................. 262
Jump Starting ......................... 268
Towing ............................. 273
Emergency Seat Back Release (Sedan) .......... 98
Emission Control System Maintenance ......278,320
Engine ............................... 277
Break-In Recommendations ................ 72
Checking Oil Level ..................... 281
10
INDEX 353

Coolant (Antifreeze).................... 292
Cooling ............................. 292
Exhaust Gas Caution .................. 74,241
Fuel Requirements ..................... 237
Jump Starting ......................... 268
Oil ........................... 281,316,317
Oil Change Interval .................... 282
Oil Filler Cap ...................... 277,284
Oil Filter ............................ 317
Oil Selection .......................... 283
Oil Synthetic ......................... 284
Overheating .......................... 260
Temperature Gauge .................... 143
Ethanol ............................... 238
Exhaust Gas Caution ..............34,74,241,290
Exhaust System ....................... 74,290
Exterior Lights .......................... 77 Filler Location Fuel
.................... 143,242
Filters Air Cleaner .......................... 285
Automatic Transaxle .................... 301
Engine Oil ........................ 284,317
Flashers .............................. 260
Hazard Warning ....................... 260
Turn Signal ........................ 77,149
Flooded Engine Starting ................... 193
Fluid Capacities ......................... 316
Fluid Leaks ............................. 77
Fluid Level Checks Automatic Transaxle .................... 300
Brake .............................. 298
Cooling System ....................... 292
Power Steering ........................ 206
Fluids ................................ 317
Fluids, Lubricants and Genuine Parts .......... 317
Fog Light Service ........................ 314
354 INDEX

Malfunction Indicator (Check Engine)........ 148
Map Reading ......................... 105
Oil Pressure .......................... 153
Passing ............................. 103
Rear Servicing ........................ 314
Seat Belt Reminder ..................... 151
Security Alarm (Theft Alarm) ............18,152
Service ............................. 312
Service Engine Soon (Malfunction Indicator) . . . 148
Theft Alarm (Security Alarm) .............. 152
Tire Pressure Monitoring (TPMS) ........144,232
Traction Control ....................... 213
Turn Signal ...................... 77,104,313
Voltage ............................. 149
Warning (Instrument Cluster Description) ..... 143
Loading Vehicle ...................... 244,245
Capacities ........................... 245
Tires ............................... 219 Locks
Child Protection ........................ 30
Door ................................ 26
Power Door ........................... 28
Steering Wheel ......................... 14
Low Tire Pressure System .................. 232
Lubrication, Body ....................... 288
Lumbar Support ......................... 88
Maintenance Free Battery .................. 286
Maintenance, General ..................... 281
Maintenance Procedures ................... 281
Maintenance Schedule Schedule “A”-Non Turbo ................ 333
Schedule “B” ......................... 322
Schedule “B”-All Engines ................ 322
Maintenance Schedules .................... 320
Malfunction Indicator Light (Check Engine) . . 148,278
Manual, Service ......................... 345
358 INDEX