2009 OPEL MERIVA coolant level

88 Instruments, Controls
Picture no: 17906s.tif
Coolant temperature display
Coolant temperature display For physical reasons, the engine
temperature gauge shows the coolant
temperature only if the coolant level is
adequate.
During operation the system is pressurised.
The temperature may therefore rise briefly
to over 100 C.
Picture no: 17907s.tif
Fuel gauge
Fuel tank level display.
If the fuel level is too low, a warning lamp
lights up
Y. When the light flashes, refuel as
soon as possible.
Never run the tank dry!
Because of the fuel remaining in the tank,
the amount of fuel required to fill the
tank may be less than the specified tank
capacity.
Pointer in zone at
left
= Engine operating
temperature not yet
reached.
Pointer between
the zones = Normal operating
temperature.
Pointer in zone at
right (warning
zone) = Temperature too
high: Stop vehicle
and switch off
engine. Danger to
engine. Check
coolant level
immediately 3 213.

200 Service and maintenanceService schedule Europe⊕additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
Carry out a visual check of all warning lamps, lighting and signalling devices,
check steering and ignition locks xxxxx
Remote control: replace batteries (check spare key) every 2 years
Check windscreen wipers, windscreen washer and headlamp washer systems, adjust if
necessary. xxxxx
Check coolant and antifreeze (bright orange) levels
2), adjust if necessary, note
antifreeze temperature in Service and Warranty Booklet (validation fields).
2)If the loss is too great or there are leaks, carry out remedial work in agr eement with the customer.
xxxxx
Check water-carrying hoses for leaks and make sure that they are secure. xxxxx
Check break fluid level
2), top up if necessary. xxx
Check that the battery terminals and lugs are secure xxxxx
Vehicle system check using TECH 2 xxxxx
Replace pollen filter or active charcoal filter xx
⊕o
If the air is particularly polluted, full of du st or sand or pollen, if the air conditioning
system smells Discussion between customer / Opel Partner
Replace air cleaner element every 4 years/60 000 km
⊕
Replace spark plugsevery 4 years/60 000 km
Make a visual check of the ribbed belt xx
⊕
Replace ribbed belt
Z 13 DT, Z 13 DTJ, Z 17 DTH, Z 17 DT, Z 17 DTR. every 10 years/150 000 km
⊕
Check valve clearance,
adjust if necessary
Z 16 LET, Z 16 XEP, Z 17 DTH, Z 17 DT, Z 17 DTR every 10 years/150 000 km

203
Service and maintenance
International service schedule⊕ additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x 1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
Carry out a visual check of all warning lamps, lighting and signalling devices,
check steering and ignition locks xxxxx
Remote control: replace batteries (check spare key) every 2 years
Check windscreen wipers, windscreen washer and headlamp washer systems, adjust if
necessary. xxxxx
Check coolant and antifreeze (bright orange) levels
2), adjust if necessary, note
antifreeze temperature in Service and Warranty Booklet (validation fields).
2)If the loss is too great or there are leaks, carry out remedial work in agr eement with the customer.
xxxxx
Check water-carrying hoses for leaks and make sure that they are secure. xxxxx
Check break fluid level
2), top up if necessary. xxx
Check that the battery terminals and lugs are secure xxxxx
Vehicle system check using TECH 2 xxxxx
Replace pollen filter or active charcoal filter xx
⊕o
If the air is particularly polluted, full of du st or sand or pollen, if the air conditioning
system smells Discussion between customer / Opel Partner
Replace air cleaner element every 4 years/60 000 km
⊕
Replace spark plugsevery 4 years/60 000 km
Make a visual check of the ribbed belt xx
⊕
Replace ribbed belt
Z 13 DT, Z 13 DTJ, Z 17 DTH, Z 17 DT, Z 17 DTR. every 10 years/150 000 km
⊕
Check valve clearance,
adjust if necessary
Z16 LET, Z 16 XEP, Z 17 DTH, Z 17 DT, Z 17 DTR every 10 years/150 000 km

209
Service and maintenance
Genuine Opel Parts and
Accessories We recommend that you use "Genuine
Opel Parts and Accessories" and
conversion parts released expressly for
your vehicle type. These parts have
undergone special tests to establish their
reliability, safety and specific suitability for
Opel vehicles. Despit e continuous market
monitoring, we cannot assess or guarantee
these attributes for other products, even if
they have been granted approval by the
relevant authorities or in some other form.
"Genuine Opel Parts and Accessories" and
conversion parts approved by Opel can be
obtained from your Op el Partner, who can
provide expert advice on permitted
technical changes and ensure correct
installation.
Picture no: 17922S.tif
Performing work To avoid injury from moving parts and
cables conducting ignition voltage, only
carry out engine compartment checks
(e. g. checking brake fluid or engine oil
level) when the igniti on is switched off.
Picture no: 14234s.tif
To aid identification, the caps to be
removed for topping up engine oil, coolant
and washer fluid and the dipstick handle
may be coloured yellow.
9 Warning
Only perform engine compartment
checks when the ignition is off.
The cooling fan may start operating
even if the ignition is off.
9 Warning
The ignition system 3 and Xenon
headlamps 3 use extremely high
voltage. Do not touch.

213
Service and maintenance
Picture no: 17904s.tif
Coolant level
In a closed cooling system, there is hardly
any loss.
If the cooling system is cold, the coolant
should lie above the KALT/COLD mark.
Top up if the level is low. Top up with anti-freeze. If no anti-freeze is
available, fill with clean tap water or
distilled water. Have the anti-freeze
concentration checked.
Have the cause of coolant loss rectified by
a workshop.
Fit the cap on straight and tighten it.
Brakes A screeching noise indicates that the brake
lining is at its minimum thickness.
Continued driving is possible. Have the
brake lining replace as soon as possible.
Once new brake lining is fitted, do not
brake unnecessarily hard for the
first 200 km.
9 Warning
Allow the engine to cool before opening
the cap. Carefully open the cap,
relieving the overpressure slowly.
Caution
Too low a coolant level can cause
engine damage.

217
Service and maintenance
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage.
zWash and wax the vehicle 3196.
z Have the wax in the engine
compartment and underbody checked.
z Clean and preserve rubber seals.
z Change engine oil.
z Check antifreeze and corrosion
protection 3 212.
z Check coolant level, add antifreeze if
necessary 3213.
z Empty windscreen washer system and
headlamp washer system.
z Increase tyre pressure to value given for
full load 3228. z
Park vehicle in dry and well ventilated
place. Select first gear or reverse gear,
and with manual transmission
automated 3 move selector lever to
middle position before switching ignition
off. Use wedges or something similar to
prevent vehicle from rolling.
z Do not apply hand brake.
z Disconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
z Check tyre pressure 3228.
z Top up windscreen washer system 3215.
z Check engine oil level 3210.
z Check coolant level 3213.
z Fit the number plate if necessary.

235
Index
Centre console lighting .................. 108, 109
Changing the remote control battery ..... 29
Changing wheels .................................... 174
Chassis number, see Vehicle identification number ........................... 219
Child restraint system ............................... 65
Child safety locks ................................ 36, 40
Cigarette lighter........................................ 78
Climate control system ........................... 122
Clutch operation ............................. 134, 136
CO2 emissions......................................... 224
Coin holder ................................................ 81
Cold start ................................................. 136
Colour information display ...................... 92
Contrast ..................................................... 96
Control indicator ABS (Anti-lock Brake System) ............ 152
Airbag .................................................... 72
Engine electronics ............................... 143
Exhaust ................................................ 143
Immobiliser ............................................ 27
Control indicators ............................... 10, 82 Adaptive Forward Lighting
(AFL) .............................................. 82, 106
Belt tensioners ....................................... 61
Cruise control ...................................... 148
EPS (Electric Power Steering) ............... 86
ESP (Electronic Stability Program) ..... 146
Coolant ............................................ 208, 212
Coolant level ........................................... 213
Coolant temperature display .................. 88
Coolant thermometer ............................... 88
Cornering light ........................................ 106
Correcting time ......................................... 95 Coupling socket load ............................. 163
Courtesy lamp ........................................ 108
Bulb replacement ............................... 194
Cruise control .......................................... 148
Curtain airbags......................................... 71
Curve lighting ......................................... 106
DDashboard, see Instrument panel .......... 15
Data................................................... 26, 218
Date ........................................................... 92
Daytime running lights........................... 102
Decommissioning ................................... 217
Demisting and defrosting Windows .............................................. 118
with climate control system ............... 124
With the air conditioning system....... 121
Diesel fuel filter ....................................... 212
Diesel fuel system ........................... 165, 212
Diesel particle filter.............41, 86, 136, 144
Dimensions .............................................. 231
Dipped beam ............................................ 11 Bulb replacement ....................... 186, 188
Display....................................................... 90
Display mode ............................................ 96
Door locks ......................................... 26, 198
Driving abroad ....................................... 199 Headlamps.......................................... 110
Toll systems ......................................... 112
Driving hints ............................................ 135
EEasytronic ......................................... 15, 129 Driving programmes .......................... 131
Fault .................................................... 133
Interruption of power supply ............. 134
Kickdown............................................. 132
Selector lever................................. 15, 130
Winter programme ............................. 132
Economical driving ................................. 137
Electric power steering ............................. 86
Electric windows ....................................... 40
Electrical system ............................. 181, 216
Electronic components........................... 216
Electronic immobiliser .............................. 27
Electronic Stability Program .................. 146
Engine code .................................... 220, 221
Engine control indicator ........................ 143
Engine oil ........................................ 207, 210 Additives ............................................. 207
Top up ................................................. 207
Viscosity .............................................. 207
Engine oil consumption ... 135, 210, 220, 221
Engine oil level ........................................ 210
Engine oil pressure ................................... 84
Engine speed .......................................... 136
Engine wash............................................ 198
Environmental protection ...................... 196
EPS ............................................................. 86
ESP (Electronic Stability Program) ........ 146
Exhaust control indicator ...................... 143
Exhaust gases......................................... 144
Exhaust system ....................................... 135