2009 SATURN OUTLOOK change wheel

Some driving conditions or climates
can cause a brake squeal when
the brakes are rst applied or lightly
applied. This does not mean
something is wrong with the brakes.
Properly torqued wheel nuts are
necessary to help prevent
brake pulsation. When tires are
rotated, inspect brake pads for wear
and evenly tighten wheel nuts in
the proper sequence to torque
specications inCapacities and
Specifications on page 5-98.
Brake linings should always be
replaced as complete axle sets.
Brake Pedal Travel
See your dealer/retailer if the brake
pedal does not return to normal
height, or if there is a rapid increase
in pedal travel. This could be a
sign that brake service might
be required.
Brake Adjustment
Every time the brakes are applied,
with or without the vehicle moving,
the brakes adjust for wear.
Replacing Brake System Parts
The braking system on a vehicle
is complex. Its many parts have to
be of top quality and work well
together if the vehicle is to have
really good braking. The vehicle was
designed and tested with top-quality
brake parts. When parts of the
braking system are replaced — for
example, when the brake linings
wear down and new ones are
installed — be sure to get new
approved replacement parts. If this
is not done, the brakes might
not work properly. For example, if
someone puts in brake linings
that are wrong for the vehicle, the
balance between the front and
rear brakes can change — for the
worse. The braking performance
expected can change in many other
ways if the wrong replacement
brake parts are installed.
Battery
This vehicle has a maintenance free
battery. When it is time for a new
battery, see your dealer/retailer
for one that has the replacement
number shown on the original
battery’s label.
For battery replacement, see your
dealer/retailer or the service manual.
To purchase a service manual,
seeService Publications Ordering
Information on page 7-15.
Warning:Battery posts, terminals,
and related accessories contain
lead and lead compounds,
chemicals known to the State of
California to cause cancer and
reproductive harm. Wash hands
after handling.
Service and Appearance Care 5-29
ProCarManuals.com

Federal Communications
Commission (FCC) and
Industry and Science Canada
The Tire Pressure Monitor System
(TPMS) operates on a radio
frequency and complies with Part 15
of the FCC Rules. Operation is
subject to the following two
conditions:
1. This device may not cause
harmful interference.
2. This device must accept any
interference received, including
interference that may cause
undesired operation.Vehicles with TPMS operate on a
radio frequency and comply with
RSS-210 of Industry and Science
Canada. Operation is subject to the
following two conditions:
1. This device may not cause
interference.
2. This device must accept any
interference received, including
interference that may cause
undesired operation of the device.
Changes or modications to
this system by other than an
authorized service facility could
void authorization to use this
equipment.
Tire Pressure Monitor
Operation
This vehicle may have a Tire
Pressure Monitor System (TPMS).
The TPMS is designed to warn the
driver when a low tire pressure
condition exists. TPMS sensors are
mounted onto each tire and wheel
assembly, excluding the spare tire
and wheel assembly, if the vehicle
has one. The TPMS sensors monitor
the air pressure in the vehicle’s tires
and transmits the tire pressure
readings to a receiver located in the
vehicle.
5-48 Service and Appearance Care
ProCarManuals.com

After the tires have been rotated,
adjust the front and rear ination
pressures as shown on the Tire
and Loading Information label.
SeeInflation - Tire Pressure on
page 5-45andLoading the
Vehicle on page 4-18.
Reset the Tire Pressure Monitor
System. SeeTire Pressure
Monitor Operation on page 5-48.
Make certain that all wheel
nuts are properly tightened.
See “Wheel Nut Torque” under
Capacities and Specifications
on page 5-98.{CAUTION
Rust or dirt on a wheel, or on
the parts to which it is fastened,
can make wheel nuts become
loose after time. The wheel
could come off and cause an
accident. When you change a
wheel, remove any rust or
dirt from places where the
wheel attaches to the vehicle.
(Continued)
CAUTION (Continued)
In an emergency, you can use
a cloth or a paper towel to do
this; but be sure to use a
scraper or wire brush later, if
needed, to get all the rust or
dirt off. SeeChanging a Flat
Tire on page 5-70.
Make sure the spare tire, if the
vehicle has one, is stored
securely. Push, pull, and then
try to rotate or turn the tire.
If it moves, tighten the cable.
SeeStoring a Flat or Spare
Tire and Tools on page 5-80.
Service and Appearance Care 5-53
ProCarManuals.com

Tire Sealant and
Compressor Kit Storage
The tire sealant and compressor
kit is located in the storage
compartment on the driver side,
at the rear of the vehicle.
1. Press down on the latch tab and
pull the cover off to access the
storage compartment.2. Press the two tabs on the quick
release buckle to release the tire
sealant and compressor kit strap.
3. Remove the sealant and
compressor kit from its tray.
To store the tire sealant and
compressor kit, reverse the steps.
Changing a Flat Tire
If a tire goes at, avoid further tire
and wheel damage by driving slowly
to a level place. Turn on the hazard
warning ashers. SeeHazard
Warning Flashers on page 3-5.
{CAUTION
Changing a tire can be
dangerous. The vehicle can slip
off the jack and roll over or fall on
you or other people. You and they
could be badly injured or even
killed. Find a level place to
change your tire. To help prevent
the vehicle from moving:
1. Set the parking brake rmly.
2. Put the shift lever in
P (Park).
3. Turn off the engine and do
not restart while the vehicle
is raised.
4. Do not allow passengers to
remain in the vehicle.
To be even more certain the
vehicle will not move, you should
put blocks at the front and rear of
the tire farthest away from the
one being changed. That would
be the tire, on the other side, at
the opposite end of the vehicle.
5-70 Service and Appearance Care
ProCarManuals.com

When the vehicle has a at tire (B),
use the following example as a
guide to assist you in the placement
of wheel blocks (A).
A. Wheel Block
B. Flat Tire
The following information explains
how to use the jack and change
a tire.Removing the Spare Tire
and Tools
The tools needed to remove the
spare tire are located in the storage
compartment on the driver side,
at the rear of the vehicle.
1. Open the jack storage
compartment by pulling on the
latch tab, located toward the rear
of the vehicle, and pulling the
cover off.
A. Tool Bag
B. Wing Bolt
C. Jack2. Remove the wing bolt (B) by
turning it counterclockwise
3. Push the jack (C) up out of the
holding bracket.
4. Turn the jack on its side, with the
bottom facing toward you.
5. Pull the jack straight out, bottom
rst.
The tools you will be using include
the jack (A) and lug wrench (B).
Service and Appearance Care 5-71
ProCarManuals.com

Additional Required Services
The following services should be performed at the rst maintenance service (Ior II) after the indicated miles
(kilometers) shown for each item.
Additional Required Services
Service and Miles (Kilometers) 25,000
(40 000) 50,000
(80 000) 75,000
(120 000) 100,000
(160 000) 125,000
(200 000) 150,000
(240 000)
Inspect fuel system for damage or
leaks. • •••••
Inspect exhaust system for loose or
damaged components. • •••••
Replace engine air cleaner lter. See
Engine Air Cleaner/Filter on page 5-17 .•••
Change automatic transmission uid
(severe service). See footnote (h). •••
Change automatic transmission uid
(normal service). •
All-wheel-drive vehicles: Change
transfer case uid (severe service).
See footnote (m). •••
All-wheel-drive vehicles: Change
transfer case uid (normal service). •
6-6 Maintenance Schedule
ProCarManuals.com

Seats
Driver Seat Height Adjuster . . . 1-3
Head Restraints................. 1-2
Heated Seats..................... 1-5
Manual Lumbar.................. 1-4
Memory, Mirrors................. 1-6
Power Lumbar ................... 1-5
Power Seats...................... 1-4
Rear Seat Operation........... 1-9
Reclining Seatbacks............ 1-8
Third Row Seat................1-12
Second Row Center
Console..........................2-50
Secondary Latch System.......5-78
Securing a Child Restraint
Rear Seat Position.............1-43
Right Front Seat Position....1-45
Security Light......................3-43
Service................................ 5-3
Accessories and
Modications.................. 5-3
Adding Equipment to the
Outside of the Vehicle..... 5-5
Doing Your Own Work........ 5-4
Engine Soon Lamp...........3-39
Publications Ordering
Information...................7-15
Scheduling Appointments..... 7-9Service Parts Identication
Label..............................5-91
Servicing Your
Airbag-Equipped Vehicle.....1-60
Setting the Clock.................3-74
Sheet Metal Damage............5-90
Shifting
Out of Park.....................2-29
Shifting Into Park.................2-28
Signals, Turn and
Lane-Change..................... 3-6
Spare Tire
Compact.........................5-83
Installing..........................5-74
Removing........................5-71
Storing............................5-80
Specications and
Capacities.......................5-98
Speedometer.......................3-32
StabiliTrak
®Indicator Light.....3-37
StabiliTrak®System............... 4-5
Start Vehicle, Remote............. 2-6
Starting the Engine..............2-22
Steering............................... 4-8
Steering Wheel Controls,
Audio............................3-125
Steering Wheel, Tilt and
Telescopic......................... 3-6Storage Areas
Cargo Management
System........................2-53
Center Console................2-50
Convenience Net..............2-52
Cupholders......................2-50
Glove Box.......................2-50
Instrument Panel..............2-50
Luggage Carrier...............2-52
Rear Seat Armrest............2-52
Second Row Center
Console.......................2-50
Storing the Tire Sealant and
Compressor Kit................5-70
Stuck in Sand, Mud, Ice,
or Snow..........................4-17
Sun Visors..........................2-16
Sunroof..............................2-54T
Tachometer.........................3-32
Taillamps
Turn Signal, Stoplamps and
Sidemarker Lamps.........5-36
Telescopic Wheel................... 3-6
Text Telephone (TTY) Users..... 7-5
i-10 INDEX
ProCarManuals.com

Theft-Deterrent Feature.......3-125
Theft-Deterrent Systems........2-16
Content Theft-Deterrent.....2-16
PASS-Key
®III+ Electronic
Immobilizer...................2-18
PASS-Key
®III+ Electronic
Immobilizer Operation.....2-18
Third-Row Seats..................1-12
Tilt Wheel............................. 3-6
Time, Setting.......................3-74
Tire
Pressure Light..................3-39
Tire Sealant and
Compressor Kit................5-70
Tires..................................5-39
Aluminum or
Chrome-Plated Wheels,
Cleaning......................5-89
Buying New Tires.............5-54
Chains............................5-60
Changing a Flat Tire.........5-70
Cleaning..........................5-90
Compact Spare................5-83
Different Size...................5-56
If a Tire Goes Flat............5-61
Ination - Tire Pressure.....5-45Tires (cont.)
Inspection and Rotation.....5-52
Installing the Spare Tire.....5-74
Pressure Monitor
Operation.....................5-48
Pressure Monitor System....5-46
Removing the Flat Tire......5-74
Removing the Spare Tire
and Tools.....................5-71
Sealant and
Compressor Kit.............5-62
Secondary Latch System....5-78
Sidewall Labeling..............5-40
Storing a Flat or Spare Tire
and Tools.....................5-80
Terminology and
Denitions....................5-42
Uniform Tire Quality
Grading.......................5-57
Wheel Alignment and
Tire Balance.................5-58
Wheel Replacement..........5-59
When It Is Time for
New Tires....................5-54
Tow/Haul Mode ....................2-26
Tow/Haul Mode Light............3-43Towing
Recreational Vehicle..........4-22
Towing a Trailer................4-26
Your Vehicle.....................4-22
Traction
StabiliTrak
®System............ 4-5
Transmission
Fluid, Automatic................5-18
Transmission Operation,
Automatic........................2-24
Transportation, Courtesy......... 7-9
Turn and Lane-Change
Signals............................. 3-6
Turn Signal/Multifunction
Lever................................ 3-6
U
Ultrasonic Rear Parking
Assist (URPA)..................2-34
Uniform Tire Quality
Grading...........................5-57
Universal Home Remote
System...........................2-45
Operation........................2-46
INDEX i-11
ProCarManuals.com