2009 OPEL MERIVA transmission fluid

15
In Brief
Picture no: 14175s.tif
Automated manual
transmission
3
To move the selector lever from N to R
press the button on the lever.
Only start in N with foot brake applied.
Automated manual transmission 3 3 129.
Before starting off, checkz Tyre pressure and tyre condition 3155,
3 228.
z Engine oil level and fluid levels 3209 to
3 216.
z All windows, mirrors, exterior lighting
and number plates are free from dirt,
snow and ice and operational.
z Seats, seat belts and mirrors are
correctly adjusted. 344, 359, 336.
z Check brake function at low speed,
particularly if the brakes are wet.
Picture no: 15678t.tif
Steering wheel lock and ignitionTurn key to position 1. Move the steering
wheel slightly to release the steering wheel
lock.
N
=Idle/start position
o =Driving position
+ = Higher gear
- = Lower gear
A/M = Switch between Automatic and
Manual mode
R = Reverse gear
(with selector lever lock) 0=Ignition off
1 = Steering free, ignition off
2 =Ignition on, with diesel engine: pre-
heating
3 =Starting

85
Instruments, Controls
Picture no: 18385s.tif
T
Winter mode for manual transmission
automated 3
Control indicator lights up yellow.
Control indicator lights up when winter
program is enabled 3132. m

Cruise control 3
Control indicator lights up green
This comes on when the system is switched
on 3148.
r
Fog tail lamp
Control indicator lights up yellow.
This comes on when the fog tail lamp is
switched on 3104.
Picture no:
p

Alternator
Control indicator lights up red.
It illuminates when the ignition is switched
on and goes out shortly after the engine
starts.
Illuminates when the engine is running
Stop, switch off engine. Battery is not
charging. Contact a workshop
immediately. R

Brake system, clutch system
Control indicator lights up or flashes red.
Illuminated
Illuminates when the ignition is switched on
if the hand brake is applied 3151.
Lights up when the hand brake is released
when the fluid level for the brake or clutch
systems is low 3214.
FlashesOn vehicles with manual transmission
automated 3, control indicator R flashes
for a few seconds after the ignition is
switched off when the hand brake has not
been applied. u

Anti-lock brake system
Control indicator lights up red.
Illuminates while driving
Fault in anti-lock braking system 3152. S

Engine oil level 3
Control indicator lights up yellow.
The engine oil level is checked
automatically 3.
Illuminates when the engine is running

Engine oil level too lo w. Check engine oil
level and top up engine oil if necessary
3 210.
9 Warning
Stop. Do not continue your journey.
Consult a workshop.

202 Service and maintenance⊕additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20 000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary xx
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
⊕
Germany only: carry out emissions check, main inspection
First time after three years, then every 2 years
If used commercially to tran sport passengers, taxis, ambulances, hire cars etc annually

205
Service and maintenance
⊕ additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x 1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20 000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary xx
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx

227
Technical Data
Table 1, kerb weight
1)
1)According to EC Directive 70/156/EC, including assumed weights for driver (68 kg), luggage (7 kg) and all fluids (tank 90 % ful l). MerivaEngineManual
transmission Manual transmission
automated
without/with air
conditioning [kg] Z 14 XEP
1330/1355 –/–
Z 16 XEP 1375/1400 1375/1400
Z 18 XE 1380/1405 1380/1405
Z 16 LET 1450/1475 –/–
Z 13 DTJ 1415/1440 –/–
Z 17 DT, Z 17 DTR 1460/1485 –/–
Z 17 DTH 1455/1480 –/–Table 2, weight of heavy accessories Accessories Towing equipment
Weight [kg] 25

237
Index
KKeyextending .............................................. 26
ignition lock ..................................... 16, 27
Locking doors............................28, 30, 36
Starting .................................................. 27
Starting the engine ............................... 16
Keys ........................................................... 26LLanguage selection .................................. 95
Lashing eyes ............................................. 57
Leather trim ............................................ 197
Light switch ............................................... 11
Lighting ............................................. 11, 102 Driving abroad .................................... 110
Loading .....................................58, 162, 226
Loading the vehicle .................................. 58
Locking doors ...........................2, 28, 30, 36
Locking from the inside ............................ 30
Lubricants ............................................... 210
Luggage compartment Bulb replacement................................ 195
Cover...................................................... 55
Extension ......................................... 32, 53
Lighting ............................................... 109
Loading .................................58, 162, 226
Luggage compartment cover ................. 55
Lumbar support ........................................ 45
MMain beam ................................................ 11 Bulb replacement ....................... 187, 188
Control indicator ................................... 84
Maintenance Air conditioning system...................... 128
Antifreeze protection ......................... 212
Brake fluid ........................................... 214
Brakes .................................................. 213
Catalytic converter ............................. 145
Engine oil ............................................. 210
Fuel consumption ............................... 138
Tyre pressure............................... 154, 228
Tyres .................................................... 155
Manual transmission ........................ 14, 134
Mirrors ................................................... 4, 38
Misted windows ......................118, 121, 124
Mobile telephone.................................... 113
Muffler, see Exhaust system .................. 144NNumber plate lamps Bulb replacement ............................... 193
Number plate lighting............................ 193
Number plates ........................................ 217OOctane numbers ............................. 220, 221
Odometer .................................................. 87
Oil ............................................................ 207 Additives ............................................. 207
Top up ................................................. 207
Viscosity............................................... 207 Oil consumption ..................... 210, 220, 221
Oil level.................................................... 210
Oil pressure ............................................... 84
Opel Service ............................................ 199
Operating temperature ......................... 136
Outside temperature gauge ................... 91
Overrun ........................................... 136, 138
PPaintwork damage................................. 197
Park pilot ................................................. 150
Parking lamps........................................... 11
Bulb replacement ............................... 189
Pedals...................................................... 136
Performance ........................................... 222
Pollen filter .............................................. 127
Power assisted steering, see electronic power steering ................ 86
Power steering, see electronic power steering ........................................ 86
Preheating ................................................ 86
Pushing, towing .............................. 142, 166QQuickheat ............................................... 127RRadio ................................................. 24, 111
Radio equipment (CB) ........................... 113
Radio reception ...................................... 111
Radio remote control ............................... 28
Reading lamps ....................................... 109
Rear lamp cluster ................................... 102 Bulb replacement ............................... 191