2009 OPEL MERIVA wheel

205
Service and maintenance
⊕ additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x 1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20 000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary xx
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx

228 Technical DataTyres Restrictions
Not all tyres available on the market
currently meet the structural requirements.
We recommend that you consult an Opel
Partner concerning suitable tyre makes.
These tyres have undergone special tests
to establish their reliability, safety and
specific suitability for Opel vehicles.
Despite continuous market monitoring, we
are unable to assess these attributes for
other tyres, even if they have been granted
approval by the relevant authorities or in
some other form.
Further information 3153. Winter tyres
3
Tyres of size 205/50 R 16 are not suitable
for use as winter tyres except on vehicles
with the Z 16 LET engine.
Tyres of size 205/45 R 17 are not suitable
for use as winter tyres. If winter tyres are in use, the spare wheel
may still be fitted with a summer tyre. Use
of the spare wheel may alter vehicle
handling. Obtain a replacement for the
faulty tyre as soon as possible, and have
the wheel balanced and fitted to the
vehicle.
Further information 3
157.
Tyre chains
3
Tyre chains may be used on the front
wheels only.
We recommend the use of tyre chains with
a fine mesh that add no more than 10 mm
to the running surface and the insides of
the tyres (including chain lock).
Tyre chains are not permitted on tyre
sizes 205/50 R 16 and 205/45 R 17.
Further information 3157. Wheels Wheel bolt tightening torque: 110 Nm.
Spare wheel
3
Depending on model, the spare wheel is
designed as a temporary spare wheel 3.
When using the spare wheel, the driving
behaviour may be modified. Replace the
faulty tyre as soon as possible, balance the
wheel and refit to vehicle. Follow the notes
on this page and 3157, 3173.
On vehicles with alloy wheels 3 the spare
wheel may have a steel rim.
The spare wheel can be fitted with a
smaller tyre
1)and a smaller rim than the
wheels fitted on the vehicle.
Tyre pressure (overpressure) The specified tyre pressures are valid for
cold tyres. The increased tyre pressure
resulting from extensive driving must not
be reduced. The tyre pressures specified on
the following pages apply to both summer
and winter tyres.
The spare wheel must always be inflated to
the tyre pressure for a full load – see table
on following pages.
Further information 3153 to 3157. 1)Country-specific version: The spare wheel is
only to be used as a temporary spare wheel.

231
Technical Data
Dimensions
Meriva Meriva OPC
Length [mm] 40524068
Width without exterior mirrors [mm] 16941694
Width with two exterior mirrors [mm] 19481948
Height [mm] 16241624
Length of luggage compartment
floor [mm] 861
861
Luggage compartment width [mm] 10341034
Height of luggage compartment
opening [mm] 832
832
Wheelbase [mm] 26302630
Turning circle diameter [m] 10.4210.42

234 IndexIndex
AABS (Anti-lock Brake System) ................ 152
Accessories.............................................. 171
Accessory socket ...................................... 78
Adaptive brake lamp ............................. 152
Adaptive Forward Lighting ................... 106Bulb replacement ............................... 188
Driving abroad.................................... 110
Adaptive Forward Lighting (AFL) ......... 106 Bulb replacement ............................... 188
Driving abroad.................................... 110
Air conditioning system ......................... 114
Air intake ................................................. 127
Air recirculation system.................. 119, 126
Air vents .................................................. 115
Airbags ...................................................... 67
Alarm ......................................................... 36
Alarm system ............................................ 34
Alternator .................................................. 85
Antenna .......................................... 111, 196
Anti-corrosion service............................. 208
Antifreeze........................................ 208, 212
Antifreeze protection ..................... 212, 216
Anti-knock quality of fuel Octane number................................... 220
Anti-theft alarm system ........................... 34
Anti-theft lock Alloy wheels ........................................ 175
Anti-theft lockin g system ......................... 31
Towing equipment ............................. 160
Aquaplaning ........................................... 156
Armrest...................................................... 48
Ashtray ...................................................... 79 Automatic anti-dazzle interior mirror..... 39
AUX input ............................................... 112
Auxiliary heater ...................................... 127
BBattery ............................................ 136, 216
Interruption of power supply ....... 41, 134
Battery discharge protection ................ 110
Before starting off .................................... 15
Belt tensioners .......................................... 60
Bleeding, diesel fuel system .................. 165
Bonnet ..................................................... 165
Boot, see Luggage compartment..... 32, 53
Brake assist ............................................. 153
Brake fluid ............................................... 208
Brake lamp ............................................. 152
Brake system .......................................... 151
Brakes ABS ...................................................... 152
Brake assist ......................................... 153
Brake fluid ........................................... 214
Brake lamps ........................................ 191
Brake servo unit .................................. 135
Hand brake ......................................... 153
Bulb replacement ................................... 185
Bulbs ........................................................ 184CCapacities ............................................... 230
Car Pass .................................................... 26
Caravan/trailer towing........................... 135
Care ......................................................... 196
Catalytic converter ......................... 145, 166
Central locking system ....................... 28, 30

235
Index
Centre console lighting .................. 108, 109
Changing the remote control battery ..... 29
Changing wheels .................................... 174
Chassis number, see Vehicle identification number ........................... 219
Child restraint system ............................... 65
Child safety locks ................................ 36, 40
Cigarette lighter........................................ 78
Climate control system ........................... 122
Clutch operation ............................. 134, 136
CO2 emissions......................................... 224
Coin holder ................................................ 81
Cold start ................................................. 136
Colour information display ...................... 92
Contrast ..................................................... 96
Control indicator ABS (Anti-lock Brake System) ............ 152
Airbag .................................................... 72
Engine electronics ............................... 143
Exhaust ................................................ 143
Immobiliser ............................................ 27
Control indicators ............................... 10, 82 Adaptive Forward Lighting
(AFL) .............................................. 82, 106
Belt tensioners ....................................... 61
Cruise control ...................................... 148
EPS (Electric Power Steering) ............... 86
ESP (Electronic Stability Program) ..... 146
Coolant ............................................ 208, 212
Coolant level ........................................... 213
Coolant temperature display .................. 88
Coolant thermometer ............................... 88
Cornering light ........................................ 106
Correcting time ......................................... 95 Coupling socket load ............................. 163
Courtesy lamp ........................................ 108
Bulb replacement ............................... 194
Cruise control .......................................... 148
Curtain airbags......................................... 71
Curve lighting ......................................... 106
DDashboard, see Instrument panel .......... 15
Data................................................... 26, 218
Date ........................................................... 92
Daytime running lights........................... 102
Decommissioning ................................... 217
Demisting and defrosting Windows .............................................. 118
with climate control system ............... 124
With the air conditioning system....... 121
Diesel fuel filter ....................................... 212
Diesel fuel system ........................... 165, 212
Diesel particle filter.............41, 86, 136, 144
Dimensions .............................................. 231
Dipped beam ............................................ 11 Bulb replacement ....................... 186, 188
Display....................................................... 90
Display mode ............................................ 96
Door locks ......................................... 26, 198
Driving abroad ....................................... 199 Headlamps.......................................... 110
Toll systems ......................................... 112
Driving hints ............................................ 135
EEasytronic ......................................... 15, 129 Driving programmes .......................... 131
Fault .................................................... 133
Interruption of power supply ............. 134
Kickdown............................................. 132
Selector lever................................. 15, 130
Winter programme ............................. 132
Economical driving ................................. 137
Electric power steering ............................. 86
Electric windows ....................................... 40
Electrical system ............................. 181, 216
Electronic components........................... 216
Electronic immobiliser .............................. 27
Electronic Stability Program .................. 146
Engine code .................................... 220, 221
Engine control indicator ........................ 143
Engine oil ........................................ 207, 210 Additives ............................................. 207
Top up ................................................. 207
Viscosity .............................................. 207
Engine oil consumption ... 135, 210, 220, 221
Engine oil level ........................................ 210
Engine oil pressure ................................... 84
Engine speed .......................................... 136
Engine wash............................................ 198
Environmental protection ...................... 196
EPS ............................................................. 86
ESP (Electronic Stability Program) ........ 146
Exhaust control indicator ...................... 143
Exhaust gases......................................... 144
Exhaust system ....................................... 135

236 IndexExterior lighting switch-off delay........... 107
Exterior mirrors..........................4, 36, 38, 41FFan ........................................................... 114
Fault........................................................... 41
Filling station Engine oil level .................................... 210
Fuel .............................................. 220, 221
Opening the bonnet ........................... 165
Tyre pressure ............................... 138, 228
Vehicle data ................................ 218, 219
Windscreen washer system ................ 215
First-aid kit .............................................. 171
Flat tyre ................................................... 178
FlexSpace .................................................. 52
Fog lamps ............................................... 103 Bulb replacement................................ 191
Fog tail lamp ........................................... 104 Bulb replacement................................ 191
Foot brake ....................................... 151, 153
Front passenger airbag ........................... 67
Fuel ......................................... 139, 220, 221
Fuel consumption ........................... 137, 224
Fuel filter.................................................. 212
Fuel gauge ................................................ 88
Fuel system, diesel .................................. 165
Fuses ........................................................ 181GGears ................................................. 14, 134
Generator, see Alternator ........................ 85
Glasses compartment .............................. 81
Glove compartment ................................. 80 Glove compartment lighting ................. 109
Bulb replacement ............................... 195
Graphical information display ................ 90
Gross vehicle weight............................... 226
Gross vehicle weight rating ................... 226
HHalogen headlamp system ................... 185 Bulb replacement ............................... 185
Driving abroad.................................... 110
Hand brake ....................................... 16, 153
Hazard warning lamps .................... 12, 104
Head restraints ............................. 21, 46, 47
Headlamp flash ........................................ 11
Headlamp range adjustment................ 104
Headlamp switch ............................. 11, 102
Headlamp washer system13, 100, 101, 215
Headlamps ............................................... 11 Daytime running lights ....................... 102
Driving abroad.................................... 110
Fog lamps ........................................... 103
Reversing lamps.................................. 104
Warning device ................................... 100
Headlights Changing bulbs .................................. 185
Heated exterior mirrors................ 13, 38, 41
Heated rear window .................... 13, 38, 41
Heated seats............................................. 46
Heating ........................................... 114, 117 Seats ...................................................... 46
With climate control system .............. 123
With the air conditioning system....... 114 Height adjustment
Seat belts .............................................. 63
Steering wheel .........................................5
High-pressure cleaners .......................... 198
Hill Start Assist ........................................ 153
Horn........................................................... 12
IIdentification plate ......................... 218, 219
Idling ....................................................... 134
Ignition switch..................................... 16, 27
Ignition system ............................... 209, 216
Immobiliser ............................................... 27
Information display .................................. 90
Infotainment system .............................. 111
Instrument display ................................... 87
Instrument illumin ation .......................... 108
Bulb replacement ............................... 196
Instrument pane l ...................................... 15
Instruments ................................... 15, 82, 87
Interior mirror.................................. 4, 38, 39
Interruption of po wer supply ................... 99
Easytronic............................................ 134
Electric sun roof .................................... 43
Electric windows ................................... 41
Electronic Stability Program .............. 147
ISOFIX ....................................................... 79JJack ................................................. 171, 176
Jump leads.............................................. 166

238 IndexRear seats.................................................. 51
Rear window washer system ...13, 101, 215
Refuelling................................................. 140Fuel filler cap ....................................... 141
Remote control Central locking system ......................... 28
Steering wheel ............................... 24, 111
Replacement keys .................................... 26
Reversing lamps...................................... 107 Bulb replacement................................ 191
Roof load .......................... 58, 135, 138, 226
Roof rack ...................................58, 138, 158
Roof racks ......................................... 58, 138
Running-in ............................................... 135 Brakes .................................................. 213SSafeguard against unauthorised use ..................15, 17, 27, 36
Safety accessories .................................. 171
Safety net .................................................. 56
Safety systems ........................................ 111
Saving energy ......................................... 136
Seat adjustment ............................. 2, 44, 51
Seat belts........................................... 62, 198
Seat height adjustment ........................ 3, 45
Seat occupancy recognition .................... 72
Seat position ................................... 2, 44, 45
Seats ...................................................... 2, 44 Extending the luggage
compartment .................................. 32, 53
heated ................................................... 46
Selector lever ........................................... 130
Self-diagnosis ..............................61, 72, 153 Self-help
Central locking ...................................... 31
Electric windows.................................... 40
Information display .............................. 92
Radio remote control ........................... 29
Self-help, care for your car .................... 165
Service interval display .......................... 208
Service intervals ...................................... 199 additional work ................................... 206
hard driving conditions ...................... 206
main inspection .................................. 199
Service work ............................................ 208
Side airbags .............................................. 69
Signal system ...................................... 11, 12
Spare wheel .................................... 172, 174
Speed............................................... 137, 138 Fuel consumption ....................... 137, 138
Speedometer ............................................ 87
Starting the engine.............15, 27, 130, 166 Self-help............................................... 166
Steam-jet cleaners.................................. 198
Steering column lock ................................ 15
Steering wheel adju stment ........................ 5
Steering wheel remote control ........ 24, 111
Stowage compartments .......................... 80
Sun roof ..................................................... 42 Fault....................................................... 43
Sun shade ................................................. 43
Sun visors .................................................. 81
System settings ......................................... 94
TTables ........................................................ 81
Tachometer............................................... 87 Tail lamps ............................................... 102
Bulb replacement ............................... 191
Tank Fuel gauge ............................................ 88
Technical data ....................................... 218
Telephone, see Mob ile telephone ......... 113
Temperature regulation ........................ 123
Tempomat, see cruise control ............... 148
Temporary spare wheel ................. 158, 173
The first 1000 km .................................... 135
Tightening torque .......................... 177, 228
Time........................................................... 92
Toll systems ............................................ 112
Tools ........................................................ 171
Towing equipment ................................. 158
Towing eye ..................................... 168, 170
Transmission ............................................. 14 Manual transmission .......................... 134
Transmission, Easytronic ....................... 129 Driving programmes .......................... 131
fault ..................................................... 133
Interruption of power supply ............. 134
Kickdown............................................. 132
Selector lever................................. 15, 130
Winter programme ............................. 132
Travel Assistant ............................ 22, 48, 49
Tread depth ............................................ 155
Trip computer ..................................... 23, 97
Trip odometer ........................................... 87
Triple information display ....................... 90
Turn signal lamps ............................. 11, 103
Turn signals Bulb replacement ....................... 190, 191
Twin Audio ........................................ 24, 112

239
Index
Tyre chains ...................................... 157, 228
Tyre condition ......................................... 155
Tyre pressure................................... 154, 228
Tyre repair kit .......................................... 178UUnits of measure....................................... 96
Unleaded fuel ........................ 142, 220, 221VValve cap key ......................................... 154
Vehicle care............................................. 196
Vehicle decommissioning....................... 217
Vehicle identification number................ 219
Vehicle keys, see Keys .............................. 26
Vehicle recommissioning........................ 217
Ventilation .............................. 114, 117, 125WWarning buzzers..................................... 100
Warning triangle ..................................... 171
Washer fluid reservoir, windscreen washer system .................. 215
Weights.................................................... 226
Wheels ..................................................... 153
Wheels, tyres ........................................... 153
Windows .................................................... 39 Demisting and defrosting . 118, 121, 124
Windscreen washer system............................. 13, 100, 101, 215Antifreeze protection.......................... 216
Washer fluid reservoir......................... 215
Windscreen wipers ....................12, 100, 215 Winter mode
Starting-off aid ................................... 132
Winter operation Battery ................................................. 136
Coolant, antifreeze ............................. 212
Fuel consumption ............................... 138
Fuel for diesel engines........................ 139
Heating................................................ 114
Locks .................................................... 198
Tyre chains .................................. 157, 228
Window demisting and
defrosting ............................118, 121, 124
Windscreen washer system,
antifreeze protection .......................... 216
Winter programme ................................. 132
Winter tyres ............................................. 228
XXenon headlamp system Bulb replacement ............................... 188
Driving abroad.................................... 110