2009 SATURN ASTRA cooling

Scheduled Maintenance (cont’d)
ServiceMaintenanceIMaintenance II
Inspect brake system. See footnote (c). ••
Check engine coolant and windshield washer uid levels and add uid as
needed. ••
Perform any needed additional services. See Additional Required Services
on page 11-6. ••
Inspect suspension and steering components. See footnote (d). •
Inspect engine cooling system. See footnote (e). •
Inspect wiper blades. See footnote (f). •
Inspect restraint system components. See footnote (g). •
Lubricate body components. See footnote (h). •
Service and Maintenance 11-5
ProCarManuals.com

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(40 000) 50,000
(80 000) 75,000
(120 000) 100,000
(160 000) 125,000
(200 000) 150,000
(240 000)
Engine cooling system service (or every
ve years, whichever occurs rst).
An Emission Control Service.
See footnote (j). •
Solid lifter tappet adjustment (or every
10 years, whichever occurs rst).
See footnote (m).
Not to exceed 90,000 miles (144 000 km). ••
Replace timing belt and tensioner
(or every 10 years, whichever
occurs rst). See footnote (m).
Not to exceed 100,000 miles (160 000 km). ••
Inspect engine accessory drive belt
(or every two years, whichever occurs
rst). An Emission Control Service.
See footnote (k).
Not to exceed 36,000 miles (58 000 km). ••• • • •
Change brake and clutch hydraulic uid at
a regular maintenance service every
two years. See footnote (l).
Service and Maintenance 11-7
ProCarManuals.com

Maintenance Footnotes
(a)A fluid loss in any vehicle system
could indicate a problem. Have the
system inspected and repaired
and the fluid level checked. Add fluid
if needed.
(b)If driving regularly under dusty
conditions or in high-polluted
regions, replace the filter at each
engine oil change.
(c)Inspect brake lines and hoses for
proper hook-up, binding, leaks,
cracks, chafing, etc. Inspect disc
brake pads for wear and rotors for
surface condition. Inspect other
brake parts, including calipers,
parking brake, etc.
(d)Inspect front and rear suspension
and steering system for damaged,
loose, or missing parts or signs of
wear. Inspect power steering cables
for proper hook-up, binding, cracks,
chafing, etc. Inspect power steering
hydraulic lines and hoses for proper
hook-up, binding, leaks, cracks,
chafing, etc.(e)Inspect hoses and have them
replaced if they are cracked,
swollen, or deteriorated. Inspect all
pipes, fittings and clamps; replace
with genuine parts as needed.
To help ensure proper operation,
a pressure test of the cooling system
and pressure cap and cleaning
the outside of the radiator and
air conditioning condenser is
recommended at least once a year.
(f)Inspect wiper blades for wear,
cracking, or contamination.
Clean the windshield and wiper
blades, if contaminated. Replace
wiper blades that are worn or
damaged. See Windshield Wiper
Blade Replacement on page 9-21
and “Windshield and Wiper Blades”
in Exterior Cleaning on page 9-76.
(g)Make sure the safety belt
reminder light and safety belt
assemblies are working properly.
Look for any other loose or
damaged safety belt system parts.
If you see anything that might keep
a safety belt system from doingits job, have it repaired. Have any
torn or frayed safety belts replaced.
Also see Airbag System Check
on page 1-37.
(h)Lubricate all key lock cylinders,
door hinges and latches, hood
hinges and latches, and trunk lid
hinges and latches. More frequent
lubrication may be required
when exposed to a corrosive
environment. Applying silicone
grease on weatherstrips with a clean
cloth will make them last longer,
seal better, and not stick or squeak.
(i)Change automatic transmission
fluid if the vehicle is mainly driven
under one or more of these
conditions:
In heavy city traffic where the
outside temperature regularly
reaches 90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer
towing.
Uses such as found in taxi, police,
or delivery service.
11-8 Service and Maintenance
ProCarManuals.com

(j)Drain, flush, and refill cooling
system. This service can be
complex; you should have your
dealer/retailer perform this service.
See Engine Coolant on page 9-16
for what to use. Inspect hoses.
Clean radiator, condenser, pressure
cap, and filler neck. Pressure test the
cooling system and pressure cap.
(k)Inspect belt for fraying, excessive
cracks, or obvious damage. Replace
belt if necessary.
(l)Drain, flush, and refill brake/clutch
hydraulic system at a regular service
interval (IorII) every two years.
This service can be complex; you
should have your dealer/retailer
perform this service. See Brakes
on page 9-22.
(m)This service can be complex;
you should have your dealer/retailer
perform this service.Owner Checks and
Services
These owner checks and services
should be performed at the intervals
specied to help ensure vehicle
safety, dependability, and
emission control performance.
Your dealer/retailer can assist with
these checks and services.
Be sure any necessary repairs are
completed at once. Whenever any
uids or lubricants are added to
the vehicle, make sure they are
the proper ones, as shown in
Recommended Fluids and
Lubricants on page 11-12.
At Each Fuel Fill
It is important to perform these
underhood checks at each fuel fill.
Engine Oil Level Check
Notice:It is important to check
the engine oil regularly and
keep it at the proper level.
Failure to keep the engine oil
at the proper level can cause
damage to the engine not covered
by the vehicle warranty.
Check the engine oil level and
add the proper oil if necessary.
SeeEngine Oil on page 9-7.
Engine Coolant Level Check
Check the engine coolant level
and add DEX-COOL®coolant
mixture if necessary. SeeEngine
Coolant on page 9-16.
Windshield Washer Fluid
Level Check
Check the windshield washer uid
level in the windshield washer
uid reservoir and add the proper
uid if necessary.
Service and Maintenance 11-9
ProCarManuals.com

Bulb Replacement (cont.)
Halogen Bulbs..................9-28
Headlamp Aiming..............9-26
Headlamps......................9-28
License Plate Lamps.........9-33
Replacement Bulbs...........9-34
Taillamps.................9-30, 9-32
Buying New Tires.................9-54
C
California Fuel.....................8-34
California Perchlorate
Materials Requirements....... 9-3
California Proposition 65
Warning............................ 9-3
Canadian Owners..................... ii
Capacities and
Specications...................10-2
Carbon Monoxide.........8-14, 8-27
Care, Safety Belts................1-23
Cargo Cover......................... 3-2
Cargo Tie Downs................... 3-2
Cautions and Notices............... iii
Center High-Mounted
Stoplamp (CHMSL)...........9-29Chains, Tire........................9-60
Charging System Light..........4-16
Check
Engine Lamp...................4-18
Chemical Paint Spotting........9-80
Child Restraints
Child Restraint Systems.....1-43
Infants and Young
Children.......................1-40
Lower Anchors and
Tethers for Children.......1-46
Older Children..................1-38
Securing..................1-51, 1-53
Where to Put the
Restraint......................1-44
Cleaning
Exterior...........................9-76
Interior............................9-73
Underbody Maintenance....9-80
Climate Control System.......... 7-1
Outlet Adjustment............... 7-4
Clutch, Hydraulic..................9-12
Collision Damage Repair.....12-10
Compact Spare Tire.............9-68
Content Theft-Deterrent.......... 2-9
Control of a Vehicle..............8-17Coolant
Engine............................9-16
Engine Temperature
Warning Light...............
4-18
Cooling System...................9-12
Courtesy
Transportation..........12-5, 12-9
Cruise Control....................... 4-5
Cruise Control Light..............4-23
Cupholders........................... 3-1
Customer Information
Courtesy
Transportation.......12-5, 12-9
Customer Assistance
Offices.........................12-5
Customer Satisfaction
Procedure....................12-1
GM Mobility
Reimbursement
Program.......................12-6
Online Owner Center.........12-4
Reporting Safety Defects
to Saturn....................12-14
Reporting Safety Defects
to the Canadian
Government................12-14
i-2 INDEX
ProCarManuals.com